用小支板及凹腔组合提高火箭冲压组合发动机的燃烧性能

推进技术 ›› 2012, Vol. 33 ›› Issue (2): 216-220.

用小支板及凹腔组合提高火箭冲压组合发动机的燃烧性能

潘科玮,何国强,秦飞,刘佩进,汤祥

西北工业大学燃烧、热结构和内流场重点实验室,陕西西安 710072;西北工业大学燃烧、热结构和内流场重点实验室,陕西西安 710072;西北工业大学燃烧、热结构和内流场重点实验室,陕西西安 710072;西北工业大学燃烧、热结构和内流场重点实验室,陕西西安 710072;西北工业大学燃烧、热结构和内流场重点实验室,陕西西安 710072

发布日期:2021-08-15
作者简介:潘科玮(1983—),男,博士生,研究领域为航空宇航推进理论与工程。E-mail:pkwsyy@126.com

Combustion Performance of RBCC Engine with Pylon and Cavity at Ramjet Mode

Science and Technology on Combustion, Internal Flow and Thermal-Structure Laboratory,Northwestern Polytechnical University, Xi’an 710072, China;Science and Technology on Combustion, Internal Flow and Thermal-Structure Laboratory,Northwestern Polytechnical University, Xi’an 710072, China;Science and Technology on Combustion, Internal Flow and Thermal-Structure Laboratory,Northwestern Polytechnical University, Xi’an 710072, China;Science and Technology on Combustion, Internal Flow and Thermal-Structure Laboratory,Northwestern Polytechnical University, Xi’an 710072, China;Science and Technology on Combustion, Internal Flow and Thermal-Structure Laboratory,Northwestern Polytechnical University, Xi’an 710072, China

Published:2021-08-15

摘要/Abstract

摘要： 为了研究RBCC亚燃模态的高效稳定燃烧,对小支板及凹腔结合的火焰稳定及燃烧组织方式进行多次试验研究,结果表明,凹腔与支板的火焰稳定及燃烧组织方式能有效地改善燃料的燃烧性能,提升燃烧室压强,凹腔与支板相对位置对燃烧的放热位置及燃烧性能也有影响。为了进一步研究燃烧流场内部参数变化,选取其中一种试验工况进行数值模拟,结果表明,在RBCC混合燃烧模式中,采用支板与凹腔组合的火焰组织及稳定方式,能够在较短距离实现煤油的高效燃烧,获得较好的燃烧性能,并且可以从中发现热力喉道的形成与凹腔的后斜壁收缩有关联,在实现稳定高效燃烧的条件下,获得直扩的双模态燃烧室内较为稳定的热力喉道。 

关键词: 支板;亚燃模态;煤油;热力喉道;数值仿真;试验研究

Abstract: In order to investigate the effective combustion performance in ramjet mode of RBCC, the pylon with cavity was disposed in the chamber of RBCC, and some experiments were taken on the direct-connect experiment system. Through the study, it is showed that the pylon with cavity can improve the combustion performance of fuel and increase the chamber pressure. The results also exhibit that the positions of cavity and pylon in the combustor also affect the combustion performance. For studying more parameters in the combustion flow, one experiment was selected into numerical simulation. Based on the computation results, it shows that the pylon with cavity improves the combustion stabilization, and it provides robust combustion efficiency and wide operability liquid hydrocarbon. And the thermal throat is connected with the rear ramp. It is indicated that good combustion performance can bring thermal throat after cavity.

Key words: Pylon; Ramjet mode; Kerosene; Thermal throat;Numerical simulation;Experiment research

潘科玮,何国强,秦飞,刘佩进,汤祥. 用小支板及凹腔组合提高火箭冲压组合发动机的燃烧性能[J]. 推进技术, 2012, 33(2): 216-220.

参考文献

[2] Takeshi Kanda, Kanenori Kato,Kouichiro Tani, et al.Experimental Study of a Combined-Cycle Engine Combustor in Ejector-Jet Mode[J].Journal of Propulsion and Power,7,3(6).
[3] Kouchi T, Hirano K,Matsuo A,et al.Combustion Performance of Supersonic Combustor with Stinger-Shaped Fuel Injector[R].AIAA 2008-4503.
[4] LIU Xiaowei, HE Guoqiang, LIU Peijin,et al.Investigation of Ignition and Flame Stability in RBCC Ramjet Mode[J].Journal of Solid Rocket Technology,0,3(5).
[5] 吕翔, 何国强, 刘佩进.RBCC飞行器爬升段轨迹设计方法[J].航空学报,2010,31(7).
[6] Onur Tuncer.Combustion in a Ramjet Combustor with Cavity Flame Holder [R].AIAA 2010-1532.
[7] 刘欧子,蔡元虎,胡欲立,等.凹槽火焰稳定器结构对煤油超声速燃烧的影响[J].推进技术,2005,26(4).(LIU Ou-zi,CAI Yuan-hu,HU Yu-li,et al.Effect of the Geometry Configuration of Cavity Flame Holder on Kerosene Combustion in Suppersonic Air Stream[J].Journal of Propulsion Technology,5,6(4).
[8] Doster J C, King P I,Gruber M R,et al.Pylon Fuel Injector Design for a Scramjet Combustor [R].AIAA 2007-5404.
[9] Freeborn A B, King P I,Gruber M R.Swept-Leading-Edge Pylon Effects on a Scramjet Pylon-Cavity Flameholder Flow-Field [J].Journal of Propulsion and Power,9,5(3).
[10] Doster J C, King P I, Gruber M R,et al.In-Stream Hypermixer Fueling Pylons in Supersonic Flow [J].Journal of Propulsion and Power,9,5(4).
[11] Manna P, Ramesh Behera,Debasis Chakraborty.Liquid-Fueled Strut-Based Scramjet Combustor Design:A Computational Fluid Dynamics Approach [J].Journal of Propulsion and Power,8,4(2).
[12] Gerlinger P, Brüggemann D.Numerical Investigation of Hydrogen Strut Injections into Supersonic Airflows[J]. Journal of Propulsion and Power,0,6(3).
[13] Sunami T, Murakami A,Nishioka M.Mixing and Combustion Control Strategies for Efficient Scramjet Operation in Wind Range of Flight Mach Numbers[R].AIAA 2002-5116.
[14] Gruenig C, Avrashkov V,Mayinger F.Fuel Injection into a Supersonic Airflow by Means of Pylons[J].Journal of Propulsion and Power,0,6(1).
[15] Wang T-S.Thermophysics Characterization of Kerosene Combustion[R].AIAA 2000-2511.