预旋进气小尺寸涡轮叶片冷却的流动换热

推进技术 ›› 2012, Vol. 33 ›› Issue (3): 455-462.

预旋进气小尺寸涡轮叶片冷却的流动换热

朱强华,吉洪湖,张勃,曹广州,陈宝延,关胜如

南京航空航天大学能源与动力学院,江苏南京 210016;南京航空航天大学能源与动力学院,江苏南京 210016;南京航空航天大学能源与动力学院,江苏南京 210016;南京航空航天大学能源与动力学院,江苏南京 210016;中国航天科工集团三十一研究所,北京 100074;中国航天科工集团三十一研究所,北京 100074

发布日期:2021-08-15
作者简介:朱强华(1980—),男,博士生,研究领域为传热与传质。E-mail:zqh_0702108@sina.com.cn

Numerical Study on the Pre-Swirl Flow and Heat Transfer Characteristicsof a Small Gas Turbine Blade

College of Energy and Power, Nanjing University of Aeronautics and Astronautics, Nanjing 210016, China;College of Energy and Power, Nanjing University of Aeronautics and Astronautics, Nanjing 210016, China;College of Energy and Power, Nanjing University of Aeronautics and Astronautics, Nanjing 210016, China;College of Energy and Power, Nanjing University of Aeronautics and Astronautics, Nanjing 210016, China;The 31st Research Institute of CASIC, Beijing 100074, China;The 31st Research Institute of CASIC, Beijing 100074, China

Published:2021-08-15

摘要/Abstract

摘要： 为了获得一种具有直通式冷气预旋进气系统的小型燃气轮机涡轮叶片的流动与换热特性,采用气热耦合计算方法进行数值研究,分析了总压损失、冷却效果和涡轮效率随预旋角、冷气雷诺数和无量纲质量流量的变化规律。结果表明,涡轮叶片预旋进气冷却的总压损失随冷气雷诺数和无量纲质量流量的增大而增大,但基本不受预旋角大小的影响；涡轮叶片的冷却效果随预旋角的减小、冷气雷诺数或无量纲质量流量的增大而增强,但不会改变其表面的温度分布特征；预旋进气冷却时的涡轮效率随冷气雷诺数的增大、预旋角或无量纲质量流量的减小而提高。 

关键词: 小型燃气轮机;涡轮叶片;预旋;冷却效率;耦合传热

Abstract: Numerical study of flow and heat transfer characteristics in a rotating cascade of a small gas turbine, which adopted direct-transfer pre-swirl cooling system, was conducted by using ANSYS CFX 12.0.The effects of pre-swirl angle, cooling air Reynolds number and non-dimensional mass flow rate on the total pressure loss, cooling effectiveness and turbine efficiency were analyzed. The results show that total pressure losses of pre-swirl system and temperature distributions on blade are nearly same under various pre-swirl angles. Both cooling efficiency of blade and turbine efficiency increase with the diminishing of pre-swirl angle and non-dimensional mass flow rate or increasing of cooling air Reynolds number. 

Key words: Small gas turbine; Turbine blade; Pre-swirl; Cooling efficiency; Conjugate heat transfer

朱强华,吉洪湖,张勃,曹广州,陈宝延,关胜如. 预旋进气小尺寸涡轮叶片冷却的流动换热[J]. 推进技术, 2012, 33(3): 455-462.

参考文献

[2] 杨小利.旋转涡轮盘腔系统内部流场分布的实验和计算研究[D].西安:西北工业大学, 2005.
[3] Geis T, Dittmann M, Dullenkopf K.Cooling Air Temperature Reduction in a Direct Transfer Pre-Swirl System[R].ASME 2003-GT-38231.
[4] Ciampoli F, Hills N J, Chew J W, et al.Unsteady Numerical Simulation of the Flow in a Direct Transfer Pre-Swirl System[R].ASME 2008-GT-51198.
[5] Popp O, Zimmermann H,Kutz J.CFD Analysis of Cover-Plate Receiver Flow[J]. Journal of Turbomachinery, 8,0(1):43-49.
[6] Karabay H, Chen J X, Pilbrow R, et al.Flow in a “Cover-Plate” Pre-Swirl Rotor-Stator System[J].Journal of Turbomachinery, 9,1(1):160-166.
[7] 丁水汀, 陶智, 徐国强, 等.带预旋进气的旋转空腔平均换热特性研究[J].航空动力学报, 8,3 (3):277-280.
[8] 白洛林, 冯青, 刘松龄, 等.预旋进气的盘腔系统内流场的数值研究[J].推进技术, 3,4(2):135-137.(BAI Luo-lin, FENG Qing, LIU Song-ling, et al.Numerical Investigation on Preswirl Flow in Rotating Disc System[J].Journal of Propulsion Technology, 3,4(2):135-137.)
[9] 冶萍, 张靖周.有预旋进气转静盘腔中的流动和换热特性数值研究[J].航空动力学报, 4,9(3):370-374.
[10] 王锁芳, 朱强华, 栾海峰, 等.高位预旋进气转静盘腔换热实验[J].航空动力学报, 7,2(8) :1216-1221.
[11] ZHU Qiang-hua, JI Hong-hu, WANG Suo-fang.Cooling Air Temperature Reduction and Local Heat Transfer in a Pre-Swirl Shrouded Rotor-Stator System[R].2010-ISJPPE-2005.
[12] 董平, 黄洪雁, 冯国泰.高压燃气涡轮径向内冷叶片气热耦合的数值分析[J].航空动力学报, 8,3(2):201-207.
[13] 张立超, 何建元, 马晓虹.矩阵式高温涡轮叶片热流耦合计算及验证[J].舰船科学技术, 0,2(8):111-116.
[14] 曾军, 张剑, 黄康才.预旋进气转-静盘腔中的流动和传热数值研究[J].航空动力学报, 8,3(7):1168-1173.
[15] 祝昭.转/静交界面处理方法研究及涡轮结构与气动分析[D].南京:南京航空航天大学, 2008.