离心式喷嘴在小尺度受限空间雾化特性的实验研究

推进技术 ›› 2013, Vol. 34 ›› Issue (7): 944-949.

离心式喷嘴在小尺度受限空间雾化特性的实验研究

赵娜,余永刚

南京理工大学能源与动力工程学院,江苏南京 210094;南京理工大学能源与动力工程学院,江苏南京 210094

发布日期:2021-08-15
作者简介:赵娜(1985—),女,博士生,研究领域为液体火箭发动机喷雾燃烧。E-mail:nazhao801@163.com
基金资助:
教育部博士点基金资助项目(20113219110024)。

Experiment Study on Spray Characteristics of the Swirl Injector in Small Scale Chamber

School of Energy and Power Engineering, Nanjing University of Science and Technology, Nanjing 210094, China;School of Energy and Power Engineering, Nanjing University of Science and Technology, Nanjing 210094, China

Published:2021-08-15

摘要/Abstract

摘要： 为了了解小尺度受限空间中离心式喷嘴的雾化特性,设计了四旋流槽离心式喷嘴和小尺度模拟燃烧室,采用相位多普勒粒子动态分析仪(PDA),观测了喷射压力对模拟燃烧室内雾化性能的影响。引入离散系数cv对喷雾场雾化参数的周向分布规律进行了着重分析。结果表明:模拟燃烧室内,喷射压力越大,液滴索特尔平均直径D32的值越小；在z∈[41.5,4.2]的轴向距离范围内,喷射压力对v_z的影响不明显。由于壁面作用,液滴D32的周向分布均匀性随着径向距离的增加变差；距离喷嘴出口越远处,液滴D32的周向分布均匀性越好。在喷射压力相同条件下,同一喷嘴在模拟燃烧室内雾化参数的周向分布均匀性比在大气环境中波动更大。 

关键词: 小尺度空间;离心式喷嘴;雾化;周向分布 

Abstract: To investigate the spray distribution characteristics of the swirl injector in small scale space,a swirl injector with four swirl slots and a simulated small scale chamber were designed. The effects of the injection pressure on the spray parameters in the simulated combustion chamber were studied by using of the PDA system. The circumferential distribution of the spray field was emphasized using the coefficient of variation (cv). The results indicate that the greater the injection pressure, the smaller the liquid droplets D32(Sauter Mean Diameter). For the studied range of axial distance, the effect of the injection pressure on the droplets vz(axial velocity) is not obvious. As for the impaction of the chamber wall, the uniformity of the circumferential distribution of D32 is getting worse along the radial direction. The further away from the nozzle exit, the more uniform the circumferential distribution of liquid droplets D32. Under the same injection pressure, the uniformity of the circumferential distribution of the droplets in the chamber is more fluctuating than that in the atmosphere by using the same injector. 

Key words: Small scale space; Swirl injector; Atomization;Circumferential distribution

赵娜,余永刚. 离心式喷嘴在小尺度受限空间雾化特性的实验研究[J]. 推进技术, 2013, 34(7): 944-949.

ZHAO Na, YU Yong-gang. Experiment Study on Spray Characteristics of the Swirl Injector in Small Scale Chamber[J]. Journal of Propulsion Technology, 2013, 34(7): 944-949.

参考文献

[1] 曾卓雄, 姜培正, 谢蔚明.喷嘴雾化粒径的实验研究[J].西安交通大学学报, 2000,4(5):75-77.
[2] Hamid A H A, Atan R.Spray Characteristics of Jet-Swirl Nozzles for Thrust Chamber Injector[J].Aerospace Science and Technology, 2009,3(4-5):192-196.
[3] Yoon S H, Kim D Y, Kim D K, et al.Effect of Nozzle Geometry for Swirl Type Twin-Fluid Water Mist Nozzle on the Spray Characteristic[J].Journal of Mechanical Science and Technology, 2011,5(7):1761-1766.
[4] 闫云飞,张力,高振宇,等．低压旋流雾化喷嘴的雾化性能[J].化工学报, 2009,0(5):1141-1147.
[5] 杨立军,葛明和,张向阳,等．喷口长度对离心喷嘴雾化特性的影响[J]．推进技术,2005,6(3):209-214.(YANG Li-jun, GE Ming-he, ZHANG Xiang-yang, et al.Effects of Spout Length on Spray Characteristic of Swirl Injector[J].Journal of Propulsion Technology, 2005,6(3):209-214.)
[6] 杨立军,葛明和,张向阳.液体离心喷嘴喷雾场动态特性的初步研究[J].航空动力学报, 2005,0(6).
[7] 张征,樊未军,杨茂林.双路离心式喷嘴雾化特性研究[J].工程热物理学报, 2003,4(1):153-156.
[8] Moon S, Abo-Serie E, Bae C.The Spray Characterustics of a Pressure-Swirl Injector with Various Exit Plane Tilts[J].International Journal of Multiphase Flow, 2008,4(7):615-627.
[9] 张慧明, 赵奎翰, 魏建勤, 等.小型直喷式柴油机燃烧室内喷雾碰壁的实验研究[J].工程热物理学报, 1996,7(3):362-366.
[10] 成晓北, 黄荣华.柴油机燃油喷射雾化的PIV测量实验研究[J].燃烧科学与技术, 2003,9(3):224-228.
[11] Nishida K, Tian J, Sumoto Y, et al.An Experimental and Numerical Study on Sprays Injected From Two-Hole Nozzles for DISI Engines[J].Fuel, 2009,8(9).
[12] Chen S K, Lefebvre A H, Rollbuhler J.Factors Influencing the Circumferential Liquid Distribution from Pressure-Swirl Atomizers[J].Journal of Engineering for Gas Turbines and Power, 1993,5(3):447-452.
[13] Locke R J, Hicks Y R, Anderson R C, et al.Optical Fuel Injector Patternation Measurements in Adcanced Liquid-Fueled, High Pressure, Gas Turbine Combustors[J].Combustion Science and Technology, 1998,8(1/6):297-311.
[14] 焦树建.燃气轮机燃速室[M].北京:机械工业出版社, 1990.
[15] 邢小军,徐行,郭志辉,等．模型燃烧室冷态喷雾场的实验研究[J]．推进技术,2000,1(5)．(XING Xiao-jun, XU Hang, GUO Zhi-hui, et al.Experimental Study on Spray Field in Combustor by Phase Dopplor Analyzer[J].Journal of Propulsion Technology, 2000,1(5).)
[16] 贾俊平.统计学[M].北京:清华大学出版社,2006.