垂直上升圆管内超临界航空煤油的传热恶化数值研究

推进技术 ›› 2015, Vol. 36 ›› Issue (1): 97-103.

垂直上升圆管内超临界航空煤油的传热恶化数值研究

王彦红,李素芬,东明

大连理工大学能源与动力学院，辽宁大连 116024,大连理工大学能源与动力学院，辽宁大连 116024,大连理工大学能源与动力学院，辽宁大连 116024

发布日期:2021-08-15
作者简介:王彦红(1983—)，男，博士生，研究领域为超临界压力碳氢燃料对流换热。E-mail:wangyh.526@163.com 通讯作者:李素芬(1955—)，女，硕士，教授，研究领域为超临界介质传热与压降特性。

Numerical Study on Heat Transfer Deterioration of Supercritical Aviation Kerosene in Vertical Upward Circular Tubes

School of Energy and Power Engineering，Dalian University of Technology，Dalian 116024，China,School of Energy and Power Engineering，Dalian University of Technology，Dalian 116024，China and School of Energy and Power Engineering，Dalian University of Technology，Dalian 116024，China

Published:2021-08-15

摘要/Abstract

摘要： 采用RNG k-ε湍流模型结合增强壁面处理的方法以及10组分替代模型对RP-3航空煤油在垂直上升圆管内的超临界对流换热进行了数值研究。详细分析了超临界条件下航空煤油的传热恶化机理，并将数值计算结果与常用经验换热公式值进行了比较，以考察这些经验关系式的适用性。计算结果表明:在较高的热流密度下，热物性的剧烈变化使径向流场产生异变，引发了复杂的传热恶化现象。其中，低主流焓值区的传热恶化是由热加速作用导致的，高主流焓值区的传热恶化是由径向速度波动造成的。Bae-Kim关系式能较好地反映垂直上升圆管中航空煤油的超临界传热情况，预测值与模拟值的相对误差均在20%以内；而Bishop等给出的经验公式则不再适用。

关键词: 超临界压力；航空煤油；传热恶化；数值研究

Abstract: Numerical study on supercritical convective heat transfer of RP-3 aviation kerosene in vertical upward circular tubes has been carried out，based on the RNG k-ε turbulence model with enhanced wall treatment，and a 10-species kerosene surrogate model. The heat transfer deterioration mechanisms of aviation kerosene under supercritical conditions were analyzed in detail. Moreover，the numerical results have been compared with several conventional empirical heat transfer formulae to investigate the applicability of these expressions. Results indicate that under relatively high heat fluxes，the abrupt thermophysical properties variations significantly modify the radial flow fields，leading further to complex heat transfer deterioration phenomena. The heat transfer deterioration in the low bulk enthalpy region is caused by thermal acceleration，whereas the heat transfer deterioration in the high bulk enthalpy region is due to the radial velocity oscillation. The Bae-Kim formula can be better used for supercritical heat transfer predictions of aviation kerosene in vertical upward circular tubes. The relative errors between the predicted values and numerical results are generally within 20%，while the empirical expression proposed by Bishop et al. is no longer applicable.

Key words: Supercritical pressure；Aviation kerosene；Heat transfer deterioration;；Numerical study

王彦红,李素芬,东明. 垂直上升圆管内超临界航空煤油的传热恶化数值研究[J]. 推进技术, 2015, 36(1): 97-103.

WANG Yan-hong, LI Su-fen, Dong Ming. Numerical Study on Heat Transfer Deterioration of Supercritical Aviation Kerosene in Vertical Upward Circular Tubes[J]. Journal of Propulsion Technology, 2015, 36(1): 97-103.

参考文献

[1] Lander H R, Nixon A C. Endothermic Fuels for High Mach Vehicles[J]. American Chemical Society, Division of Petroleum Chemistry, 1987, 32(2): 504-511.
[2] 黄文, 邓宏武, 徐国强, 等. U型管内超临界压力航空煤油压降特性[J]. 航空动力学报, 2011, 26(3):582-587.
[3] 范学军, 俞刚. 大庆RP-3航空煤油热物性分析[J]. 推进技术, 2006, 27(2): 187-192. (FAN Xue-jun, YU Gang.Analysis of Thermophysical Properties of Daqing RP-3 Aviation Kerosene[J]. Journal of Propulsion Technology, 2006, 27 (2): 187-192.)
[4] Koshizuka S, Takano N, Oka Y. Numerical Analysis of Deterioration Phenomena in Heat Transfer to Supercritical Water[J]. International Journal of Heat and Mass Transfer, 1995,38(16): 3077-3084.
[5] Zhang G, Zhang H, Gu H Y, et al. Experimental and Numerical Investigation of Turbulent Convective Heat Transfer Deterioration of Supercritical Water in Vertical Tube[J]. Nuclear Engineering and Design, 2012, 248:226-237.
[6] Kim D K, Kim M H. Experimental Study of the Effects of Flow Acceleration and Buoyancy on Heat Transfer in a Supercritical Fluid Flow in a Circular Tube[J]. Nuclear Engineering and Design, 2010, 240(10): 3336-3349.
[7] 李志辉, 姜培学, 赵陈儒, 等. 超临界CO₂在垂直圆管内对流换热实验研究[J]. 工程热物理学报, 2008,29(3): 461-464.
[8] Kelbaliev R F. Deterioration of Heat Transfer at Supercritical Pressures of a Substance[J]. Journal of Engineering Physics and Thermophysics, 2001, 74(2): 416-420.
[9] Linne D L, Meyer M L, Edwards T, et al. Evaluation of Heat Transfer and Thermal Stability of Supercritical JP-7 Fuel [R]. AIAA 97-3041.
[10] Hitch B, Karpuk M. Experimental Investigation of Heat Transfer and Flow Instabilities in Supercritical Fuels [R].AIAA 97-3043.
[11] Liu Z H, Bi Q C, Guo Y, et al. Convective Heat Transfer and Pressure Drop Characteristics of Near-Critical-pressure Hydrocarbon Fuel in a Minichannel[J]. Applied Thermal Engineering, 2013, 51(1-2): 1047-1054.
[12] 屈云凤, 周伟星, 鲍文. 超临界压力下戊烷传热恶化的数值研究[C]. 上海:中国工程热物理年会, 2010.
[13] Fan X J , Yu G, Li J G, et al. Effects of Entry Conditions on Cracked Kerosene Fueled Supersonic Combustor Performance [J]. Combustion Science and Technology, 2007, 179(10): 2199-2217.
[14] 陶文铨. 数值传热学(第2版)[M]. 西安:西安交通大学出版社, 2001.
[15] Zhong F Q, Fan X J , Yu G, et al. Heat Transfer of Aviation Kerosene at Supercritical Conditions[J].Journal of Thermophysics and Heat Transfer, 2009,23(3):543-550.
[16] 王夕, 刘波, 祝银海, 等. 超临界压力下RP-3在细圆管内对流换热实验研究[C]. 重庆:中国工程热物理年会, 2013.
[17] 闫晓, 臧金光, 曾小康, 等. 基于二级相变理论的超临界拟临界区划分方法[J]. 核动力工程, 2013, 34(1): 108-113.