预设堵块法检测进气道自起动能力的数值研究

推进技术 ›› 2016, Vol. 37 ›› Issue (10): 1810-1818.

预设堵块法检测进气道自起动能力的数值研究

李祝飞,杨基明

中国科学技术大学近代力学系，安徽合肥 230027,中国科学技术大学近代力学系，安徽合肥 230027

发布日期:2021-08-15
作者简介:李祝飞，男，博士，研究领域为高超声速进气道。 E-mail: lizhufei@mail.ustc.edu.cn 通讯作者:杨基明，男，博士，教授，研究领域为空气动力学与实验流体力学。
基金资助:
国家自然科学基金(11402263；11132010)；中国博士后科学基金(2014M551818)；

A Numerical Investigation of Pre-Setting-Blockage Method to Detect Self-Starting Ability of an Inlet

Department of Modern Mechanics，University of Science and Technology of China，Hefei 230027，China and Department of Modern Mechanics，University of Science and Technology of China，Hefei 230027，China

Published:2021-08-15

摘要/Abstract

摘要： 在进气道内预先设置轻质堵块迫使进气道不起动，堵块被气流吹出后流道恢复畅通，为激波风洞提供了一种检测进气道自起动能力的方法。为了深入认识预设堵块方法的检测过程，将堵块简化为一个自由度的刚体运动，采用k-ω SST湍流模型，结合铺层动网格技术，对该检测方法进行了二维非定常数值模拟。在Ma∞ = 5.9条件下，采用改变堵块质量的方式，获得了三种典型的检测过程。通过分析堵块在气动力作用下的运动与进气道非定常波系演化相互耦合的过程，揭示了堵塞作用产生和消除的流动机理。结果表明，堵塞时间没有显著地改变进气道的自起动能力，预设堵块方法成功检测到进气道在Ma∞= 4.9自起动。此外，建立了预估堵块运动的匀加速模型，预估的堵塞时间与数值模拟结果较为符合。在Ma∞ = 5.9条件下，堵块的临界质量约为3.8g。考虑到激波风洞实验时间短暂，应选择合适的堵块。

关键词: 高超声速进气道；自起动；数值模拟；动网格；激波风洞

Abstract: A testing method to detect an inlet self-starting ability in shock tunnels by pre-setting a blockage in the inlet is presented. The blockage can force the inlet to unstart at the initial testing phase，and then be blown out to open the flow path for the inlet re-starting. To thoroughly study the testing process，the motion of the blockage was simplified as a rigid body with one degree of freedom，and then two-dimensional numerical simulations were performed by applying dynamic mesh technique of layering. The k-ω SST turbulence model was used for the complex flow. Three typical types of flow in the testing process were obtained by varying the mass of the blockage at Ma∞=5.9. The aerodynamics of the blockage combine with the involved unsteady flow features in the inlet was discussed to better understand the physical mechanism of the testing process. The results indicate that the blockage duration does not affect the inlet self-starting ability. The pre-setting-blockage method successfully detect the inlet self-starting process at Ma∞=4.9. Moreover，a uniformly accelerating model was proposed to pre-estimate the motion of the blockage，and the results agree reasonably well with the simulations. The critical mass of the blockage is approximately of 3.8g at Ma∞=5.9. In consideration of the limited test time of shock tunnels，a suitable blockage is recommended to detect the self-starting ability of an inlet.

Key words: Hypersonic inlet；Self-starting；Numerical simulation；Dynamic mesh；Shock tunnel

李祝飞,杨基明. 预设堵块法检测进气道自起动能力的数值研究[J]. 推进技术, 2016, 37(10): 1810-1818.

LI Zhu-fei,YANG Ji-ming. A Numerical Investigation of Pre-Setting-Blockage Method to Detect Self-Starting Ability of an Inlet[J]. Journal of Propulsion Technology, 2016, 37(10): 1810-1818.

参考文献

[1] Curran E T, Murthy S N B. Scramjet Propulsion[M]. New York: AIAA, 2000: 447-511.
[2] Kantrowitz A, Donaldson C D. Preliminary Investigation of Supersonic Diffusers[R]. NACA-WR-L-713, 1945.
[3] M?lder S, Timofeev E V, Tahir R B. Flow Starting in High Compression Hypersonic Air Inlets by Mass Spillage[R]. AIAA 2004-4130.
[4] Veillard X, Tahir R, Timofeev E, et al. Limiting Contractions for Starting Simple Ramp-Type Scramjet Intakes with Overboard Spillage[J]. Journal of Propulsion and Power, 2008, 24(5): 1042-1049.
[5] 王成鹏, 程克明. 高超进气道临界起动特征[J]. 航空动力学报, 2008, 23(6): 997-1001.
[6] Sun B. Zhang K Y. Empirical Equation for Self-Starting Limit of Supersonic Inlets[J]. Journal of Propulsion and Power, 2010, 26(4): 874-875.
[7] Van Wie D M , Kwok F T, Walsh R F. Starting Characteristics of Supersonic Inlets[R]. AIAA 96-2914.
[8] Rodi P E, Emami S, Trexler C A. Unsteady Pressure Behavior in a Ramjet/Scramjet Inlet[J]. Journal of Propulsion and Power, 1996, 12(3): 486-493.
[9] 潘瑾, 张堃元. 移动唇口变收缩比侧压式进气道反压特性和自起动性能[J]. 航空动力学报, 2009, 24(1): 104-109.
[10] Smart M K. Experimental Testing of a Hypersonic Inlet with Rectangular-to-Elliptical Shape Transition[J]. Journal of Propulsion and Power, 2001, 17(2): 276-283.
[11] Tan H J, Li L G, Wen Y F, et al. Experimental Investigation of the Unstart Process of a Generic Hypersonic Inlet[J]. AIAA Journal, 2011, 49(2): 279-288.
[12] 杨大伟, 余安远, 刘伟雄, 等. 高超声速进气道自起动特性高焓风洞试验研究[C]. 北京:中国力学学会学术大会, 2011.
[13] 孙姝, 张红英, 程克明, 等. 喷流反压模拟技术及在高超声速进气道实验中的应用[J]. 航空动力学报, 2007, (10): 1667-1672.
[14] Buttsworth D R, Smart M K. Development of a Ludwieg Tube with Free Piston Compression Heating for Scramjet Inlet Starting Experiments[R]. AIAA 2010-588.
[15] Holden M S, Wadhams T P, MacLean M. Experimental Studies in the LENS Supersonic and Hypersonic Tunnels for Hypervelocity Vehicle Performance and Code Validation [R]. AIAA 2008-2505.
[16] Holden M S, Smolinski G J, Mundy E, et al. Experimental Studies for Hypersonic Vehicle Design and Code Validation of the Unsteady Flow Characteristics Associated with “Free Flight” Shroud and Stage Separation, and Mode Switching [R]. AIAA 2008-642.
[17] Walker S H, Rodgers F C, Esposita A L. Hypersonic Collaborative Australia/United States Experiment (HyCAUSE)[R]. AIAA 2005-3254.
[18] 岳连捷, 刘红, 徐骁, 等. 激波风洞进气道自起动实验方法[C]. 杭州:第九届全国实验流体力学学术会议, 2013.
[19] 李祝飞, 高文智, 李鹏, 等. 一种进气道自起动特性检测方法 [J]. 实验流体力学, 2013, 27(2): 14-18.
[20] Li Z, Huang B, Yang J. A Novel Test of Starting Characteristics of Hypersonic Inlets in Shock Tunnel[R]. AIAA 2011-2308.
[21] Saito T, Takayama K. Numerical Simulations of Nozzle Starting Process[J]. Shock Waves, 1999, 9(2): 73-79.
[22] H?berle J, Gülhan A. Investigation of Two-Dimensional Scramjet Inlet Flowfield at Mach 7[J]. Journal of Propulsion and Power, 2008, 24(3): 446-459.
[23] Zhufei Li, Wenzhi Gao, Hongliang Jiang, et al. Unsteady Behaviors of a Hypersonic Inlet Caused by Throttling in Shock Tunnel[J]. AIAA Journal, 2013, 51(10): 2485-2492.
[24] 李祝飞. 高超声速进气道起动特性机理研究[D]. 合肥:中国科学技术大学, 2013.
[25] 李祝飞, 高文智, 李鹏, 等. 二元高超声速进气道激波振荡特性实验[J]. 推进技术, 2012, 33(5): 676-682. (LI Zhu-fei, GAO Wen-zhi, LI Peng, et al. Experimental Investigation on the Shock Wave Oscillation Behaviors in a Two-Dimensional Hypersonic Inlet Flow[J]. Journal of Propulsion Technology, 2012, 33(5): 676-682.)
[26] 游进, 夏智勋, 王登攀, 等. 高超声速进气道再起动特性及其影响因素数值模拟[J]. 固体火箭技术, 2011, 34(2): 161-166.　　　　　　　　　　　　　*　收稿日期:2015-05-24；修订日期:2015-07-27。基金项目:国家自然科学基金(11402263；11132010)；中国博士后科学基金(2014M551818)；中央高校基本科研业务费专项资金资助(WK2090050030)。作者简介:李祝飞,男,博士,研究领域为高超声速进气道。 E-mail: lizhufei@mail.ustc.edu.cn 通讯作者:杨基明,男,博士,教授,研究领域为空气动力学与实验流体力学。 E-mail: jmyang@ustc.edu.cnFig.8　Bottom wall pressure x-t diagram of the medium blockage (Case B) at Ma∞=5.9 (编辑:史亚红)