具有局部非线性刚度的复杂转子系统动力学模型及振动特性分析 *

推进技术 ›› 2016, Vol. 37 ›› Issue (12): 2343-2351.

具有局部非线性刚度的复杂转子系统动力学模型及振动特性分析 *

于平超¹,马艳红^1,2,张大义^1,2,洪杰^1,2

北京航空航天大学能源与动力工程学院，北京 100191,北京航空航天大学能源与动力工程学院，北京 100191; 先进航空发动机协同创新中心，北京 100191,北京航空航天大学能源与动力工程学院，北京 100191; 先进航空发动机协同创新中心，北京 100191,北京航空航天大学能源与动力工程学院，北京 100191; 先进航空发动机协同创新中心，北京 100191

发布日期:2021-08-15
作者简介:于平超，男，硕士生，研究领域为航空发动机整机振动、转子动力学。

Dynamic Model and Vibration Characteristic Analysis on Complex Rotor System with Local Nonlinear Stiffness

School of Energy and Power Engineering，Beihang University，Beijing 100191，China,School of Energy and Power Engineering，Beihang University，Beijing 100191，China; Collaborative Innovation Center of Advanced Aero-Engine，Beijing 100191，China,School of Energy and Power Engineering，Beihang University，Beijing 100191，China; Collaborative Innovation Center of Advanced Aero-Engine，Beijing 100191，China and School of Energy and Power Engineering，Beihang University，Beijing 100191，China; Collaborative Innovation Center of Advanced Aero-Engine，Beijing 100191，China

Published:2021-08-15

摘要/Abstract

摘要： 为了更加精确地预测航空发动机高速柔性转子系统振动响应，为整机振动抑制提供技术支撑，以实际航空发动机转子系统为对象，对其主体结构特征及其连接结构所引起的弯曲刚度非线性特征进行了论述，在此之上建立了其动力学模型。针对这种具有局部非线性刚度的复杂转子系统动力学模型，结合FFT和Broyden迭代方法发展了一种数值谐波平衡法，通过频域方程中的自由度缩减，降低了方程规模，大幅度提高了求解效率。将该方法应用于试验转子的动力特性求解，结果表明:本文方法相比经典数值积分方法可以节省10倍以上时间。采用此方法对涡扇发动机低压转子系统在局部非线性刚度下的动力响应规律进行了分析，论证了论文方法的工程适用性。

关键词: 局部非线性刚度；柔性转子系统；数值谐波平衡法；振动响应

Abstract: In order to predict the vibration response of the high-speed flexible rotor system in aero-engine more accurately and provide technical support for the vibration suppression of the whole engine，dynamical model with respect to rotor system of practical aero-engine is established on the basis of investigating the characteristics of its main structure and nonlinear characteristics of bending stiffness resulting from joint structure. Then numerical harmonic balance method with FFT and Broyden method was put forward to solve the dynamic model，and the degree of freedom was condensed in frequency domain，which can reduce the size of equation and improve the solving efficiency. The method is applied to a test rotor，and the results show that the method in this paper can be 10 times faster than traditional numerical integration. Vibration response of the low rotor system in aero-engine with nonlinear support was analyzed using this paper’s method，which indicated the applicability of the method in engineering.

Key words: Local nonlinear stiffness；Flexible rotor system；Numerical harmonic balance method；Vibration response

于平超,马艳红,张大义,洪杰. 具有局部非线性刚度的复杂转子系统动力学模型及振动特性分析 *[J]. 推进技术, 2016, 37(12): 2343-2351.

YU Ping-chao¹,MA Yan-hong^1,2,ZHANG Da-yi^1,2,HONG Jie^1,2. Dynamic Model and Vibration Characteristic Analysis on Complex Rotor System with Local Nonlinear Stiffness[J]. Journal of Propulsion Technology, 2016, 37(12): 2343-2351.

参考文献

[1] 杨喜关, 罗贵火, 唐振寰, 等. 高维反向旋转双转子系统的建模方法及动力特性[J]. 航空动力学报, 2014, 29(3): 585-595.
[2] 杨喜关, 罗贵火, 温卫东, 等. 支承非线性特性对双转子系统的响应特性影响研究[J]. 振动工程学报, 2014, 27(4): 572-582.
[3] 罗贵火, 周海仑, 王飞, 等. 含滚动轴承的同向和反向旋转双转子系统动力学响应[J]. 航空动力学报, 2012, 27(8): 1887-1894.
[4] 邓四二, 贺凤祥, 杨海生, 等. 航空发动机双转子-滚动轴承耦合系统的动力特性分析[J]. 航空动力学报, 2010 (10): 2386-2395.
[5] Chen Guo. Vibration Modeling and Verification for Whole Aero-Engine[J]. Journal of Sound and Vibration, 2015, 349(4): 163-176.
[6] 陈果. 航空发动机整机振动耦合动力学模型及其验证[J]. 航空动力学报, 2012, 27(2): 241-254.
[7] 张大义, 刘烨辉, 梁智超, 等. 航空发动机双转子系统临界转速求解方法[J]. 推进技术, 2015, 36 (2): 292-298. (ZHANG Da-yi, LIU Ye-hui, LIANG Zhi-chao, et al. Prediction for Critical Speed of Double Spools System in Aero Engines[J]. Journal of Propulsion Technology, 2015, 36 (2): 292-298.)
[8] 张大义, 刘烨辉, 洪杰, 等. 航空发动机整机动力学模型建立与振动特性分析[J]. 推进技术, 2015, 26(5). (ZHANG Da-yi, LIU Ye-hui, HONG Jie, et al. Investigation on the Dynamical Modeling and Vibration Characteristics for the Whole Gas Engine[J]. Journal of Propulsion Technology, 2015, 26(5).)
[9] Villa C, Sinou J J, Thouverez F. Stability and Vibration Analysis of a Complex Flexible Rotor Bearing System[J]. Communications in Nonlinear Science and Numerical Simulation, 2008, 13(4): 804-821.
[10] Peletan L, Baguet S, Jacquet-Richardet G, et al. Use and Limitations of the Harmonic Balance Method for Rub-Impact Phenomena in Rotor-Stator Dynamics[R]. ASME 2012-GT-69450.
[11] Von Groll G, Ewins D J. The Harmonic Balance Method with Arc-Length Continuation in Rotor/Stator Contact Problems[J]. Journal of Sound and Vibration, 2001, 241(2): 223-233.
[12] Sinou J J. Non-Linear Dynamics and Contacts of an Unbalanced Flexible Rotor Supported on Ball Bearings[J]. Mechanism and Machine Theory, 2009, 44(9): 1713-1732.
[13] Zhang Z, Chen Y. Harmonic Balance Method with Alternating Frequency/Time Domain Technique for Nonlinear Dynamical System with Fractional Exponential[J]. Applied Mathematics and Mechanics, 2014, 35: 423-436.
[14] 何天元. 航空发动机局部刚度非线性转子系统动力响应研究[D]. 北京:北京航空航天大学, 2013.
[15] Yamamoto T, Ishida Y, Ikeda T, et al. Super-Summed-and-Differential Harmonic Oscillations of an Unsymmetrical Rotor[J]. Bulletin of JSME, 1981, 24(187): 192-199.
[16] 马艳红, 何天元, 张大义, 等. 支承刚度非线性转子系统的不平衡响应[J]. 航空动力学报, 2014, 29(7): 1527-1534.
[17] Shuguo L, Yanhong M, Dayi Z, et al. Studies on Dynamic Characteristics of the Joint in the Aero-Engine Rotor System[J]. Mechanical Systems and Signal Processing, 2012, 29: 120-136.
[18] Zhang Q, Li W, Liang Z, et al. Study on the Stiffness Loss and Its Affecting Factors of the Spline Joint Used in Rotor Systems[R]. ASME 2014-GT-26176
[19] 陈果. 航空器检测与诊断技术导论[M]. 北京:中国民航出版社, 2007.
[20] 李家瑞. 航空发动机建模技术研究[D]. 南京:南京航空航天大学, 2005. 　　　　　　　　　　　　　*　收稿日期:2015-04-23；修订日期:2015-08-25。作者简介:于平超,男,硕士生,研究领域为航空发动机整机振动、转子动力学。E-mail: 1227463613@qq.com(编辑:梅瑛)