基于李亚普诺夫稳定性理论的压气机失速主动控制方法

推进技术 ›› 2017, Vol. 38 ›› Issue (11): 2488-2495.

基于李亚普诺夫稳定性理论的压气机失速主动控制方法

刘俊杰¹,苏三买¹,孙占恒²,刘超¹

西北工业大学动力与能源学院，陕西西安 710072,西北工业大学动力与能源学院，陕西西安 710072,中国航发湖南动力机械研究所，湖南株洲 412002,西北工业大学动力与能源学院，陕西西安 710072

发布日期:2021-08-15
作者简介:刘俊杰，男，硕士生，研究领域为航空发动机控制。
基金资助:
航空科学基金(2013ZB53019)。

Compressor Stall Active Control Method Based on Lyapunov Stability Theory

School of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China,School of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China,AECC Hunan Aviation Powerplant Research Institute，Zhuzhou 412002，China and School of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China

Published:2021-08-15

摘要/Abstract

摘要： 针对压气机主动稳定控制方法中模态控制需要大量传感器及高频执行装置的不足，以喷气装置作为失速控制的执行机构，基于李亚普诺夫稳定性理论，利用回溯法设计了采用周向同步喷气的压气机预失速和过失速阶段的失速控制算法。理论分析和仿真结果表明，采用该方法，在预失速阶段，经过约1.1s持续喷气后，扰动的各阶模态的幅值均趋于0，各阶模态的相位均趋于恒定；在过失速阶段，持续约0.1s的喷气控制后，扰动的各阶模态被完全抑制，其各阶幅值趋于0，各阶模态相位趋于恒定；实现了对预失速和过失速的有效控制。由于以平均流量作为反馈输入，该方法只需安装少量传感器，且喷气装置的作动频率不高于50Hz，远低于模态控制方法。此外，采用同步喷气，也降低了执行机构的复杂性。

关键词: 压气机；失速；李亚普诺夫稳定性理论；主动稳定控制

Abstract: Aiming at solving the problem that modal control requires a multitude of sensors and high-frequency execution in the compressor active stability control，the control algorithms of compressor pre-stall and full-stall with circumferential synchronous jet were designed by the Backstep method，based on Lyapunov stability theory. It is proved by theoretical analysis and numerical simulation that，with this method，in the pre-stall stage，after about 1.1s continuous jet，the amplitude of each order modal of disturbance tends to be zero and the phase of each order modal tends to be constant. In the post-stall stage，after about 0.1s jet control，each order modal of the disturbance is completely suppressed，while the amplitude of each order modal tends to be zero and the phase of each order modal tends to be constant，which makes the effective control of pre-stall and post-stall realized. Using the mean flow as feedback input，this method only requires a small number of sensors，and the actuation frequency of the jet device is no higher than 50Hz，far below than the frequency in the modal control method. Besides，with the synchronous jet，it reduces the complexity of actuators.

Key words: Compressor；Stall；Lyapunov stability theory；Active stability control

刘俊杰,苏三买,孙占恒,刘超. 基于李亚普诺夫稳定性理论的压气机失速主动控制方法[J]. 推进技术, 2017, 38(11): 2488-2495.

LIU Jun-jie¹,SU San-mai¹,SUN Zhan-heng²,LIU Chao¹. Compressor Stall Active Control Method Based on Lyapunov Stability Theory[J]. Journal of Propulsion Technology, 2017, 38(11): 2488-2495.

参考文献

[1] 楚武利, 刘前智, 胡春波. 航空叶片机原理[M]. 西安:西北工业大学出版社, 2009.
[2] 苏三买, 吕烨, 黄顺炳. 航空发动机主动稳定控制方法分析[J]. 航空工程进展, 2014, 5(1): 7-11.
[3] 童志庭, 聂超群, 朱俊强. 微喷气提高轴流压气机稳定性的研究[J]. 工程热物理学报, 2006, 27(1): 121-124.
[4] 于兰兰, 胡骏, 屠宝锋, 等. 轴流压缩系统中主动抑制旋转失速的数值模拟[J]. 航空动力学报, 2010, 25(1): 92-101.
[5] 王健, 李应红, 张东方, 等. 基于分岔理论的轴流式压气机旋转失速主动控制技术[J]. 航空动力学报, 2007, 22(7): 1179-1183.
[6] Epstein A H, Fowcs Williams J E, Greitzer E M. Active Suppression of Aero Dynamic Instabilities in Turbomachines[J]. Journal of Propulsion and Power, 1989, 5(2): 204-211.
[7] Hendricks G J, Gysling D L. Theoretical Study of Sensor-Actuator Schemes for Rotating Stall Control[J]. Journal of Propulsion and Power, 1994, 10(1): 101-109.
[8] Paduano J D. Active Control of Rotating Stall in Axial Compressors[D]. Cambridge: Massachusetts Institute of Technology, 1992.
[9] Joel M Haynes. Active Control of Rotating Stall in a Three Stage Axial Compressor[D]. San Francisco: Massachusetts Institute of Technology, 1993.
[10] 吴艳辉, 稂仿玉, 吴俊峰, 等. 叶尖喷气影响压气机近失速流场特征的数值研究[J]. 推进技术, 2014, 35(2): 195-201. (WU Yan-hui, LANG Fang-yu, WU Jun-feng, et al. Numerical Investigation of Impact of Tip Injection on Dynamic Flow Characteristics in an Axial-Flow Compressor Rotor[J]. Journal of Propulsion Technology, 2014, 35(2): 195-201.)
[11] 孙占恒. 航空发动机主动稳定控制方法研究[D]. 西安:西北工业大学, 2016.
[12] Gysling D L. Dynamic Control of Rotating Stall in Axial Flow Compressors Using Aeromechanical Feedback[D].Cambridge: Massachusetts Institute of Technology, 1993.
[13] 胡晓煜. 航空发动机的主动控制技术[J]. 国际航空, 2004, (7): 52-53.
[14] Day I G. Active Suppression of Rotation Stall and Surge in Axial Compressor[R]. ASME 1991-87.
[15] Mansoux C A, Gysling D L, Setiawan J D, et al. Distributed Nonlinear Modeling and Stability Analysis of Axial Compressor Stall and Surge[D]. Baltimore, Massachusetts Institute of Technology, 1994: 2305-2316.
[16] 苏三买, 孙占恒, 吕烨, 等. 压气机失速与喘振动态模型与仿真[J]. 推进技术, 2016, 37(5): 960-965. (SU San-mai, SUN Zhan-heng, LV Ye, et al. Dynamic Model and Simulation of Compressor Rotating Stall and Surge[J]. Journal of Propulsion Technology, 2016, 37(5): 960-965.)
[17] Moore F K, Greitzer E M. A Theory of Post Stall Transients in Axial Compression Systems,Part I: Development of Equations[J]. Journal of Engineering for Gas Turbines and Power, 1986, 108(1): 68-76.
[18] Behnken R L. Nonlinear Control and Modeling of Rotating Stall in an Axial Flow Compressor[D]. California: California Institute of Technology Pasadena, 1996.(编辑:田佳莹)　　　　　　　　　　　　　*　收稿日期:2016-06-08；修订日期:2016-08-26。基金项目:航空科学基金(2013ZB53019)。作者简介:刘俊杰,男,硕士生,研究领域为航空发动机控制。E-mail: liujunjie@mail.nwpu.edu.cn