涡流发生器周向相对位置和高度对高负荷风扇性能的影响

推进技术 ›› 2018, Vol. 39 ›› Issue (3): 510-519.

涡流发生器周向相对位置和高度对高负荷风扇性能的影响

何成,王如根,胡加国,李仁康,宋昊林

空军工程大学工程学院，陕西西安 710038,空军工程大学工程学院，陕西西安 710038,空军工程大学工程学院，陕西西安 710038,空军工程大学工程学院，陕西西安 710038,空军工程大学工程学院，陕西西安 710038

发布日期:2021-08-15
作者简介:何成，男，硕士生，研究领域为推进系统气动热力理论与工程。

Effects of Circumferential Position and Height of Vortex Generator on Performance of High-Load Fan

Engineering College，Air Force Engineering University，Xi’an 710038，China,Engineering College，Air Force Engineering University，Xi’an 710038，China,Engineering College，Air Force Engineering University，Xi’an 710038，China,Engineering College，Air Force Engineering University，Xi’an 710038，China and Engineering College，Air Force Engineering University，Xi’an 710038，China

Published:2021-08-15

摘要/Abstract

摘要： 为了研究涡流发生器周向相对位置和高度对高负荷风扇性能的影响，根据风扇的流动特点，设计了在第二级静子叶根入口前加涡流发生器的流动控制方案，并以此为基础提出了多种不同周向位置和高度的涡流发生器方案，通过计算对采取各种方案下的流场进行了分析。研究表明，涡流发生器对风扇第二级静子角区气流分离有较好的控制作用；涡流发生器的周向位置对第二级静子角区气流分离和损失的影响较大，采取方案C时可以更好地抑制角区气流分离，减少局部损失；涡流发生器高度过高会使静子压力面出现不同程度的低速区，同时也会引起静子通道内局部损失增加，在所研究的范围内，当涡流发生器高度降低1%叶高时，其对吸力面角区分离的控制效果更加明显。

关键词: 涡流发生器；高负荷风扇；角区分离；周向相对位置；高度

Abstract: In order to study effects of the circumferential position and height of vortex generator on performance of high-load fan， the VG flow control programs before the root of the second stator were designed based on the feature of the fan flow. Different circumferential position and height VG programs were presented and the changes of fan aerodynamic performance and flow structure resulted from different VG programs were simulated. The results show that the corner separation of the second stator was suppressed by VG. The circumferential position of VG strongly influences the corner separation and flow loss of the second stator， while configuration C has the best effects. If the VG was too high， low-speed areas would appear near the pressure surface， while the flow loss in the channel of the second stator would increase， and the control program would have the best effects when the height of VG decrease 1% span within the limits of our study.

Key words: Vortex generator；High-load fan；Corner separation；Circumferential position；Height

何成,王如根,胡加国,李仁康,宋昊林. 涡流发生器周向相对位置和高度对高负荷风扇性能的影响[J]. 推进技术, 2018, 39(3): 510-519.

HE Cheng,WANG Ru-gen,HU Jia-guo,LI Ren-kang,SONG Hao-lin. Effects of Circumferential Position and Height of Vortex Generator on Performance of High-Load Fan[J]. Journal of Propulsion Technology, 2018, 39(3): 510-519.

参考文献

[1] 刘大响. 航空动力发展的历史性机遇[J]. 航空发动机, 2005, 13(2): 1-3.
[2] 邵卫卫. 风扇/轴流压气机最大负荷设计技术探索[D]. 北京:中国科学院研究生院(工程热物理研究所), 2008.
[3] Bmynes, Taylr, David J Peake,et al. Viscous Flow Control with Air-Jet Vortex Generators[R]. AIAA 99-3175.
[4] Lachmann G V. Boundary Layer and Flow Control[M]. Oxford:Pergamon Press, 1961.
[5] Pearcey H H. Shock-Induced Separation and Its Prevention. Boundary Layer and Flow Control-Its Principles and Application[M]. Oxford: Pergamon Press, 1961.
[6] Steven M Klausmeyer, Michael Papadakis, John C Lin. A Flow Physics Study of Vortex generators on a Multi-element Airfoil[R]. AIAA 96-0548.
[7] Ian Broadley, Kevin P Garry. Effectiveness of Vortex Generator Position and Orientation on Highly Swept Wings[R]. AIAA 97-2319.
[8] Ashill P R, Fulker J L, Hackett K C. Research at DERA on Sub Boundary Layer Vortex Generators(SBVGs)[R]. AIAA 2001-0887.
[9] Gammerdinger P M. The Effects of Low-Profile Vortex Generators on Flow in a Transonic Fan-Blade Cascade[D]. Monterey: Naval Postgraduate School, 1995.
[10] Law C H, Wennerstrom A J, Buzzell W A. The Use of Vortex Generators as Inexpensive Compressor Casing Treatment[R]. SAE Paper 1976-0925.
[11] 吴培根. 高负荷风扇流动失稳及流动控制方法研究[D]. 西安:空军工程大学, 2014.
[12] 胡加国, 王如根, 李坤, 等. 非设计条件下跨声速压气机失速机制分析[J]. 推进技术, 2016, 37(8): 1490-1499. (HU Jia-guo, WANG Ru-gen, LI Kun, et al. Instability Mechanism Analysis with Transonic Compressor at Off-Design Work Condition[J]. Journal of Propulsion Technology, 2016, 37(8): 1490-1499.)
[13] 何成, 王如根, 胡加国, 等. 不同转速下叶尖间隙流对跨声速压气机失速的影响[J]. 推进技术, 2016, 37(9): 1657-1663. (HE Cheng, WANG Ru-gen, HU Jia-guo, et al. The Effect of Tip Leakage Flow on Compressor Instability at Different Rotation Speed[J]. Journal of Propulsion Technology, 2016, 37(9): 1657-1663.)
[14] 吴培根, 王如根, 郭飞飞, 等. 涡流发生器对高负荷扩压叶栅性能影响的机理分析[J]. 推进技术, 2016, 37(1): 49-56. (WU Pei-gen, WANG Ru-gen, GUO Fei-fei, et al. Mechanism Analysis of Vortex Generator Effects on High-Load Compressor Cascade[J]. Journal of Propulsion Technology, 2016, 37(1): 49-56.)
[15] Kenneth L Suder. Blockage Development in a Transonic, Axial Compressor Rotor[R]. NASA TM-113115, 1997.
[16] Chunill Hah. Large Eddy Simulation of Transonic Flow Field in NASA Rotor 37[R]. NASA TM-215627, 2009.　　　　　　　　　　　　　*　收稿日期:2016-09-10；修订日期:2016-11-08。作者简介:何成,男,硕士生,研究领域为推进系统气动热力理论与工程。E-mail: welcomehh@126.com(编辑:梅瑛)