差动活塞式热气自增压系统静态特性仿真研究

推进技术 ›› 2018, Vol. 39 ›› Issue (3): 538-546.

差动活塞式热气自增压系统静态特性仿真研究

方忠坚,刘洌,梁国柱

北京航空航天大学宇航学院，北京 100191,北京航空航天大学宇航学院，北京 100191,北京航空航天大学宇航学院，北京 100191

发布日期:2021-08-15
作者简介:方忠坚，男，博士生，研究领域为液体姿轨控发动机热气增压系统。

Simulation of Static Characteristics of Differential Piston Warm Gas Self-Pressurization System

School of Astronautics，Beijing University of Aeronautics and Astronautics，Beijing 100191，China,School of Astronautics，Beijing University of Aeronautics and Astronautics，Beijing 100191，China and School of Astronautics，Beijing University of Aeronautics and Astronautics，Beijing 100191，China

Published:2021-08-15

摘要/Abstract

摘要： 为了深入理解液体姿轨控发动机差动活塞式热气自增压系统的特点，依据增压系统平衡条件，采用集中参数法构建了系统的静态特性计算模型，研究了系统主要参数对系统状态和增压性能以及对系统自锁压力的影响规律。研究结果表明:系统增压气体流量朝着推进剂贮箱压力变化相反的方向而变化，起到调节和稳定推进剂贮箱压力的作用；燃气发生器毛细管参数的变化主要对系统增压流量造成影响，与长度相比，其内径变化对系统状态参数的影响作用更大；当压力放大比在设计值附近[-7.3%，+9.6%]变化时，系统稳态工作增压气体流量偏差保持在[-5%，0%]内；流量调节器结构参数的微小变动会引起增压气体流量的较大变化。

关键词: 液体姿轨控发动机；自动增压系统；静态特性；系统平衡；流量调节器

Abstract: For further understanding the characteristics of the differential piston warm gas self-pressurization system of liquid attitude and divert control engines， the static characteristics simulation model of the system was established in lumped parameter method based on system balance conditions. The effects of system main parameters on the system state， pressurization performance and system self-locking pressure were studied. The results show that the system pressurization gas mass flux changes in the opposite direction of the propellant tank pressure and adjust and stabilize the propellant tank pressure; the changes of capillary parameters in gas generator mainly affect the system pressurization gas mass flux， and compared with the length and the inner diameter， the influence on the system state parameters by the change of capillary inner diameter is greater; when the pressure amplification ratio is in the range of design value [-7.3%， +9.6%]， the deviation of system steady-state pressurization gas mass flux falls in [-5%， 0%]， the pressurization gas mass flux is sensitive to changes of the liquid flow regulator structural parameters.

Key words: Liquid attitude and divert control engine；Self-pressurization system；Static characteristics；System balance；Liquid flow regulator

方忠坚,刘洌,梁国柱. 差动活塞式热气自增压系统静态特性仿真研究[J]. 推进技术, 2018, 39(3): 538-546.

FANG Zhong-jian,LIU Lie,LIANG Guo-zhu. Simulation of Static Characteristics of Differential Piston Warm Gas Self-Pressurization System[J]. Journal of Propulsion Technology, 2018, 39(3): 538-546.

参考文献

[1] Maybee J C, David J K. A Novel Design Warm Gas Pressurization System[R]. AIAA 98-4014.
[2] 陈杰. 液体火箭发动机系统动力平衡参数通用计算方法[J]. 上海航天, 1991, (4): 1-5.
[3] 陈杰. 液体推进剂空间推进系统静态数学模型[J].上海航天, 1999, (2): 11-15.
[4] 蒋志坚, 张黎辉, 李家文. 空间推进系统静态特性通用仿真研究[J]. 推进技术, 2003, 24(5): 448-451. (JIANG Zhi-jian, ZHANG Li-hui, LI Jia-wen. Versatile Numerical Simulation on Static Characteristics of Space Propulsion Systems[J]. Journal of Propulsion Technology, 2003, 24(5): 448-451.)
[5] 李家文, 张黎辉, 张雪梅, 等. 空间推进系统静动态仿真软件研究[J]. 推进技术, 2004, 25(2): 148-151. (LI Jia-wen, ZHANG Li-hui, ZHANG Xue-mei, et al. Simulation Software for the Static and Dynamic Characteristics of Space Propulsion System[J]. Journal of Propulsion Technology, 2004, 25(2): 148-151.)
[6] 李晓瑾, 辛坤. 姿控发动机静态特性分析[J]. 火箭推进, 2003, 29(4): 24-29.
[7] 陈朝, 黄敏超. 空间轨道转移飞行器推进系统静态仿真分析[J]. 火箭推进, 2007, 33(6): 22-27.
[8] Whitehead J C. Hydrogen Peroxide Propulsion for Smaller Satellites[R]. SSC 98-VIII-1.
[9] Whitehead J C, Dittman M D, Ledebuhr A G. Progress Toward Hydrogen Peroxide Micropropulsion[R]. SSC 99-XII-5.
[10] Whitehead J C. Self-Pressurizing HTP Feed Systems [C]. USA: Second International Hydrogen Peroxide Propulsion Conference, 1999.
[11] Lydon M M, Polidor 2Lt M. Hydrogen Peroxide Self-Pressurizing Storage Tank Test and Analysis[R]. AIAA 2004-4201.
[12] LIU Lie, LIANG Guo-zhu. Optimization Selection of Regulated Pressurization System Schemes for Liquid Attitude and Divert Propulsion Systems[J]. Procedia Engineering, 2015, 99: 1247-1251
[13] 方忠坚, 刘洌, 梁国柱. 差动活塞式燃气自增压系统参数设计方法[J]. 北京航空航天大学学报, 2017, 43(1): 61-70.
[14] 周汉申. 单组元液体火箭发动机设计与研究[M]. 北京:中国宇航出版社, 2009.
[15] MacDonald I F, El-Sayed M S, Mow K, et al. Flow Through Porous Media-the Ergun Equation Revised[J]. Ind.Eng.Chem. Fundamen, 1979, 18(3): 199-208.(编辑:史亚红)　　　　　　　　　　　　　*　收稿日期:2016-12-05；修订日期:2017-02-22。作者简介:方忠坚,男,博士生,研究领域为液体姿轨控发动机热气增压系统。E-mail: fzj4919@163.com