对转升力风扇地面效应的力学及喷流频谱特性研究

推进技术 ›› 2018, Vol. 39 ›› Issue (12): 2703-2709.

对转升力风扇地面效应的力学及喷流频谱特性研究

王海童,王掩刚,邓双厚

西北工业大学动力与能源学院，陕西西安 710072,西北工业大学动力与能源学院，陕西西安 710072,西北工业大学动力与能源学院，陕西西安 710072

发布日期:2021-08-15
作者简介:王海童，男，博士生，研究领域为叶轮机复杂流动机理及优化。E-mail: whtnwpu@foxmail.com 通讯作者:王掩刚，男，博士，教授，研究领域为叶轮机械气动热力学。
基金资助:
国家自然科学基金(51376150)。

Experimental Study of In-Ground-Effect on Force and Spectrum Characteristics of a Contra-Rotating Lift Fan

School of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China,School of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China and School of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China

Published:2021-08-15

摘要/Abstract

摘要： 为进一步了解升力风扇工作特性，以自行设计的20kg推力对转升力风扇为研究对象，设计和发展了对转涵道风扇测控系统，研究不同转速条件、不同离地距离(1.1D，2D，3D，D为转子直径)对升力风扇各部件力学特性的影响效应，结合动态压力传感器阵列测量技术及功率谱密度分析方法，获得了升力风扇的喷流频谱特性。结果表明:相比于3.0D工况，在设计转速下当离地高度降低到1.1D时，升力风扇总推力提高11%但需求功率基本不变，其中涵道唇口推力下降3%，转子推力上升25%，出现了明显的“气垫效应”；上、下游转子叶片尾迹能量较小，未能监测到明显的叶片通过频率，风扇喷流动态特性与前后级转子间动-动非定常干涉效应有明显相关性，其一阶频率为上、下游转子通过频率之和。

关键词: 升力风扇；地面效应；对转；功率谱密度；实验研究

Abstract: In order to further study the working characteristics of lift fan， present study conducted an experimental investigation on the in-ground-effect aerodynamic characteristics of a contra-rotating lift fan in terms of force generation and pressure spectrum. An experimental system including the control and measurement system is designed， in which the aerodynamic properties are revealed with different RPM and the distance of fan exit to ground(1.1D， 2D， 3D where D is the diameter of the lift fan). The spectrum characteristics of the exit jet flow have been investigated by means of high-response dynamic pressure sensors. Results revealed that the ‘air cushion’ effect occurred when the ground distance approaches to 1.1D. Compared with the 3.0D condition， the total thrust of lift fan increases by 11% but the demand power is almost the same when the ground distance of the lift fan is lowered to 1.1D， lift generated by the ducted lip was reduced by 3% while the lift from the contra-rotating rotors increased by 25% at the design speed. However， the power consumption did not show a noticeable variation at different ground distance. The dynamic pressure spectrum showed that a new signal dominate the characteristics of the jet flow due to the strong interaction between the contra-rotating rotor rows. The first order frequency is identical to the sum of the blades for both rotor rows. Besides， the fluctuation of the wake from the rotors cannot be observed clearly.

Key words: Lifting fan；Ground effect；Contra-rotating；PSD (Power spectral density)；Experimental study

王海童,王掩刚,邓双厚. 对转升力风扇地面效应的力学及喷流频谱特性研究[J]. 推进技术, 2018, 39(12): 2703-2709.

WANG Hai-tong,WANG Yan-gang,DENG Shuang-hou. Experimental Study of In-Ground-Effect on Force and Spectrum Characteristics of a Contra-Rotating Lift Fan[J]. Journal of Propulsion Technology, 2018, 39(12): 2703-2709.

参考文献

[1] 彭润艳, 王和平, 林宇. 带升力风扇飞机的短距起飞建模和仿真研究[J]. 计算机仿真, 2008, 25(4):46-49.
[2] Hayden J S. The Effect of the Ground on Helicopter Hovering Power Required[C]. Washington D C: Proceedings of the 32nd American Helicopter Society Forum, 1976.
[3] Curtiss H C, Sun M, Putman W F, et al. Rotor Aerodynamics in Ground Effect at Low Advance Ratios[J]. Journal of the American Helicopter Society, 1984, 29(1):48-55.
[4] Light J S. Tip Vortex Geometry of a Hovering Helicopter Rotor in Ground Effect[J]. Journal of the American Helicopter Society, 1993, 38(2): 34-42.
[5] Ganesh B, Komerath N. Study of Ground Vortex Structure of Rotorcraft in Ground Effect at Low Advance Ratios[C]. San Francisco:24th Applied Aerodynamics Conference, 2006.
[6] Bevilaqua P. Inventing the F-35 Joint Strike Fighter[R]. AIAA 2009-1650.
[7] Vanoverbeke T J. A Numerical Study of the Hot Gas Environment around a STOVL Aircraft in Ground Proximity[R]. AIAA 88-2882.
[8] Johns A, Flood J, Strock T, et al. Hot Gas Ingestion Testing of an Advanced STOVL Concept in the NASA Lewis 9-by 15-Foot Low Speed Wind Tunnel with Flow Visualization[R]. AIAA 88-3025.
[9] Johns A, Neiner G, Flood J, et al. Engine Inlet Distortion in a 9.2 Percent Scaled Vectored Thrust STOVL Model in Ground Effect[R]. AIAA 89-2910.
[10] Cabrita P M, Saddington A J, Knowles K. Unsteady Features of Twin-Jet STOVL Ground Effects[R]. AIAA 2002-6014.
[11] Saddington A, Knowles K, Cabrita P. Flow Visualization and Measurements in a Short Take of Vertical Landing Fountain Flow[R]. AIAA 2007-1402.
[12] 刘帅, 王占学, 周莉, 等. 基于响应面法的短距/垂直起降飞机近地面升力损失[J]. 航空动力学报, 2017, 32(4): 874-881.
[13] 刘帅, 王占学, 周莉, 等. 三轴承旋转喷管矢量偏转规律及流场特性研究[J]. 推进技术, 2015, 36(5): 656-663. (LIU Shuai, WANG Zhan-xue, ZHOU Li, et al. Three Bearing Swivel Nozzle Vector Deflection Law Study and Fluid Field Calculation[J]. Journal of Propulsion Technology, 2015, 36(5): 656-663.
[14] 尹超, 胡骏, 严伟, 等. 多级轴流压气机进气畸变模型研究[J]. 推进技术, 2016, 37(12): 2278-2287. (YIN Chao, HU Jun, YAN Wei, et al. Investigation of Multistage Axial Compressor Distortion Analysis Model[J]. Journal of Propulsion Technology, 2016, 37(12): 2278-2287.)
[15] Liu J, Holste F, Neise W. On the Azimuthal Mode Structure of Rotating Blade Flow Instabilities in AxialTurbomachines[R]. AIAA 96-1741.　　　　　　　　　　　　　　收稿日期:2017-10-12；修订日期:2017-11-20。基金项目:国家自然科学基金(51376150)。作者简介:王海童,男,博士生,研究领域为叶轮机复杂流动机理及优化。E-mail: whtnwpu@foxmail.com通讯作者:王掩刚,男,博士,教授,研究领域为叶轮机械气动热力学。E-mail: wyg704@nwpu.edu.cn(编辑:朱立影)