Numerical Simulation of Two-Phase Transient Flow in Scramjet Fuel Supply System

Journal of Propulsion Technology ›› 2016, Vol. 37 ›› Issue (1): 166-171.

Previous Articles Next Articles

Numerical Simulation of Two-Phase Transient Flow in Scramjet Fuel Supply System

Science and Technology on Scramjet Laboratory，Beijing Power Machinery Insititute，Beijing 100074，China,Science and Technology on Scramjet Laboratory，Beijing Power Machinery Insititute，Beijing 100074，China,School of Power and Mechanical Engineering，Wuhan University，Wuhan 430072，China,School of Power and Mechanical Engineering，Wuhan University，Wuhan 430072，China,School of Power and Mechanical Engineering，Wuhan University，Wuhan 430072，China,Science and Technology on Scramjet Laboratory，Beijing Power Machinery Insititute，Beijing 100074，China and Science and Technology on Scramjet Laboratory，Beijing Power Machinery Insititute，Beijing 100074，China

Published:2021-08-15

超燃冲压发动机燃油供给系统两相瞬变数值模拟

王斌元¹,程洪贵¹,张立胜²,易万爽²,蒋劲²,郑日恒¹,王隆¹

北京动力机械研究所高超声速冲压发动机技术重点实验室，北京 100074,北京动力机械研究所高超声速冲压发动机技术重点实验室，北京 100074,武汉大学动力与机械学院，湖北武汉 430072,武汉大学动力与机械学院，湖北武汉 430072,武汉大学动力与机械学院，湖北武汉 430072,北京动力机械研究所高超声速冲压发动机技术重点实验室，北京 100074,北京动力机械研究所高超声速冲压发动机技术重点实验室，北京 100074

作者简介:王斌元，男，本科，高级工程师，研究领域为发动机供油调节系统设计。
基金资助:
高超声速冲压发动机重点实验室开放基金课题(20120101018)。

Abstract

Abstract: In order to reveal the effects of different air content in the fuel on the transient behavior of scramjet supply system，the simulation model of the scramjet fuel supply system which consists of the pressure tank，turbo pump，control valves，nozzles and so on，is modeled based on the physical model of gas release and the mathematical model of characteristic line method. The gas-liquid two phase transient behaviors of the system while opening the valve and stepping down the speed of the turbo pump are simulated and compared with the fuel that does not contain air and containing 1% and 5% volume fraction of air，respectively. The calculation results show that in the process of opening the valve as well as stepping down the pump speed，the maximum wave pressure and the maximum bubble volume before the turbo pump were affected by fuel oil containing different amount of air. In the meantime，the different amount of air contained in the fuel also made the pump suction pipe in different forms of pressure pulsation.

Key words: Scramjet；Fuel supply；Gas-liquid two phase；Transient flow；Air content

摘要： 为揭示冲压发动机燃油介质中不同的含气量对供油系统瞬态行为的影响，在基于气体释放的物理模型和特征线算法的数学模型上，以超燃冲压发动机燃油供给系统为分析对象，对压力油箱、涡轮泵、控制阀门、输油管道、喷嘴支管等进行建模。模拟计算了在初始燃油介质中不含空气和分别含有1%与5%体积分数的空气时，供油系统分别在启泵开阀和转速阶跃下降工况下的气液两相瞬态特性。计算结果表明:在启泵开阀和转速阶跃下降的过程中，涡轮泵前的波峰压力和空泡体积会受到燃油介质中所含空气的影响，并且含气量的变化会使泵进口管段出现不同形式的压力脉动情况。

关键词: 超燃冲压发动机；燃油供给；气液两相；瞬变流；含气量

WANG Bin-yuan¹,CHENG Hong-gui¹,ZHANG Li-sheng²,YI Wan-shuang²,JIANG Jin²,ZHENG Ri-heng¹,WANG Long¹. Numerical Simulation of Two-Phase Transient Flow in Scramjet Fuel Supply System[J]. Journal of Propulsion Technology, 2016, 37(1): 166-171.

王斌元,程洪贵,张立胜,易万爽,蒋劲,郑日恒,王隆. 超燃冲压发动机燃油供给系统两相瞬变数值模拟[J]. 推进技术, 2016, 37(1): 166-171.

References

[1] 周新红. 高超声速武器的发展与应用[J]. 飞航导弹,2007, 1(2): 9-11.
[2] Hopkins R P, Raymond N E, White S T, et al. The Analysis of Conventional Prompt Global Strike Alternatives[C]. USA: 2010 IEEE Systems and Information Engineering Design Symposium, 2010: 135-140.
[3] Richman M S, Kenyon J A. High Speed and Hypersonic Science and Technology[R]. AIAA 2005-4099.
[4] Joseph M H, James S M, Richard C M. The X-51A Scramjet Engine Flight Demonstration Program[R]. AIAA 2008-2540.
[5] 郑日恒, 雷英汉. 涡轮泵式供油系统流体瞬变过程的高速摄影研究[J]. 推进技术, 1988, 9(6): 31-36. (ZHENG Ri-Heng, LEI Ying-Han. A High Speed Photographic Study of Fluid Transients in Turbopump Fuel System[J]. Journal of Propulsion Technology, 1988, 9(6): 31-36.)
[6] 贺武生. 超燃冲压发动机研究综述[J]. 火箭推进, 2005, 31(1): 29-32.
[7] 陈英硕, 叶蕾. 国外吸气式高超声速飞行器发展现状[J]. 飞航导弹, 2008, 12(1): 25-32.
[8] 刘兴洲. 中国超燃冲压发动机研究回顾[J]. 推进技术, 2008, 29(4): 385-395. (LIU Xing-Zhou. Review of Scramjet Research in China[J]. Journal of Propulsion Technology, 2008, 29(4): 385-395.)
[9] Song K D, Choi S H. Transpiration Cooling Experiment for Scramjet Engine Combustion Chamber by High Heat Fluxes[J]. Journal of Propulsion and Power, 2006, 22(1): 96-102.
[10] 崔涛. 超燃冲压发动机控制方法研究[D]. 哈尔滨:哈尔滨工业大学, 2005: 14-18.
[11] 范学军. 吸热碳氢燃料超声速燃烧研究现状与趋势[C]. 北京:2005年高超声速技术发展研讨会, 2005.
[12] 程谋森, 刘昆, 张育林. 低温推进剂供应管路预冷充填瞬变流计算[J]. 推进技术, 2000, 21(5): 38-41. (CHENG Mou-Sen, LIU Kun, ZHANG Yu-Lin. Numerical Analysis of Precooling and Priming Transients in Cryogenic Propellant Feed Systems[J]. Journal of Propulsion Technology, 1988, 9(6): 31-36.)
[13] Tim Edwards. Liquid Fuels and Propellants for Aerospace Propulsion: 1903-2003[J]. Journal of Propulsion and Power, 2003, 19(6).
[14] Wylie V L Streer. Fluid Transients[M]. New York: McGraw-Hill, 2004: 23-28.
[15] 刘竹溪, 刘光临. 泵站水锤及防护[M]. 北京:水利电力出版社, 1988: 38-46.
[16] 郑源, 索丽生, 屈波, 等. 有压输水管道系统含气水锤研究[J]. 河海大学学报, 2005, (3).　(编辑:张荣莉)　　　　*　收稿日期:2014-04-21；修订日期:2014-10-30。基金项目:高超声速冲压发动机重点实验室开放基金课题(20120101018)。作者简介:王斌元,男,本科,高级工程师,研究领域为发动机供油调节系统设计。E-mail: dummywby@sina.com通讯作者:张立胜,男,博士生,研究领域为流体管道系统过渡过程,CFD仿真计算以及泵设计优化 E-mail: lszhang@whu.edu.cn

Numerical Simulation of Two-Phase Transient Flow in Scramjet Fuel Supply System

超燃冲压发动机燃油供给系统两相瞬变数值模拟

PDF

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 0

Recommended Articles

Metrics

Comments