有无蜂窝的直通斜齿流动特性旋转实验研究

doi:10.13675/j.cnki.tjjs.190346

推进技术 ›› 2020, Vol. 41 ›› Issue (5): 1015-1022.DOI: 10.13675/j.cnki.tjjs.190346

有无蜂窝的直通斜齿流动特性旋转实验研究

聂顺鹏¹，刘高文¹，雷昭¹，冯青¹

西北工业大学动力与能源学院，陕西西安 710072

发布日期:2021-08-15
作者简介:聂顺鹏，硕士生，研究领域为发动机空气系统和旋转盘腔中的流动传热。E-mail：1398723121@qq.com

Experimental Study on Rotation on Flow Characteristics of Straight-Through Inclined Tooth with or Without Honeycomb

School of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China

Published:2021-08-15

摘要/Abstract

摘要： 为了研究蜂窝对直通斜齿流动特性的影响，在光滑衬套和蜂窝衬套条件下的高速旋转篦齿实验台上，分别测量了工作间隙和流动特性随转速0~8700r/min和压比1.1~1.5的变化规律。实验结果表明：随着转速的增加，泄漏量下降了约50%，流量系数下降了约25%，风阻温升达到40K；随着压比的增加，泄漏量和流量系数也相应增加；蜂窝衬套相对于光滑衬套，流量下降了约20%，流量系数下降了约10%，风阻温升差异微小。蜂窝可以使篦齿流量及流量系数降低，提升封严性能，对风阻温升影响很小。

关键词: 篦齿封严;直通斜齿;蜂窝衬套;流动特性;旋转

Abstract: In order to study the effects of honeycomb on the flow characteristics of straight-through inclined tooth, the variation of working clearance and discharge characteristics with rotational speed 0~8700r/min and pressure ratio 1.1~1.5 were measured on the experiment rig of a high-speed rotating labyrinth under the cases with smooth bushing and honeycomb bushing. The experimental results show that with the increase of the rotational speed, the leakage flow decreases by about 50%, the discharge coefficient decreases by about 25%, and the windage heating rises to 40K. As the pressure ratio increases, the leakage flow and the discharge coefficient increase accordingly. With respect to the smooth bushing case, the mass flow rate with honeycomb bushing decreases by about 20%, the discharge coefficient drops by about 10%, and the difference of windage heating is slight. Honeycomb can reduce the mass flow rate and discharge coefficient of the labyrinth seal， and improve the sealing performance， and have little effect on the windage heating.

Key words: Labyrinth seal;Straight-through inclined tooth;Honeycomb bushing;Flow characteristic;Rotation

聂顺鹏，刘高文，雷昭，冯青. 有无蜂窝的直通斜齿流动特性旋转实验研究[J]. 推进技术, 2020, 41(5): 1015-1022.

NIE Shun-peng¹, LIU Gao-wen¹, LEI Zhao¹, FENG Qing¹. Experimental Study on Rotation on Flow Characteristics of Straight-Through Inclined Tooth with or Without Honeycomb[J]. Journal of Propulsion Technology, 2020, 41(5): 1015-1022.

参考文献

[1] Xiaozhi Kong, Gaowen Liu， Yuxin Liu， et al. Experimental Testing for the Influences of Rotation and Tip Clearance on the Labyrinth Seal in a Compressor Stator Well[J]. Aerospace Science and Technology， 2017， 71: 556-567.
[2] Li J ， Kong S ， Yan X ， et al. Numerical Investigations on Leakage Performance of the Rotating Labyrinth Honeycomb Seal[J]. Journal of Engineering for Gas Turbines and Power， 2010， 132(6).
[3] Yan X， Li J， Feng Z. Effects of Inlet Preswirl and Cell Diameter and Depth on Honeycomb Seal Characteristics[J]. Journal of Engineering for Gas Turbines and Power， 2010， 132(12).
[4] Fraczek D， Krzysztof Bochon, Wlodzimierz Wróblewski， et al. Influence of Honeycomb Rubbing on the Labyrinth Seal Performance[J]. Journal of Engineering for Gas Turbines and Power， 2016， 138(1).
[5] Fraczek D， Bochon K， Wróblewski W. Influence of Honeycomb Land Geometry on Seal Performance[R]. ASME GT 2016-57569.
[6] 孙丹，卢江，刘永泉，等. 篦齿封严风阻温升特性研究[J]. 航空学报， 2018， 39(11): 70-79.
[7] 高杰，郑群，李义进. 动叶顶部蜂窝面迷宫密封对涡轮级气动性能的影响[J]. 航空动力学报， 2012， 27(1): 160-168.
[8] 王代军，苏云亮，罗翔. 旋转状态下篦齿流量特性试验研究[J]. 燃气涡轮试验与研究， 2007， 20(2):41-44.
[9] 纪国剑，吉洪湖. 旋转状态下篦齿-蜂窝结构封严特性研究[J]. 工程热物理学报， 2006， 27(z1): 161-164.
[10] 纪国剑，吉洪湖，黄云霞，等. 直通篦齿蜂窝封严结构的风阻特性试验[J]. 航空动力学报， 2011， 26(12): 2655-2660.
[11] 王鹏飞，刘玉芳，郭文，等. 高转速对直通型篦齿封严特性影响的试验研究[J]. 燃气涡轮试验与研究， 2007, 20(2): 45-48.
[12] 刘高文，陈凯，刚铁，等. 压比和雷诺数对压气机级间篦齿封严流动特性的影响[J]. 航空动力学报， 2015， 30(7): 1554-1560.
[13] 胡东旭，贾力，杨立新. 篦齿封严泄漏特性的实验[J]. 航空动力学报， 2014， 29(3): 549-555.
[14] 郭海龙，冯青，刘高文，等. 考虑间隙变化的旋转篦齿流动特性实验[J]. 航空动力学报， 2018， 33(7): 1779-1786.
[15] 孔晓治，刘高文，雷昭，等. 转速对压气机级间篦齿封严影响的实验[J]. 航空动力学报， 2016， 31(7): 1575-1582.

有无蜂窝的直通斜齿流动特性旋转实验研究

Experimental Study on Rotation on Flow Characteristics of Straight-Through Inclined Tooth with or Without Honeycomb

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 0

编辑推荐

Metrics

本文评价