波浪形前缘降低后掠叶片宽频噪声实验研究

doi:10.13675/j.cnki.tjjs.190757

推进技术 ›› 2020, Vol. 41 ›› Issue (12): 2720-2728.DOI: 10.13675/j.cnki.tjjs.190757

波浪形前缘降低后掠叶片宽频噪声实验研究

卯鲁秦，郭鑫，黎霖，乔渭阳，仝帆

西北工业大学动力与能源学院，陕西西安 710129

发布日期:2021-08-15
作者简介:卯鲁秦，硕士生，研究领域为叶轮机气动声学。E-mail：maoluqin@mail.nwpu.edu.cn
基金资助:
国家自然科学基金（51936010；51776174）；国家科技重大专项(2017-Ⅱ-0008-0022）。

Experimental Study on Broadband Noise Reduction with Wavy Leading Edge for Sweep Blade

School of Power and Energy，Northwestern Polytechnical University，Xi’an 710129，China

Published:2021-08-15

摘要/Abstract

摘要： 为了研究波浪形前缘对后掠叶片湍流干涉噪声的影响，通过放置于叶片上游的倾斜圆柱产生尾迹，圆柱尾迹为各向异性的湍流，之后湍流与叶片相互干涉产生干涉噪声。实验采用的叶型后掠角度为30°，截面为NACA0012翼型。在气流来流速度v分别为30，40，60，70m/s的情况下（基于叶片弦长的雷诺数为3×10⁵~7×10⁵），使用31个麦克风线阵列测量了基准后掠叶片与波浪形前缘叶片对应的叶片湍流干涉噪声。采用Clean-SC算法处理数据，得到不同幅值与波长下后掠叶片前缘噪声信息。实验结果表明，波浪形前缘幅值与波长对总声压级降噪量均有影响，使用最大幅值和最小波长的波浪形前缘降噪效果最好；不同气流速度下，采用相同的波浪形前缘，使用斯特劳哈尔数表征的噪声频谱图变化规律相似。

关键词: 后掠叶片;波浪形前缘;宽频噪声;干涉;湍流

Abstract: In order to investigate the blade-turbulence interaction （BTI） noise reduction of a sweep blade with wavy leading edge（WLE） configuration，the noise radiation from the sweep blade leading-edge is generated by the interaction of the blade and incoming anisotropic turbulence which is produced by a rod whose wake impinges onto the downstream blade. The swept blade with swept angle of 30 degrees and constructed by NACA0012 airfoil was experimental investigated in this study. The BTI noise for the swept blade with and without wavy leading edge were measured with the flow speeds of U=30m/s， 40m/s， 60m/s and 70m/s， and the corresponding Reynolds numbers based on the blade chord are in 3×10⁵ ~ 7×10⁵. A linear array of 31 microphones was used in this study to determine the BTI noise of the swept blade. With the Clean-SC approach， clear and quantitative sound radiation results of the leading edge noise source of swept blade with different amplitudes and wavelengths are obtained. It is observed that the OASPL （overall sound pressure level） reduction is sensitive to both the amplitude and wavelength of the WLE. The WLE with the largest amplitude and smallest wavelength can achieve the most considerable OASPL reduction. It is found in this study that the spectra of BTI noise reduction with Strouhal number is almost the same for same WLE under different airflow velocities.

Key words: Sweep blade;Wavy leading edge;Broadband noise;Interference;Turbulence

卯鲁秦，郭鑫，黎霖，乔渭阳，仝帆. 波浪形前缘降低后掠叶片宽频噪声实验研究[J]. 推进技术, 2020, 41(12): 2720-2728.

MAO Lu-qin, GUO Xin, LI Lin, QIAO Wei-yang, TONG Fan. Experimental Study on Broadband Noise Reduction with Wavy Leading Edge for Sweep Blade[J]. Journal of Propulsion Technology, 2020, 41(12): 2720-2728.

参考文献

[1] Migliore P， Oerlemans S. Wind Tunnel Aeroacoustic Tests of Six Airfoils for Use on Small Wind Turbines： Preprint［J］. Journal of Solar Energy Engineering， 2004， 126（4）： 974-985.
[2] Miklosovic D S， Murray M M， Howle L E， et al. Leading-Edge Tubercles Delay Stall on Humpback Whale （Megaptera Novaeangliae） Flippers［J］. Physics of Fluids， 2004， 16（5）： 39-42.
[3] Clair V， Polacsek C， Le Garrec T， et al. Experimental and Numerical Investigation of Turbulence-Airfoil Noise Reduction Using Wavy Edges［J］. AIAA Journal， 2013， 51（11）： 2695-2713.
[4] Lau A S H， Haeri Sina， Wook Jae. The Effect of Wavy Leading Edges on Aerofoil-Gust Interaction Noise［J］. Journal of Sound and Vibration， 2013， 332（24）： 6234-6253
[5] Kim J W， Haeri S， Joseph P F. On the Reduction of Aerofoil-Turbulence Interaction Noise Associated with Wavy Leading Edges［J］. Journal of Fluid Mechanics， 2016， 792： 526-552.
[6] James Mathews， Nigel Peake J. Noise Generation by Turbulence Interacting with an Aerofoil with a Serrated Leading Edge［C］. Dallas：21st AIAA/CEAS Aeroacoustics Conference， 2015.
[7] Lyu B， Azarpeyvand M， Sinayoko S. Noise Prediction for Serrated Leading-Edges［C］. Lyon：22nd AIAA/CEAS Aeroacoustics Conference， 2016.
[8] Chaitanya P， Joseph P， Narayanan S， et al. Performance and Mechanism of Sinusoidal Leading Edge Serrations for the Reduction of Turbulence-Aerofoil Interaction Noise［J］. Journal of Fluid Mechanics， 2017， 818： 435-464.
[9] Biedermann T M， Chong T P， Kameier F， et al. Statistical-Empirical Modeling of Airfoil Noise Subjected to Leading-Edge Serrations［J］. AIAA Journal， 2017， 55（9）： 3128-3142.
[10] Turner J M， Kim J W. Aeroacoustic Source Mechanisms of a Wavy Leading Edge Undergoing Vortical Disturbances［J］. Journal of Fluid Mechanics， 2017， 811： 582-611.
[11] Geaaguilera F， Gill J， Angland D， et al. Wavy Leading Edge Airfoils Interacting with Anisotropic Turbulence［C］. Denver： 23rd AIAA/CEAS Aeroacoustics Conference，2017.
[12] Reboul G， Cader A， Polacsek C， et al. CAA Prediction of Rotor-Stator Interaction Using Synthetic Turbulence： Application to a Low-Noise Serrated OGV［C］. Denver： 23rd AIAA/CEAS Aeroacoustics Conference， 2017.
[13] Turner J M ， Kim J W . Aeroacoustic Source Mechanisms of a Wavy Leading Edge Undergoing Vortical Disturbances［J］. Journal of Fluid Mechanics， 2017， 811：582-611.
[14] Chen W J， Qiao W Y， Tong F， et al. Experimental Investigation of Wavy Leading Edges on Rod-Aerofoil Interaction Noise［J］. Journal of Sound and Vibration， 2018， 422： 409-431.
[15] Chen W J， Qiao W Y， Tong F， et al. Numerical Investigation of Wavy Leading Edges on Rod-Airfoil Interaction Noise［J］. AIAA Journal， 2018， 56（7）： 2553-2567.
[16] Chen W J， Qiao W Y， Wang L F， et al. Rod-Airfoil Interaction Noise Reduction Using Leading Edge Serrations［C］. Dallas： 21st AIAA/CEAS Aeroacoustics Conference，2015.
[17] Tong F， Qiao W Y， Chen W J， et al. Numerical Analysis of Broadband Noise Reduction with Wavy Leading Edge［J］. Chinese Journal of Aeronautics， 2018， 31（7）.
[18] Tong F， Qiao W Y， Xu K B， et al. On the Study of Wavy Leading-Edge Vanes to Achieve Low Fan Interaction Noise［J］. Journal of Sound and Vibration， 2018， 419：200-226.
[19] Johari H， Henoch C W， Custodio D， et al. Effects of Leading-Edge Protuberances on Airfoil Performance［J］. AIAA Journal， 2007， 45（11）： 2634-2642.
[20] Berland J， Lafon P， Crouzet F， et al. A Parametric Study of the Noise Radiated by the Flow Around Multiple Bodies： Direct Noise Computation of the Influence of the Separating Distance in Rod-Airfoil Flow Configurations［R］. AIAA 2011-2819.
[21] Matsumoto M. Vortex Shedding of Bluff Bodies： A Review［J］. Journal of Fluids & Structures， 1999， 13（7-8）： 791-811.

波浪形前缘降低后掠叶片宽频噪声实验研究

Experimental Study on Broadband Noise Reduction with Wavy Leading Edge for Sweep Blade

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 0

编辑推荐

Metrics

本文评价