有声腔推力室的声学振型及其阻尼特性研究

doi:10.13675/j.cnki.tjjs.200355

推进技术 ›› 2021, Vol. 42 ›› Issue (7): 1483-1492.DOI: 10.13675/j.cnki.tjjs.200355

有声腔推力室的声学振型及其阻尼特性研究

覃建秀¹，张会强²

1.中国航天空气动力技术研究院，北京 100074;2.清华大学航天航空学院，北京 100084

出版日期:2021-07-15 发布日期:2021-08-15
作者简介:覃建秀，博士，工程师，研究领域为燃烧不稳定性和斜爆震。E-mail：qinjianxiu@hotmail.com

Numerical Study on Acoustic Modes and Their Damping Characteristics in a Thruster Chamber with Resonators

1.China Academy of Aerospace Aerodynamics，Beijing 100074，China;2.School of Aerospace Engineering，Tsinghua University，Beijing 100084，China

Online:2021-07-15 Published:2021-08-15

摘要/Abstract

摘要： 为确定多声学模态压力振荡条件下带有1/4波长管声腔推力室的声学振型及其阻尼特性，揭示1/4波长管声腔对推力室压力振荡的抑制作用机理，对有声腔推力室和无声腔推力室进行近圆周壁面的定容弹激励仿真，激发了多模态的声学振型，给出了推力室压力分布的时空演化，并采用半带宽法定量评价每个激发声学振型的阻尼特性。结果表明：1/4波长管声腔成功抑制了目标振型（一阶切向振型）压力振荡，大幅度减小其幅值，而不是大幅度增加其半带宽，但可能增强其它非目标振型的压力振荡。声腔通过削弱目标振型波峰波谷压力差、声腔入口漩涡和增加壁面面积等三种方式来抑制目标振型压力振荡，主要以前者为主，前者旨在降低目标振型幅值，后两者是增加其半带宽。

关键词: 1/4波长管声腔;推力室;声学振型;阻尼特性;抑制作用;数值定容弹

Abstract: In order to determine acoustic modes and their damping characteristics in a thruster chamber with quarter-wave resonators under multi-acoustic modes pressure oscillations condition and reveal the suppression mechanism of quarter-wave resonators on pressure oscillations， the acoustic modes and their damping characteristics of a chamber without resonator and a chamber with quarter-wave resonators were numerically predicted by imposing numerical constant-volume bomb at the region near the circumferential side-wall. Multi-acoustic modes were excited and the temporal and spatial evolution of pressure contours were performed. The damping characteristics of each excited mode were evaluated by half-power bandwidth method. The results show that pressure oscillation of the target mode （the first tangential mode） is successfully retrained by quarter-wave resonators. The amplitude is reduced greatly， while the half-power bandwidth increases slightly. But pressure oscillations of other acoustic modes may be enhanced. Quarter-wave resonators suppress pressure oscillations of the target mode by three ways： reducing the difference in the crest and trough pressure of target acoustic mode， producing vortex in the inlet of resonators and increasing wall surface. The form one is the major mechanism， which will reduce the amplitude of the target mode. The latter ones will increase the half-power bandwidth.

Key words: Quarter-wave resonator;Thruster chamber;Acoustic mode;Damping characteristic;Suppression;Numerical constant-volume bomb

覃建秀，张会强. 有声腔推力室的声学振型及其阻尼特性研究[J]. 推进技术, 2021, 42(7): 1483-1492.

QIN Jian-xiu¹, ZHANG Hui-qiang². Numerical Study on Acoustic Modes and Their Damping Characteristics in a Thruster Chamber with Resonators[J]. Journal of Propulsion Technology, 2021, 42(7): 1483-1492.

参考文献

[1] 杨V，安德松 W E. 液体火箭发动机燃烧不稳定性［M］. 张宝炯，洪鑫，陈杰，译. 北京：科学出版社， 2001.
[2] Bennewitz J W， Lineberry D M， Frederick R A. Application of High Frequency Pressure Disturbances as a Control Mechanism for Liquid Rocket Engine Combustion Instabilities［R］. AIAA 2013-3853.
[3] Bennewitz J W， Frederick R A， Lineberry D M. Suppressing a High-Frequency Instability with Varying Bands of White Noise［J］. Journal of Propulsion and Power， 2014， 30（4）： 1094-1097.
[4] Kim H J， Seo S， Lee K J， et al. Stability Rating Tests for the Length-Optimization of Baffles in a Liquid Propellant Combustion Chamber Using Pulse Gun［J］. Areospace Science and Technology， 2008， 12（3）： 214-222.
[5] Feng S J， Nie W S， He Bo， et al. Control Effects of Baffle on Combustion Instability in a LOX/GH₂ Rocket Engine［J］. Journal of Spacecraft and Rockets， 2010， 47（3）： 419-426.
[6] Park J H， Sohn C H. On Optimal Design of Half-Wave Resonators for Acoustic Damping in an Enclosure［J］. Journal of Sound and Vibration， 2009， 319（3-5）： 807-821.
[7] Sohn C H， Park J H. A Comparative Study on Acoustic Damping Induced by Half-Wave， Quarter-Wave， and Helmholtz Resonators［J］. Aerospace Science and Technology， 2011， 15（8）： 606-614.
[8] Kim H J， Cha J P， Song J K， et al. Geometric and Number Effect on Damping Capacity of Helmholtz Resonators in a Modal Chamber［J］. Journal of Sound and Vibration， 2010， 329（16）： 266-279.
[9] Cora R， Martins C A， Lacava P T. Acoustic Instabilities Control Using Helmholtz Resonators［J］. Applied Acoustic， 2014， 77： 1-10.
[10] 聂万胜. 自燃推进剂火箭发动机燃烧稳定性研究［D］. 长沙：国防科学技术大学， 1998.
[11] 严宇，王延涛，李佳明，等. 有声腔推力室的声学特性实验［J］. 航空动力学报， 2016， 31（7）： 1785-1792.
[12] Oschwald M， Farago Z， Searby G， et al. Resonance Frequencies and Damping of a Combustor Acoustically Coupled to an Absorber［J］. Journal of Propulsion and Power， 2008， 24（3）： 524-533.
[13] Bennewitz J W， Frederick R A. Overview of Combustion Instabilities in Liquid Rocket Engines-Coupling Mechanisms & Control Techniques［R］. AIAA 2013-4106.
[14] Zhang H Q， Ga Y J， Wang B， et al. Analysis of Combustion Instability via Constant Volume Combustion in a LOX/RP-1 Bipropellant Liquid Rocket Engine［J］. Sciences China Technological Sciences， 2012， 55（4）： 1066-1077.
[15] 覃建秀，张会强，王兵. 基于数值定容弹方法的推力室声学特性研究［J］. 推进技术， 2018， 39（2）： 366-373.
[16] Qin J X， Zhang H Q， Wang B. Numerical Evaluation of Acoustic Characteristics and Their Damping of a Thrust Chamber［J］. Chinese Journal of Aeronautics， 2018， 31（3）： 470-480.
[17] Christensen E， Nesman T. Fastrac Rocket Engine Combustion Chamber Acoustic Cavities［C］. Huntsville： The 10th Annual Symposium of the Penn State University Propulsion Engineering Research Center， 1998， 11： 18-23.
[18] Wang T S， Chen Y S. Unified Navier-Stokes Flowfield and Performance Analysis of Liquid Rocket Engines［J］. Journal of Propulsion and Power， 1993， 9（5）： 678-685.
[19] Hirt C W， Amsden A A， Cook J L. An Arbitrary Lagrangian-Eulerian Computing Method for All Flow Speeds［J］. Journal of Computational Physics， 1997， 135： 203-216.
[20] Patankar S V. Numerical Heat Transfer and Fluid Flow［M］. Washington： Hemisphere， 1980.
[21] Kim S K， Kim H J， Seol W S， et al. Acoustic Stability Analysis of Liquid Propellant Rocket Combustion Chambers［R］. AIAA 2004-4142.
[22] Park I S， Sohn C H. Nonlinear Acoustic Damping Induced by a Half-Wave Resonator in an Acoustic Chamber［J］. Aerospace Science and Technology， 2010， 14（6）： 442-450.
[23] Kim Y M， Chen Z J， Chen C P， et al. Pressure-Based Method for Combustion Instability Analysis［J］. International Journal for Numerical Methods in Fluids， 1994， 19： 981-995.
[24] Kim S K， Choi H S， Kim H J， et al. Finite Element Analysis for Acoustic Characteristics of Combustion Stabilization Devices［J］. Aerospace Science and Techology， 2015， 42： 229-240.
[25] Sohn C H， Park I S， Kim S K， et al. Acoustic Tuning of Gas-Liquid Scheme Injectors for Acoustic Damping in a Combustion Chamber of a Liquid Rocket Engine［J］. Journal of Sound and Vibration， 2007， 304（3-5）： 793-810.
[26] Buffum F G， Dehority G L， Slates R O， et al. Acoustic Attenuation Experiments on Subscale， Cold-Flow Rocket Motors［J］. AIAA Journal， 1967， 5（2）： 272-280.
[27] Qin J X， Zhou L X， Zhang H Q， et al. Numerical Evaluation of Acoustic Characteristics of a Thrust Chamber with Quarter-Wave Resonators［J/OL］. https：//doi.org/10.1007/s11431-019-1575-6， 2020.

有声腔推力室的声学振型及其阻尼特性研究

Numerical Study on Acoustic Modes and Their Damping Characteristics in a Thruster Chamber with Resonators

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 0

编辑推荐

Metrics

本文评价