间隙泄漏对半开式离心叶轮性能影响的实验研究与分析

推进技术 ›› 1999, Vol. 20 ›› Issue (3): 69-72.

间隙泄漏对半开式离心叶轮性能影响的实验研究与分析

楚武利,刘志伟

西北工业大学航空动力与热力工程系;西北工业大学航空动力与热力工程系

发布日期:2021-08-15

EXPERIMENT STUDY ON EFFECT OF TIP CLEARANCE ON CENTRIFUGAL IMPELLER PERFORMANCE

Dept.of Aeroengine engineering,Northwestern Polytechnical Univ ,Xi′an,710072;Dept.of Aeroengine engineering,Northwestern Polytechnical Univ ,Xi′an,710072

Published:2021-08-15

摘要/Abstract

摘要： 通过实验研究，得出了半开式离心叶轮间隙对效率及压力的影响和不同间隙下叶轮出口径向速度的变化规律。在间隙一定，当流量从大向小变化时，主流区从轮盘侧向轮盖侧移动，有时在轮盘侧观测到明显的倒流现象。用动态热线风速仪对叶轮叶道出口的速度分布进行了集平均测量，得出了不同流量下的速度分布。

关键词: 半开式离心叶轮;间隙测量;流量;实验

Abstract: Fluid loss caused by leaks through the impeller tip clearance was investigated for a centrifugal compressor.Operating conditions and clearance were varied independently during the experiment It was found that the average compressor performance would be reduced by about 10% when the relative clearance was increased from 2 8% to 6 9%.The leak velocity in clearance was measured by hot wire.Moreover,the distribution of velocity at impeller exit was taken and the results show that the reverse flow occurs near hub side in small flow rate.

Key words: Unshrouded centrifugal impeller +;Clearance measurement;Flow rate;Experiment

楚武利,刘志伟. 间隙泄漏对半开式离心叶轮性能影响的实验研究与分析[J]. 推进技术, 1999, 20(3): 69-72.