聚集状态下燃烧室凝相粒子粒度特性实验

推进技术 ›› 2011, Vol. 32 ›› Issue (1): 54-58.

聚集状态下燃烧室凝相粒子粒度特性实验

张少悦,何国强,刘佩进,陈剑

西北工业大学燃烧、流动和热结构国家级重点实验室,陕西西安 710072;西北工业大学燃烧、流动和热结构国家级重点实验室,陕西西安 710072;西北工业大学燃烧、流动和热结构国家级重点实验室,陕西西安 710072;西北工业大学燃烧、流动和热结构国家级重点实验室,陕西西安 710072

发布日期:2021-08-15
作者简介:张少悦(1982—),男,硕士生,研究领域为航空宇航推进理论与工程。E-mail:zsy2007200246@sohu.com
基金资助:
国家自然科学基金资助项目(50776073)。

Experiment on granularity peculiarity of condensed particlesin the chamber of SRM under aggregation condition

National Key Lab. of Combustion, Flow and Thermo-Structure, Northwestern Polytechnical Univ., Xian 710072, China;National Key Lab. of Combustion, Flow and Thermo-Structure, Northwestern Polytechnical Univ., Xian 710072, China;National Key Lab. of Combustion, Flow and Thermo-Structure, Northwestern Polytechnical Univ., Xian 710072, China;National Key Lab. of Combustion, Flow and Thermo-Structure, Northwestern Polytechnical Univ., Xian 710072, China

Published:2021-08-15

摘要/Abstract

摘要： 设计了具有收敛段的粒子发生装置,采用密闭收集水罐,针对HTPB推进剂开展实验,有效完整地收集到了聚集状态下的凝相粒子。采用扫描电镜和粒度分析仪对收集的粒子进行了分析。结果表明,聚集状态下颗粒间碰撞聚合非常严重,大颗粒一般由多个颗粒聚合而成。碰撞聚合条件下凝相粒子的粒度分布范围比较宽,颗粒分布峰值粒度在9～13μm之间,比非聚集状态下的主峰粒度大很多。研究结果可为两相流数值计算、发动机工作过程分析提供基础数据。

关键词: 固体火箭发动机;粒子收集;粒度分布;聚集状态 

Abstract: The particle-generator device with a convergent part was designed and experiments were carried out using typical HTPB composite propellant containing 17% aluminum. The condensed particles in the chamber of SRM under aggregation condition were effectively and completely collected in the use of an airtight water tank and analyzed by means of Mastersizer2000 and SEM. The results show that compared with the normal condition, the collision among particles is more severe under aggregation condition . The condensed particles distribute in a much wider range and the volumetric distribution peak value of particle size is much bigger, which lies between 9μm and 13μm. The results provide basic data for simulation of two-phase flow and analysis of operating courses in the rocket motors.

Key words: Solid rocket motor; Particle collection; Diameter distribution; Aggregation condition

张少悦,何国强,刘佩进,陈剑. 聚集状态下燃烧室凝相粒子粒度特性实验[J]. 推进技术, 2011, 32(1): 54-58.

参考文献

[2] Kitron A, Elperin T, Tamir A.Stochastic modeling of the effects of the liquid droplet collisions in impinging streams absorbers and combustors[J].Int J.Multiphase Flow,1,7(2):274-282.
[3] 张宏安,叶定友,侯晓,等.固体火箭发动机凝聚相微粒分布研究现状[J].固体火箭技术,2000,23(3):25-28.
[4] Traineau J C,Kuentzmann P,Prevost M,et al.Particle size distribution measurements in a subscale motor for the ariane 5 solid rocket booster[R].AIAA 92-3049.
[5] Hiroto Habu, Toru Shimada, Hiroshi Hasegawa.Study on Al/Al₂O₃ agglomeration particle size distributions for solid propellants[R].AIAA 2006-5249-311.
[6] Averin V S.Effect of a sudden change in cross-sectional area of the solid rocket motor duct on coagulation of condensed particles[J].Combustion,Explosion,and Shock Waves,2003,39(3) .
[7] 张明信,魏建维,王晓霞,等.固体推进剂燃烧室中凝相粒子的激光全息测试[J].固体火箭技术,2000,23(1):73-76.
[8] 张明信,王国志,魏剑维,等.影响Al₂O₃凝相尺寸分布的因素[J].推进技术,2001,22(3):250-253.(ZHANG Ming-xin,WANG Guo-zhi,WEI Jian-wei,et al.Factors influencing Al₂O₃ condensed phase sizing distribution[J].Journal of Propulsion Technology,1,2(3).)
[9] 李江,娄永春,刘洋,等.聚集状态对火箭发动机颗粒粒度分布的影响[J].固体火箭技术,2005,28(4).
[10] 刘佩进,白俊华,杨向明,等.固体火箭发动机燃烧室凝相粒子的收集与分析[J].固体火箭技术,2008,31(5).
[11] Gan Xiao-song, Liu Pei-jin, Zhao Zhi-bo, et al.Collection and analysis of the condensed-phase products of solid propellant by the innovative equipment[R].AIAA 2009-5429.
[12] 李江, 何国强, 秦飞,等.高过载条件下绝热层烧蚀实验方法研究(I)方案论证及数值模拟[J].推进技术, 3,4(4).(LI Jiang, HE Guo-qiang,QIN Fei,et al.Study of experimental method for ablation of insulator of SRM with high acceleration(Ⅰ)[J].Journal of Propulsion Technology,3,4(3).)
[13] 李江, 何国强, 陈剑,等.高过载条件下绝热层烧蚀实验方法研究(II)收缩管聚集法[J].推进技术, 4,5(3).(LI Jiang,HE Guo-qiang, CHEN Jian,et al.Study of experimental method for ablation of insulator of SRM with high acceleration (Ⅱ)Convergent tube experimental method[J].Journal of Propulsion Technology,4,5(3).)
[14] 赵志博.含铝推进剂凝相燃烧产物的特性研究[D].西安:西北工业大学,2009.