流体热物性对粗糙微通道内传热性能的影响

推进技术 ›› 2012, Vol. 33 ›› Issue (4): 625-630.

流体热物性对粗糙微通道内传热性能的影响

苗辉,黄勇,谢法

北京航空航天大学能源与动力工程学院,北京 100191;北京航空航天大学能源与动力工程学院,北京 100191;北京航空航天大学能源与动力工程学院,北京 100191

发布日期:2021-08-15
作者简介:苗辉(1984—),男,博士生,研究领域为微通道传热技术。E-mail:miaohui@sjp.buaa.edu.cn

Effects of thermal properties of the working fluid on heat transfer characteristic in rough microchannels

College Energy and Power Engineering,Beijing University of Aeronautics and Astronautics, Beijing 100191, China;College Energy and Power Engineering,Beijing University of Aeronautics and Astronautics, Beijing 100191, China;College Energy and Power Engineering,Beijing University of Aeronautics and Astronautics, Beijing 100191, China

Published:2021-08-15

摘要/Abstract

摘要： 为了明晰工质种类对微通道传热性能的影响,研究了导热系数λ,比热容cp,动力粘度μ和密度ρ影响微通道传热性能的规律。首先研究了水和煤油在构造的粗糙微通道中流动与传热性质的差异,然后将各个因素孤立的研究其对于整体传热性能的影响。结果发现,在粗糙微通道中的层流充分发展流动状态,Poiseuille数(Po)基本不随Re变化,也不随工质热物性变化；水和煤油的Nusselt数(Nu)都随Re的增大而增大,且煤油的Nu的数值和随Re的增长率都大于水的对应值。研究还发现,Nu随着λ的增加而减小,随着cp和μ的增加而增加,不随密度ρ变化；同时,λ和μ对Nu的影响比cp大。 

关键词: 微通道热沉;液体冷却;传热强化;粗糙度效应;热物性

Abstract: The effects of thermal properties on the heat transfer patterns in rough microchannels have been investigated using numerical simulations. The four thermal properties are:thermal conductivity λ, specific heat capacity cp, dynamic viscosity μ, and density ρ. A simple microchannel was modeled with rectangular roughness. The effect of the Reynolds number (Re) was examined on both flow and heat transfer for water and kerosene. Then each thermal property parameter was separated from others to check the effects on heat transfer, with the respective variations of corresponding values from water to kerosene. It was found that in the developed laminar flow through the rough microchannels, the Poiseuille numbers (Po) were almost independent of Re and the kind of fluids, but the Nusselt numbers (Nu) of both fluids increased with Re. In addition, the value and the incremental rate of Nu for kerosene were larger than the corresponding values for water. Finally, results showed an increase in Nu with the decrease of λ, with the increase of cp and μ. And cp showed a weaker effect on Nu than λ and μ. 

Key words: Microchannel heat sink; Liquid cooling;Heat transfer enhancement;Roughness effect; Thermal properties

苗辉,黄勇,谢法. 流体热物性对粗糙微通道内传热性能的影响[J]. 推进技术, 2012, 33(4): 625-630.

参考文献

[2] Wu H Y, Cheng P.An Experimental Study of Convective Heat Transfer in Silicon Microchannels with Different Surface Conditions[J].International Journal of Heat and Mass Transfer, 3,6(14):2547-2556.
[3] Shen S, Xu J L, Zhou J J.Flow and Heat Transfer in Microchannels with Rough Wall Surface[J].Energy Conversion and Management, 6,7(11-12):1311-1325.
[4] Qu W, Mudawar I.Experimental and Numerical Study of Pressure Drop and Heat Transfer in a Single-Phase Micro-channel Heat Sink[J].International Journal of Heat and Mass Transfer, 2,5(12):2549-2565.
[5] Lee P S, Garimella S V, Liu D.Investigation of Heat Transfer in Rectangular Microchannels[J].International Journal of Heat and Mass Transfer, 5,8(9):1688-1704.
[6] Zhang H Y, Pinjala D, Wong T N.Single-Phase Liquid Cooled Microchannel Heat Sink for Electronic Packages [J].Applied Thermal Engineering, 5,5(10):1472-1487.
[7] 周继军, 申盛, 徐进良,等.微槽道内单相流动阻力与传热特性[J].化工学报, 5,6(10):1849-1855.
[8] 蒋洁, 郝英立, 施明恒.矩形微通道中流体流动阻力和换热特性实验研究[J].热科学与技术, 6,5(3):189-194.
[9] Celata G P, Cumo M, Guglielmi M.Experimental Investigation of Hydraulic and Single Phase Heat Transfer in 0.130 mm Capillary Tube[J].Microscale Thermal Physical Engineering, 2002, (6):85-97.
[10] Owhaib W, Palm B.Experimental Investigation of Single-phase Convective Heat Transfer in Circular Microchannels[J].Experimental Thermal and Fluid Science, 4,8(2-3):105-110.
[11] Grohmann S.Measurement and Modeling of Single-Phase and Flow-Boiling Heat Transfer in Microtubes[J].International Journal of Heat and Mass Transfer, 5,8(19-20):4073-4089.
[12] Xie Y Q, Yu J Z, Zhao Z H.Experimental Investigation of Flow and Heat Transfer for the Ethanol-Water Solution and FC-72 in Rectangular Microchannels[J].Heat Mass Transfer, 2005, (41):695-702.
[13] Schilder B, Yu S C M, Kasagi N.Local Measurement of Forced Convection Heat Transfer in Micro Glass Tube [R].ASME ICNMM 2008-62054.
[14] Hsieh S S, Lin C Y.Convective Heat Transfer in Liquid Microchannels with Hydrophobic and Hydrophilic Surfaces[J].International Journal of Heat and Mass Transfer, 9,2(1-2):260-270.
[15] 俞坚, 马重芳, John L.陶瓷微通道内的传热和压降特性[J].工程热物理学报, 4,5(1):142-144.
[16] 甘云华, 徐进良.水和甲醇在硅基微通道中换热特性的实验研究[J].自然科学进展, 5,5(12):1498-1503.
[17] 魏珍, 吴慧英, 吴信宇.水/乙醇混合工质在硅基微通道中的流动与换热[J].化工学报, 8,9(11):2706-2712.
[18] Hamilton R E, Kennedy P G.Microchannel Cooling Using Aviation Fuels for Airborne Electronics[P].US Patent 5,2,558.
[19] 朱锟, 邓宏武, 王英杰,等.超临界压力下航空煤油结焦换热综述及实验[J].航空动力学报, 0,5(11):2472-2478.
[20] Gloss D, Herwig H.Microchannel Roughness Effects:A Close-Up View[J].Heat Transfer Engineering, 9,0(1-2):62-69.
[21] 杨世铭, 陶文铨.传热学[M].北京:高等教育出版社,2005:162-171.
[22] Croce G, D''Agaro P, Nonino C.Three-Dimensional Roughness Effect on Microchannel Heat Transfer and Pressure Drop[J].International Journal of Heat and Mass Transfer, 7,0(25-26):5249-5259.
[23] Gamrat G, Favre-Marinet M, Le Person S.Modelling of Roughness Effects on Heat Transfer in Thermally Fully-Developed Laminar Flows Through Microchannels[J].International Journal of Thermal Sciences, 9,8(12):2203-2214.
[24] Croce G, D''Agaro P.Numerical Analysis of Roughness Effect on Microtube Heat Transfer[J].Superlattices and Microstructures, 4,5(3-6):601-616.
[25] Miao H, Huang Y, Xie F, et al.Effects of Dented Roughness on Laminar Flow and Heat Transfer in Microchannels[C]. Washington DC:Proceedings of the International Heat Transfer Conference, ASME, 2010:109-115.