超高速转子系统动力学特性(I):无碰摩转子

推进技术 ›› 2012, Vol. 33 ›› Issue (5): 695-703.

超高速转子系统动力学特性(I):无碰摩转子

陈巍,杜发荣,丁水汀,郭宝亭

中国科学院工程热物理研究所/推进与动力实验室,北京 100190;北京航空航天大学交通科学与工程学院,北京 100191;北京航空航天大学能源与动力工程学院,北京 100191;中国科学院工程热物理研究所/推进与动力实验室,北京 100190

发布日期:2021-08-15
作者简介:陈巍(1980—),男,博士,助理研究员,研究领域为转子动力学/振动测试与分析。E-mail:yiquncw@163.com

Research on Dynamic Characteristics for a Super-High Speed Rotor System (I):Rotor System Without Rubs

Propulsion and Power Laboratory, Institute of Engineering Thermophysics,Chinese Academy of Sciences, Beijing 100190, China;School of Transportation Science and Engineering,Beijing University of Aeronautics and Astronautics,Beijing 100191,China;School of Jet Propulsion, Beijing University of Aeronautics and Astronautics, Beijing, 100191, China;Propulsion and Power Laboratory, Institute of Engineering Thermophysics,Chinese Academy of Sciences, Beijing 100190, China

Published:2021-08-15

摘要/Abstract

摘要： 为排查超高速转子系统碰摩故障原因,利用混沌、分岔理论,研究了无碰摩转子系统的动力学特性。以实际转子结构为对象:建立物理模型；由拉格朗日(Lagrange)法建立系统动力学方程；用四阶龙格库塔(Runge-Kutta)法数值求解方程；结合分岔图、轴心轨迹、相图、Poincare映射等手段,分析了无故障转子系统的动力学行为及系统参数变化对其动力特性的影响。结果表明:该转子系统动力学状态过渡过程不明显,在全转速域内,振动以高频低幅为主,高速时具有良好的动力稳定性；扭振特征不明显；质量盘之间的动力耦合效应较弱,有利于系统稳定性；对于单个质量盘,弯振和摆振具有同步性和耦合性,横向振动和扭振动力耦合效应较弱。研究结果说明,该转子结构在冷态条件下,不致在高速状态下引起混沌运动状态。

关键词: 超高速;转子系统;振动;碰摩;动力学;分岔;混沌

Abstract: To check the reason that rotor rubbed with stator, the dynamic characteristics of a super-high speed rotor system without rubs were studied based on theory of dynamic system chaos and bifurcation. Physical model was built according to the prototype of the rotor, dynamics equations for the system were deduced by Lagrange method and solved numerically by 4th Runge-Kutaa method. By combining ways of bifurcation chart, shaft orbit, phase diagram and Poincare map, contents are studied including dynamic features and effects that changes of system parameters act on the rotor system. The results show that the rotor system has the ability to transfer into different dynamic behaviors quickly. Its vibration presents low amplitude with high frequency in whole work domain and its dynamic stability is good under high speed. Torsional-vibration is unconspicuous and dynamic coupling effect between different discs is so weak that it is helpful to system stability. For single disc, bending vibration and pendulum vibration are synchronous and coupling, and lateral vibration and torsional vibration are weakly coupled with each other. All those tend to show that the rotor system will not change into chaos at high speed when it works under natural condition. These contents are helpful for pointing out the direction to check fault reason. 

Key words: Super-high speed; Rotor system; Vibration; Rub; Dynamics; Bifurcation; Chaos

陈巍,杜发荣,丁水汀,郭宝亭. 超高速转子系统动力学特性(I):无碰摩转子[J]. 推进技术, 2012, 33(5): 695-703.

参考文献

[2] Glodman P, Muszynska A.Chaotic Behavior of Rotor/Stator Systems with Rubs [J].Journal of Engineering for Gas Turbines and Power, 4,6(7):692-701.
[3] Muszynska A, Glodman P.Chaotic Responses of Unbalanced Rotor/Bearing/Stator Systems with Looseness or Rubs [J].Chaos, Solutions & Fractals, 5,5(9):1683-1704.
[4] Tejas H.Patel, Ashish K Darpe.Coupled Bending-Torsional Vibration Analysis of Rotor with Rub and Crack [J].Journal of Sound and Vibration, 9,6(5):740-752.
[5] Yu J J, Glodman P, Bently T E.Rotor/Seal Experimental and Analytical Study on Full Annular Rub [J].Journal of Engineering for Gas Turbines and Power, 2,4(4):340-350.
[6] Glodman P, Muszynska A.Rotor-to-Stator Rub-Related Thermal Mechanical Effects in Rotating Machinery [J].Chaos,Solitons and Fractals, 5,5(9):1579-1601.
[7] Zhang W M, Meng G.Stability Bifurcation and Chaos of a High-Speed Rub-Impact Rotor System in MEMS [J].Sensors and Actuators, 6,7(11):163-178.
[8] 汪建晓, 孟光.磁流变液阻尼器-柔性转子系统的力学模型(I):单盘悬臂转子[J].佛山科学技术学院学报(自然科学版), 2,0(4):8-13.
[9] 汪建晓, 孟光.磁流变液阻尼器-柔性转子系统的力学模型(II):双盘悬臂转子[J].佛山科学技术学院学报(自然科学版), 3,1(1):15-18.
[10] 李永强, 刘杰, 刘宇, 等.碰摩转子弯扭摆藕合振动非线性动力学特性[J].机械工程学报,7,3(2):44-49.
[11] 何成兵, 顾煜炯, 李猛.Jeffcott转子碰摩的弯扭耦合振动特性分析[J].振动与冲击,6,5(2):59-69.
[12] 张文明, 孟光, 冷小磊, 等.碰摩微转子系统稳定性与分岔行为分析[J].机械科学与技术,6,5(6):740-744.
[13] 傅忠广, 杨昆, 宋之平.转子动态过程弯扭藕合振动的仿真和实验[J].华北电力大学学报, 9,6(2):55-59.
[14] 何成兵, 顾煜炯, 陈祖强.质量不平衡转子的弯扭耦合振动分析[J].中国电机工程学报, 6,6(14):134-139.
[15] 刘献栋, 李其汉.转静件碰摩模型及不对中转子局部碰摩的混沌特性[J].航空动力学报, 8,3(4):361-365.
[16] 张俊红, 孙少军, 程晓鸣, 等.弯扭耦合的旋转机械轴系弯振特性的研究[J].动力工程,5,5(3):305-311.
[17] 刘占生, 李存生, 黄智勇, 等.涡轮泵转子弯扭耦合振动与分岔特性研究[J].火箭推进, 7,3(5):11-17.
[18] 刘长利, 姚红良, 罗跃纲, 等.松动碰摩转子轴承系统周期运动稳定性研究[J].振动工程学报, 4,7(3):336-340.
[19] 罗跃纲, 李振平, 刘长利, 等.转子系统松动与碰摩耦合故障非线性特性研究[J].中国机械工程, 3,4(14):1224-1227.
[20] 付波.基于弯扭耦合振动与轴心轨迹辨识的水轮发电机组故障诊断研究[D].武汉:华中科技大学, 2006.
[21] 钟一谔,何衍宗.转子动力学[M].北京:清华大学出版社, 1987.
[22] 闻邦春, 顾家柳, 夏松波,等.高等转子动力学理论技术与应用[M].北京:机械工业出版社, 2000.