微小推力冷气发动机动静态性能实验研究

推进技术 ›› 2013, Vol. 34 ›› Issue (6): 728-733.

微小推力冷气发动机动静态性能实验研究

李明新,汤海滨,张尊

北京航空航天大学宇航学院,北京 100191;北京航空航天大学宇航学院,北京 100191;北京航空航天大学宇航学院,北京 100191

发布日期:2021-08-15
作者简介:李明新(1985—),男,硕士生,研究领域为小推力发动机测试。E-mail:thb@buaa.edu.cn
基金资助:
国家自然科学基金 (51276006);航天支撑基金资助。

Experimental Investigation on Dynamic and Steady Performance of Cold Gas Micro-Propulsion Thruster

School of Astronautics, Beijing University of Aeronautics and Astronautics,Beijing 100191,China;School of Astronautics, Beijing University of Aeronautics and Astronautics,Beijing 100191,China;School of Astronautics, Beijing University of Aeronautics and Astronautics,Beijing 100191,China

Published:2021-08-15

摘要/Abstract

摘要： 针对所设计的微小推力冷气发动机进行高空模拟试验,搭建了试验系统,并应用推力测试装置测量了发动机不同推进剂下的推力和比冲,得到了发动机的稳态特征参数,当分别以丙烷和氮气为推进剂时,平均比冲分别为83.5s和75.6s。为了获得发动机的动态特征参数,对推力测量装置进行了负阶跃力和正阶跃力动态标定,通过标定数据的对比验证得到推力测量系统的延迟时间为90ms；进而在特定试验工况下,给出了发动机和推力测量装置实际上升时间的计算方法,得到丙烷质量流量为40mg/s时,发动机的上升时间为27.1ms。 

关键词: 微小推力冷气发动机;静态标定;动态标定;负阶跃力;正阶跃力;响应时间 

Abstract: Aiming at a cold gas micro-propulsion thruster,a high altitude simulation experiment system was studied, and the experiment system was set up. The thrust and specific impulse of the thruster were measured using the thrust test system. The steady characteristic of the thruster was determined. When the propellants are propane and nitrogen, respectively, the average specific impulse of the thruster are 83.5s and 75.6s, respectively. In order to acquire the dynamic performance of the thruster, the test system should be calibrated with the positive and negative step force, and then the delay time of the test system was 90ms based on the calibration data. Under the specific test condition, the rise time calculation method of thruster and thrust test system was proposed. When mass flux of propane is 40mg/s, the engine rise time is 27.1ms. 

Key words: Cold gas micro-propulsion thruster;Steady calibration;Dynamic calibration;Negative step force;Positive step force;Response time

李明新,汤海滨,张尊. 微小推力冷气发动机动静态性能实验研究[J]. 推进技术, 2013, 34(6): 728-733.

LI Ming-xin,TANG Hai-bin,ZHANG Zun. Experimental Investigation on Dynamic and Steady Performance of Cold Gas Micro-Propulsion Thruster[J]. Journal of Propulsion Technology, 2013, 34(6): 728-733.

参考文献

[1] Zakirov V, Erichsen P, Lawrence T J, et al.Specifics of Small Satellite Propulsion:Part II[R].AIAA 2001-3834.
[2] 屠善澄.卫星姿态动力学与控制(4)[M].北京:宇航出版社,2006.
[3] Sasoh A.A High-Resolution Thrust Stand for Ground Tests of Low-Thrust Space Propulsion Devices[J].Review of Scientific Instruments,1993,4(3):719-723.
[4] Barber B C.Thrust Measuring System for Electrothermal Thrusters[J].Journal of Spacecraft and Rockets, 1970,1:549-554.
[5] Haan TW.PPT thrust stand[R].AIAA 95-2917.
[6] 刘向阳,范宁军,李科杰.微型推进器推力测试的现状发展趋势[J].测控技术,2004,23(5):18-20.
[7] 汤海滨,刘宇,赵宝瑞,等.一种电推力器用小推力测量系统[J].推进技术,2001,22(2):174-176.(TANG Hai-bin,LIU Yu,ZHAO Bao-rui,et al.A Small Thrust Measurement System of Electric Thruster[J].Journal of Propulsion Technology,2001,2(2):174-176.
[8] 张廷良.采用液压力反馈系统进行瞬态推力测量的研究[J].推进技术,1985,6(2):61-68.
[9] Enrico C,Andrea R.Digital Control of an Interfere Metric Balance for Micro-Thruster Measurement[C].Denver:Proceedings of the American Control Conference,2003.
[10] 汤海滨,刘畅,向民,等.微推力全弹性测量装置[J].推进技术,2008,29(6):703-706.(TANG Hai-bin, LIU Chang, XIANG Min, et al.Full Elastic Microthrust Measurement Equipment[J].Journal of Propulsion Technology,2008,9(6):703-706.
[11] 施陈波,汤海滨,张莘艾,等.mN级推力架静态特性及推力测量不确定度分析[J].固体火箭技术,2011,(3):398-402.
[12] Tang H B, Zi Z P, Jin X W, et al.Design and Development:A Micro-Propulsion System with Propane Propellant for Small Satellites [J].Advanced Science Letters, 2011,(4):2015-2021.
[13] Tang H B,Zhang X A, Liu Y,et al.Experimental Study of Startup Characteristics and Performance of a Low-Power Arcjet [J].Journal of Propulsion and Power, 2011,7(1):218-226.
[14] 李明新,汤海滨.动态微小推力的测量方法及分析[C].敦煌:中国宇航学会固体火箭推进暨航天第三专业信息网学术交流会,2011.