总压畸变对超声速压气机动叶端区流场结构的影响

推进技术 ›› 2013, Vol. 34 ›› Issue (6): 747-753.

总压畸变对超声速压气机动叶端区流场结构的影响

孙鹏,高海洋,钟兢军

大连海事大学轮机工程学院,辽宁大连 116026;大连海事大学轮机工程学院,辽宁大连 116026;大连海事大学轮机工程学院,辽宁大连 116026

发布日期:2021-08-15
作者简介:孙鹏(1979—),男,博士,研究领域为发动机气动热力学。E-mail:sp_hit@hotmail.com
基金资助:
国家自然科学基金青年基金资助项目(51006014)；中央高校基本科研业务费专项资金(017102)。

Effects of Total Pressure Distortion on Rotor End Wall Flow Structure of a Supersonic Compressor

Marine Engineering College, Dalian Maritime University, Dalian 116026, China;Marine Engineering College, Dalian Maritime University, Dalian 116026, China;Marine Engineering College, Dalian Maritime University, Dalian 116026, China

Published:2021-08-15

摘要/Abstract

摘要： 采用全周非定常数值模拟方法,对两种畸变进口条件下的超声速压气机流场进行求解,了解动叶流场参数变化和气动性能与畸变来流条件的关系,重点分析动叶根部和顶部附近激波位置、结构和强度的变化情况,揭示动叶流场参数的动态变化规律。研究表明,随畸变区范围增加,压气机质量流量和效率下降；动叶流场参数对畸变来流的动态响应主要表现为激波位置、结构和强度的周期变化,当畸变区范围足够大时,流道在畸变区中会经历深度畸变；27.2%畸变时,畸变区内流道存在根部和顶部流动状态不一致的时刻,流场状态复杂。38.2%畸变时,畸变区内动叶叶顶和叶根区域都能达到深度畸变状态,流动损失较大且稳定性差。 

关键词: 总压畸变;数值模拟;压气机;动叶;端区 

Abstract: In order to analyze the response of flow parameters in rotor to the distorted inlet conditions, full annuls unsteady numerical simulation was carried out to study a supersonic compressor rotor flow field with two kinds of distorted inlets. Position, structure and intensity of shock wave near end walls were analyzed in detail. Study shows that the compressor mass flow rate and efficiency will decrease as distorted area increases. Distorted flow impact on rotor flow field is mainly reflected in the influence on shock wave structure, position and intensity. If the distorted region is large enough, deep distortion will be induced in rotor passages. The flow fields in rotor hub and casing area are not coincident in distorted region with 27.2% distortion.The flow field in rotor is even more complex and the flow fields are both even more deeply distorted with 38.2% distortion. 

Key words: Total pressure distortion; Numerical simulation; Compressor; Rotor; End wall

孙鹏,高海洋,钟兢军. 总压畸变对超声速压气机动叶端区流场结构的影响[J]. 推进技术, 2013, 34(6): 747-753.

SUN Peng, GAO Hai-yang, ZHONG Jing-jun. Effects of Total Pressure Distortion on Rotor End Wall Flow Structure of a Supersonic Compressor[J]. Journal of Propulsion Technology, 2013, 34(6): 747-753.

参考文献

[1] 张皓光, 楚武利, 吴艳辉,等.进口总压畸变对压气机性能及流场影响的机理研究[J].机械科学与技术, 2010,9(7):880-885.
[2] Dragan K, Udo S, Eugen L.Hub-Corner Stall in Compressor Cascades:A Comparison Between Experimental and Numerical Results[R].ISABE-2009-1335.
[3] 李传鹏, 胡骏, 王英锋,等.进气畸变对压气机稳定性的影响[J].工程热物理学报, 2006,7(5):778-780.
[4] Gourdain, N, Burguburu, S, Michon, G J, et al.About the Numerical Simulation of Rotating Stall Mechanisms in Axial Compressors[R].ASME 2006-GT-90223.
[5] Longley J P, Shin H W, Plumley R E, et al.Effects of Rotating Inlet Distortion on Multistage Compressor Stability[J].ASME J.Turbomachinery,1996,8(2):181-188.
[6] 屠宝峰, 胡俊.径向进气总压畸变对压气机气动稳定性的影响[J].推进技术, 2012,3(2):167-173.( TU Bao-feng, HU Jun.Effect of Total Pressure Distortion on Aerodynamic Stability of Compressor[J].Journal of Propulsion Technology, 2012,3(2):167-173.)
[7] 李美林, 林峰, 陈静宜,等.周向进口畸变对压气机失速过程的影响[J].工程热物理学报, 2005,6(6) .
[8] 童志庭,张靖煊,李美林,等.不同进口畸变下低速压气机近失速状态非定常特征[J].工程热物理学报,2006,7(1):51-53.
[9] Rade D, Bolecs A, Russler P.Influence of Inlet Distortion on Transonic Compressor Blade Loading[R].AIAA 95-2461.
[10] Steven E G, David C, Steven L, et al.An Investigation of Wake-Shock Interactions in a Transonic Compressor with DPIV and Time-Accurate CFD[R].ASME 2005-GT-69107.
[11] 丁可金, 楚武利, 卢新根,等.单级轴流压气机内部三维流动的数值模拟[J].流体机械,2005,3(8):21-23.
[12] 张士杰, 袁新, 叶大均.跨音速轴流压气机级三维粘性流场全工况数值模拟[J].工程热物理学报,2003,4(1):43-45.
[13] Peng Sun, Ji’ang Han, Jingjun Zhong, et al.Effects of Bowed Stators on A Transonic Fan with Distorted Inlet[R].ASME 2008-GT-50523.