基于V型槽的空气/煤油燃气发生器火焰稳定方法研究

推进技术 ›› 2013, Vol. 34 ›› Issue (9): 1231-1239.

基于V型槽的空气/煤油燃气发生器火焰稳定方法研究

康忠涛^1,2,李清廉^1,2,张新桥^1,2

国防科学技术大学高超声速冲压发动机技术重点实验室,湖南长沙 410073;国防科学技术大学高超声速冲压发动机技术重点实验室,湖南长沙 410073;国防科学技术大学高超声速冲压发动机技术重点实验室,湖南长沙 410073

发布日期:2021-08-15
作者简介:康忠涛(1987—),男,博士生,研究领域为先进火箭及其组合推进技术,E-mail:kangzhongtao@126.com

Flame Stabilization of Air/Kerosene Gas Generator Based on V-Gutter

Science and Technology on Scramjet Laboratory, National University of Defense Technology, Changsha 410073, China;Science and Technology on Scramjet Laboratory, National University of Defense Technology, Changsha 410073, China;Science and Technology on Scramjet Laboratory, National University of Defense Technology, Changsha 410073, China

Published:2021-08-15

摘要/Abstract

摘要： 为实现空气/煤油燃气发生器的可靠点火和稳定燃烧,采用试验与数值仿真相结合的方法对V槽火焰稳定器应用于燃气发生器时阻塞比和安装位置的选取进行了研究。发现不同阻塞比的火焰稳定器安装于燃气发生器不同位置时局部油气比可以是富油或贫油,甚至出现火焰稳定器一侧为贫油,另一侧为富油的状态。从接近当量比侧向贫油侧的热量和质量传递可以使得贫油侧的火焰稳定性能提高。钝体稳定的空气/煤油部分预混火焰存在“熄火-再点火”过程,其熄火频率为30Hz,高于贫油预混火焰的10Hz。阻塞比约0.6的V槽火焰稳定性能较好,获得了空气/煤油燃气发生器采用钝体稳定火焰时稳定器安装的特征长度范围。 

关键词: 空气/煤油燃气发生器;V型槽火焰稳定器;火焰稳定方案;稳焰特性 

Abstract: In order to improve the ignition and combustion characteristics of air/kerosene gas generator, flame stability of V-gutters with different blockage ratio and fix posiziton was investigated by experiment and simulation. The flame holder with different blockage ratio and fixing position could work in fuel rich or fuel lean condition locally, or even one side of flame holder fuel rich, the other side fuel lean. The heat and mass transfer from the richer to the leaner side increases the flame stability of the leaner side. The ‘extinction-reignition’ process occurs in bluff body stabilized partially premixed flames, and the frequency of ‘extinction-reignition’ is about 30Hz, larger than that of lean premixed flames, which is about 10Hz. The flame stabilized by V-gutter with a blockage ratio of 0.6is more stable.The characteristic length range with this flame holder in air/kerosene gas generator has been obtained. 

Key words: Air/kerosene gas generator; V-gutter; Flame stabilize strategy; Flame stability

康忠涛,李清廉,张新桥. 基于V型槽的空气/煤油燃气发生器火焰稳定方法研究[J]. 推进技术, 2013, 34(9): 1231-1239.

KANG Zhong-tao^1,2, LI Qing-lian^1,2, ZHANG Xin-qiao^1,2. Flame Stabilization of Air/Kerosene Gas Generator Based on V-Gutter[J]. Journal of Propulsion Technology, 2013, 34(9): 1231-1239.

参考文献

[1] 钟战.燃气发生器点火与燃烧性能研究[D].长沙:国防科学技术大学, 2008.
[2] Ninucci M A S, Oliva J L S.On the Development of a Gas Generator for CO₂-N₂Gas Dynamic Lasers Utilizing Liquid Fuel and Liquid Oxidizer[R].AIAA 93-3187.
[3] 纵苏.液氧/煤油燃气发生器的试验研究[J].推进技术, 1994,5(4):58-61.( ZONG Su.Experimental Investigation of a LOx/Kerosene Gas Generator[J].Journal of Propulsion Technology, 1994,5(4):58-61.)
[4] 曹再勇, 蔡体敏, 谭永华.富氧燃气发生器三维燃烧流场的数值模拟[J].西北工业大学学报, 2005,5:1000-2758.
[5] 田章福.低浓度酒精/过氧化氢燃气发生器喷雾燃烧过程研究[D].长沙:国防科学技术大学, 2007.
[6] 李庆, 李清廉, 王振国.燃气发生器结构对燃烧性能的影响[J].航空动力学报, 2008,1:1000-8055.
[7] Chaudhuri S,Kostka S,Tuttle S G, et al.Blowoff Mechanism of Two Dimensional Bluff-Body Stabilized Turbulent Premixed Flames in a Prototypical Combustor[J].Combustion and Flame, 2011,8(7):1358-1371.
[8] 李庆, 潘余, 谭建国.亚燃冲压发动机中凹腔与V槽火焰稳定器性能对比分析[J].航空动力学报, 2010,5(1):35-40.
[9] Fluker B J, O′Loughlin J R.Effects of Flow Transients on the Opposed Jet Flame Stabilizer[J].Combustion and Flame, 1971,6(3):295-302.
[10] Majumdar S, Bhaduri D.On Recirculating Flow in an Opposed Jet Flame Holder[J].Applied Mathematical Modelling, 1981,5(3):179-184.
[11] Lovett J A, Brogan T P, Philippona D S.Development Needs for Advanced Afterburner Designs[R].AIAA 2004-4192.
[12] Huang W,Pourkashanian M, Ma L, et al.Investigation on the Flameholding Mechanims in Supersonic Flows:Backward-Facing Step and Cavity Flameholder[J].Journal of Visualization, 2011,4:63-74.
[13] DeZubay E A.Characteristics of Disk-Controlled Flame[J].Aero Digest, 1950:54-57.
[14] Plee S L,Mellor A M.Characteristic Time Correlation for Lean Blowoff of Bluff-Body-Stabilized Flames[J].Combustion and Flame, 1979,5(1):61-80.
[15] Ozawa R I.Survey of Basic Data on Flame Stabilization and Propagation for High Speed Combustion System[R].AFAPL-TR-70-81.
[16] Huelskamp B C,Kiel B V, Lynch A C, et al.Improved Correlation for Blowout of Bluff Body Stabilized Flames[R].AIAA 2011-66.
[17] Shanbhogue S J,Husain S, Lieuwen T.Lean Blowoff of Bluff body Stabilized Flames:Scaling and Dynamics[J].Progress in Energy and Combustion Science, 2009,5(1):98-120.
[18] Li H G, Sung H G., Yang V.Large Eddy Simulation of Combustion Dynamics of Bluff Body Stabilized Flame[R].AIAA 2011-783.
[19] Gokulakrishnan P, Foli K, Klassen M, et al.LES-PDF Modeling of Flame Instability and Blow-Out in Bluff-Body Stabilized Flames[R].AIAA 2009-5409.
[20] Tuttle S G, Chaudhuri S, Kostka Jr S, et al.Time-Resolved Blowoff Transition Measurements for Two-Dimensional Bluff Body-Stabilized Flames in Vitiated Flow[J].Combustion and Flame, 2012,9(1):291-305.
[21] Chaudhuri S,Kostka S,Renfro M W, et al.Blowoff Dynamics of Bluff Body Stabilized Turbulent Premixed Flames[J].Combustion and Flame, 2010,7(4):790-802.
[22] 李庆.基于凹腔火焰稳定器的亚燃冲压发动机燃烧室点火过程研究[D].长沙:国防科学技术大学, 2010.
[23] Tuttle S G, Chaudhuri S, Kopp-Vaughan K M, et al.Blowoff Dynamics of Asymmetrically-Fueled, Bluffbody Flames[R].AIAA 2011-235.
[24] Chaudhuri S, Kostka S,Tuttle S G, et al.Blowoff Mechanism of Two Dimensional Bluff-Body Stabilized Turbulent Premixed Flames in a Prototypical Combustor[J].Combustion and Flame, 2011,8(7):1358-1371.
[25] Erickson R R, Soteriou M C.The Influence of Reactant Temperature on the Dynamics of Bluff Body Stabilized Premixed Flames[J].Combustion and Flame, 2011,8(12):2441-2457.