M3条件下乙烯燃料超燃冲压发动机空气节流点火试验

推进技术 ›› 2013, Vol. 34 ›› Issue (9): 1240-1247.

M3条件下乙烯燃料超燃冲压发动机空气节流点火试验

邓维鑫^1,2,乐嘉陵²,杨顺华²,田野²,张弯洲^1,2,许明恒¹

西南交通大学机械工程学院,四川成都 610031;中国空气动力研究与发展中心高超中心,四川绵阳 621000;中国空气动力研究与发展中心高超中心,四川绵阳 621000;中国空气动力研究与发展中心高超中心,四川绵阳 621000;西南交通大学机械工程学院,四川成都 610031;西南交通大学机械工程学院,四川成都 610031

发布日期:2021-08-15
作者简介:邓维鑫(1983—),男,博士生,研究领域为高超声速推进系统。E-mail:dengweixin21@yahoo.com.cn
基金资助:
国家自然科学青年科学基金(10902109)。

Air-Throttling Ignition Experiments of Ethylene Fueled Scramjet at Mach 3

School of Mechanical Engineering, Southwest Jiaotong University, Chengdu 610031, China;Air-breathing Hypersonic Technology Research Center, China Aerodynamics Research and Development Center, Mianyang 621000, China;Air-breathing Hypersonic Technology Research Center, China Aerodynamics Research and Development Center, Mianyang 621000, China;Air-breathing Hypersonic Technology Research Center, China Aerodynamics Research and Development Center, Mianyang 621000, China;School of Mechanical Engineering, Southwest Jiaotong University, Chengdu 610031, China;School of Mechanical Engineering, Southwest Jiaotong University, Chengdu 610031, China

Published:2021-08-15

摘要/Abstract

摘要： 在隔离段入口Ma=3(模拟飞行马赫数6.5)条件下,采用乙烯燃料的超燃冲压发动机点火十分困难。为解决该难题,采用了空气节流作为辅助点火措施。基于脉冲燃烧风洞直连式试验平台进行了空气节流点火试验,通过壁面压力测量,获得了节流点火的火焰发展历程。以点火时间为指标,对节流流量、乙烯当量比、节流时间等参数进行了定量分析,节流流量的调节范围为0%~45%,乙烯当量比调节范围为0.6~1.2,节流时间调节范围为190~350ms。分析了三个节流参数各自的作用机理,通过数据拟合,绘制了节流流量与点火时间、乙烯当量比与点火时间的关系曲线,揭示了节流时间与点火时间的关系。 

关键词: 超燃冲压发动机;空气节流;点火;节流流量;节流时间;定量分析 

Abstract: With the Ma=3inflow conditions at isolator entry (simulating flight Ma=6.5), it is difficult to ignite ethylene fueled scramjet. Thus, air-throttling strategy was used in the ignition experiments conducted at the pulse combustion wind tunnel facility of China Aerodynamics Research and Development Center (CARDC). The time history of combustion was obtained through wall pressure measurement. The quantitative analysis of the effects of throttling mass flux, ethylene equivalence ratio and throttling duration on ignition were conducted with the index of ignition time. The influence of throttling mass flux was checked at the range of 0%~45%, with ethylene equivalence ratio range of 0.6~1.2and throttling duration range of 190ms~350ms. All of the three throttling parameters were examined intensively to explore their mechanisms of facilitating ignition. The evolution curves of ignition time with throttling mass flux and ignition time with ethylene equivalence ratio were drawn by data fitting. Also the relationship between ignition time and throttling time was analyzed. 

Key words: Scramjet; Air-throttling; Ignition; Throttling mass flux; Throttling duration; Quantitative analysis

邓维鑫,乐嘉陵,杨顺华,田野,张弯洲,许明恒. M3条件下乙烯燃料超燃冲压发动机空气节流点火试验[J]. 推进技术, 2013, 34(9): 1240-1247.

DENG Wei-xin^1,2, LE Jia-ling², YANG Shun-hua², TIAN Ye², ZHANG Wan-zhou^1,2,XU Ming-heng¹. Air-Throttling Ignition Experiments of Ethylene Fueled Scramjet at Mach 3[J]. Journal of Propulsion Technology, 2013, 34(9): 1240-1247.

参考文献

[1] Corin segal.The Scramjet Engine:Processes and Characteristics [M].New York:Cambridge University Press,2009.
[2] Tohru Mitani, Nobuo ehinzei, Takeshi Kanda.Reaction and Mixing-Controlled Combustion in Scramjet Engines [R].AIAA 99-4871
[3] Tohru Mitani, Toshinori Kouchi.Flame Structures and Combustion Efficiency Computed for a Mach 6Scramjet Engine[J] .Combustion and Flame,2005(142):187-196.
[4] 潘余,刘卫东,梁剑寒,等.模型超燃发动机内着火过程分析[J].力学学报,2009,41(4):455-461.
[5] 田野,乐嘉陵,杨顺华,等.空气节流对超燃燃烧室火焰稳定影响的数值研究[J].推进技术,2013,4(5).(TIAN Ye, LE Jia-ling, YANG Shun-hua, et al.Numerical Study on Air Throttling Influence of Flame Stabilization in the Scramjet Combustor [J].Journal of Propulsion Technology,2013,4(5).)
[6] 邓维鑫,乐嘉陵,王西耀,等.空气节流对超燃发动机燃烧性能的影响[J].航空动力学报,2013,28(2):316-323.
[7] Jinhyeon Noh, Jeong-Yeol Choi, Jong-Ryul Byun, et al.Numerical Simulation of Auto-Ignition of Ethylene in a Scramjet Combustor with Air Throttling[R].AIAA 2010-7036.
[8] Jian Li, Fuhua Ma, Vigor Yang, et al.Control and Optimization of Ignition Transient in Scramjet Engine Using Air Throttling [R].AIAA 2006-1028.
[9] Mathur T, Lin K C, Kennedy P, et al.Liquid JP-7Combustion in a Scramjet Combustor[R].AIAA 2000-3581.
[10] Donbar J, Powell O, Gruber M, et al.Post-Test Analysis of Flush-Wall Fuel Injection Experiments in a Scramjet Combustor[R].AIAA 2001-3197.
[11] Yang V, Li J, Choi J Y, et al.Ignition Transient in an Ethylene Fueled Scramjet Engine with Air Throttling ,Part I:Non-Reacting flow Development and Mixing[R].AIAA 2010-409.
[12] Yang V, Li J, Choi J Y, et al.Ignition Transient in an Ethylene Fueled Scramjet Engine with Air Throttling.Part II:Ignition and Flame Development[R].AIAA 2010-410.
[13] Wen Bao, Jichao Hu, Youhai Zong, et al.Ignition Characteristic of a Liquid Kerosene Fueled Scramjet by Air Throttling Combined with a Gas Generator [J].Journal of Aerospace Engineering,2013,(2):1-27.
[14] 刘兴洲.中国超燃发动机研究回顾[J].推进技术,2008,9(4):385-395.( LIU Xing-zhou.Review of Scramjet Research in China[J].Journal of Propulsion Technology, 2008,9(4):385-395.)
[15] 刘昊,宋文艳,罗飞腾.污染空气对乙烯燃料超声速燃烧影响的试验[J].推进技术, 2011,2(1):70-75.( LIU Hao, SONG Wen-yan, LUO Fei-teng.Experiments on Vitiated Air Effects of Ethylene-Fueled Supersonic Combustion [J].Journal of Propulsion Technology,2011,2(1):70-75.)