超燃冲压发动机燃烧室空气节流技术研究

推进技术 ›› 2014, Vol. 35 ›› Issue (4): 499-506.

超燃冲压发动机燃烧室空气节流技术研究

田野¹,杨顺华¹, 邓维鑫^1,2,张弯洲^1,2

中国空气动力研究与发展中心吸气式高超声速技术研究中心,四川绵阳 621000;中国空气动力研究与发展中心吸气式高超声速技术研究中心,四川绵阳 621000;中国空气动力研究与发展中心吸气式高超声速技术研究中心,四川绵阳 621000;中国空气动力研究与发展中心吸气式高超声速技术研究中心,四川绵阳 621000

发布日期:2021-08-15
作者简介:田野(1987—),男,硕士,研究领域为超燃冲压发动机燃烧室技术。E-mail:tianye_cardc@163.com
基金资助:
国家自然科学基金(51376193)。

A Study on Air Throttling Technology in Scramjet Combustor

Airbreathing Hypersonics Research Center of China Aerodynamics Research and Development Center, Mianyang 621000, China;Airbreathing Hypersonics Research Center of China Aerodynamics Research and Development Center, Mianyang 621000, China;Airbreathing Hypersonics Research Center of China Aerodynamics Research and Development Center, Mianyang 621000, China;Airbreathing Hypersonics Research Center of China Aerodynamics Research and Development Center, Mianyang 621000, China

Published:2021-08-15

摘要/Abstract

摘要： 为考察空气节流对超燃冲压发动机燃烧室的影响,非定常数值模拟和地面实验相结合证实了空气节流可以实现超燃燃烧室燃料稳定燃烧,研究了节流位置、节流流量、节流撤去时间对节流效果的影响。结果表明:在燃烧室入口马赫数2,静温548.8K ,静压101555.9Pa条件下,745mm处节流时,激波串稳定时间较短,稳焰失败；875mm处节流时,火焰稳定成功。随着节流流量和节流撤去时间的增加,燃烧越来越剧烈,壁面压力逐渐升高,可能影响进气道的起动,对于本文来流条件,30%入口空气流量作为节流流量是合适的,440ms以前撤去空气节流是恰当的。 

关键词: 超燃冲压发动机;燃烧室;空气节流;火焰稳定;节流参数 

Abstract: In order to investigate the effects of air throttling on scramjet combustor, air throttling numerical simulation and experimental measurements were performed.The parameters(position,flux,air throttling off time) of air throttling were analyzed. Results show that under the inflow air condition,Ma=2.0,T_e=548.8K,p_e=101.6kPa,the stabilization time of shock train is shorter with the location of air throttling at 745mm from the combustor entrance and flame stabilization is failed. But the flame is successfully stabilized with the location of air throttling at 875mm. When the flux of air throttling and air throttling off time increase, the wall pressure of scramjet combustor increases, which may influence the inlet starting. 30% flux of inflow air and air throttling off time under 440ms for air throttling are fit for this inflow air condition. 

Key words: Scramjet engine; Combustor; Air throttling; Flame stabilization; Throttling parameters

田野,杨顺华,邓维鑫,张弯洲. 超燃冲压发动机燃烧室空气节流技术研究[J]. 推进技术, 2014, 35(4): 499-506.

TIAN Ye¹, YANG Shun-hua¹, DENG Wei-xin^1,2,ZHANG Wan-zhou^1,2. A Study on Air Throttling Technology in Scramjet Combustor[J]. Journal of Propulsion Technology, 2014, 35(4): 499-506.

参考文献

[1] Gruenig C,Avrashkov V,Mayinger F.Self-Ignition and Supersonic Reaction of Pylon-Injected Hydrogen Fuel[J].Journal of Propulsion and Power,2000,16(1).
[2] Kuo C L, Chung J T, Campbell C, et al.Flame Characteristics and Fuel Entrainment Inside a Cavity Flame Holder in a Scramjet Combustor [R].AIAA 2007-5381.
[3] Viacheslav A V, Yuri M S, Ruslan V A, et al.Experimental Research of Pre-Injected Methane Combustion in High Speed Subsonic Airflow[R].AIAA 2003-6940.
[4] Bao W, Hu J, Zong Y, et al.Ignition Characteristic of a Liquid Kerosene Fueled Scramjet by Air Throttling Combined with a Gas Generator[J].Journal of Aerospace Engineering, 2013,(2).
[5] 田野,乐嘉陵,杨顺华,等.空气节流对超燃燃烧室流场结构和燃料混合影响的数值研究[J].推进技术,2013,4(1):47-53.(TIAN Ye, LE Jia-ling, YANG Shun-hua, et al.Numerical Study on Air Throttling Influence of Flow Structure and Fuel- Air Mixing in the Scramjet Combustor [J].Journal of Propul Technology,2013,4(1):47-53.)
[6] 田野,乐嘉陵,杨顺华,等.空气节流对超燃燃烧室火焰稳定影响的数值研究[J].推进技术,2013,4(6).(TIAN Ye, LE Jia-ling, YANG Shun-hua, et al.Numerical study on air throttling influence of flame stabilization in the scramjet combustor [J].Journal of Propul Technology,2013,4(6).)
[7] 杨顺华.碳氢燃料超燃冲压发动机数值研究[D].绵阳:中国空气动力研究与发展中心,2006.
[8] 赵慧勇.超燃冲压整体发动机并行数值研究[D].绵阳:中国空气动力研究与发展中心,2005.
[9] 田野.空气节流对超燃燃烧室燃烧性能影响研究[D].绵阳:中国空气动力研究与发展中心,2013.
[10] Mawid M A, Sekar B.Kinetic Modeling of Ethylene Oxidation in High Speed Reacting Flows[R].AIAA 97-3269.
[11] 乐嘉陵, 刘伟雄, 贺伟,等.脉冲燃烧风洞及其在火箭和超燃发动机研究中的应用[J].试验流体力学,2005,9(1).
[12] 邢建文,杨样.H₂O污染对超燃冲压发动机燃烧室性能影响的三维数值模拟[J].推进技术,2011,2(1):5-10.(XING Jian-wen, YANG Yang.Three-Dimensional Simulation of H₂O Vitiation Effects on Combustor Performance for Scramjet [J].Journal of Propulsion Technology,2011,2(1):5-10)
[13] 刘昊,宋文艳,罗飞腾.污染空气对乙烯燃料超声速燃烧影响的试验[J].推进技术,2011,2(1):70-75.(LIU Hao, SONG Wen-yan, LUO Fei-teng.Experiments on Vitiated Air Effects of Ethylene-Fueled Supersonic Combustion [J].Journal of Propulsion Technology,2011,2(1):70-75.)
[14] 罗飞腾,宋文艳,刘昊.污染空气对氢燃料超声速燃烧室性能的影响 [J].推进技术,2010,1(4):401-405.(LUO Fei-teng, SONG Wen-yan, LIU Hao.Experimental Investigation for Vitiated Air Effects on Hydrogen-Fueled Supersonic Combustor Performance [J].Journal of Propulsion Technology,2010,1(4):401-405.)
[15] Pellett G L, Bruno C, Chinitz W.Review of Air Vitiation Effects on Scramjet Ignition and Flameholding Combustion Processes[R].AIAA 2002-3880.