甲基环己烷层流火焰燃烧特性研究

推进技术 ›› 2015, Vol. 36 ›› Issue (10): 1522-1527.

甲基环己烷层流火焰燃烧特性研究

徐庆尧,赵文涛,李兰,钟文丽,杨波

装备学院激光推进及其应用国家重点实验室，北京 101416,装备学院激光推进及其应用国家重点实验室，北京 101416,装备学院激光推进及其应用国家重点实验室，北京 101416,装备学院激光推进及其应用国家重点实验室，北京 101416,装备学院激光推进及其应用国家重点实验室，北京 101416

发布日期:2021-08-15

Study on Laminar Combustion Characteristics of Methylcyclohexane/Air

State Key Laboratory of Laser Propulsion and Application，Academy of Equipment，Beijing 101416，China,State Key Laboratory of Laser Propulsion and Application，Academy of Equipment，Beijing 101416，China,State Key Laboratory of Laser Propulsion and Application，Academy of Equipment，Beijing 101416，China,State Key Laboratory of Laser Propulsion and Application，Academy of Equipment，Beijing 101416，China and State Key Laboratory of Laser Propulsion and Application，Academy of Equipment，Beijing 101416，China

Published:2021-08-15

摘要/Abstract

摘要： 为了深入了解甲基环己烷的燃烧特性，利用定容燃烧弹和光学纹影测量系统分别对不同初始条件下的甲基环己烷/空气层流火焰燃烧特性进行研究。用自编的Matlab图片处理程序对定容弹内球形火焰传播过程的纹影图片进行分析，得到不同初始条件下甲基环己烷/空气的拉伸火焰传播速度、马克斯坦长度和层流燃烧速度等层流燃烧参数，并给出了以初始压力和初始温度为变量的甲基环己烷/空气的层流燃烧速度拟合公式。研究结果表明:甲基环己烷/空气的拉伸火焰传播速度与初始压力呈负相关，在当量比[?>0.8]时，与拉伸率呈负相关；马克斯坦长度与燃料空气当量比、初始压力和初始温度都呈负相关；层流燃烧速度与初始温度呈正相关，与初始压力呈负相关，并通过与其他的研究数据进行对比，表明构建的层流火焰燃烧速度拟合公式较为合理。

关键词: 层流燃烧速度；定容燃烧弹；马克斯坦长度；甲基环己烷

Abstract: In order to investigate combustion characteristics of methylcyclohexane，laminar combustion characteristics of methylcyclohexane/air mixtures were studied at different initial condition by constant combustion bomb and schlieren system， using Matlab image processing to analyze schlieren photography of spherical flame in constant combustion bomb. The stretched flame speed，Markstein lengths and laminar burning speed at the different initial condition were deduced，and fitting formula of laminar burning speed was obtained，taking initial pressure and initial temperature as variance. The results show that the stretched flame speed decreases with the increase of initial pressure，and decreases with the increase of stretch with equivalence ratio [?>0.8].Markstein length decreases with the increase of initial pressure，initial temperature and equivalence ratio. Laminar burning speed increases with the increase of initial temperature，and decreases with the increase of initial pressure. Comparison with other research data shows the fitting formula of laminar burning speed is more reasonable.

Key words: Laminar burning speed；Constant combustion bomb；Markstein length；Methylcyclohexane

徐庆尧,赵文涛,李兰,钟文丽,杨波. 甲基环己烷层流火焰燃烧特性研究[J]. 推进技术, 2015, 36(10): 1522-1527.

XU Qing-yao,ZHAO Wen-tao,LI Lan,ZHONG Wen-li,YANG Bo. Study on Laminar Combustion Characteristics of Methylcyclohexane/Air[J]. Journal of Propulsion Technology, 2015, 36(10): 1522-1527.

参考文献

[1] Brown A K, Maunder. Using Landfill Gas: A UK Perspective[J]. Renewable Energy, 1994, 5: 774-781.
[2] Goto S. Advanced Gas Engine Fueled By a Coal Seams Methane Gas[C]. USA: International Coalbed Methane Symposium, 2001.
[3] Bosschaart K J, Goey L P H. Detailed Analysis of the Heat Flux Method for Measuring Burning Velocities[J]. Combustion and Flame, 2003, 132(1-2): 170-180.
[4] Lewis B, Von Elbe G. Combustion Flames and Explosions of Gases[M]. New York: Academic Press, 1987.
[5] Huang Y, Sung C J, Eng J A. Laminar Flame Speeds of Primary Reference Fuels and Reformer Gas Mixtures[J]. Combustion and Flame, 2004, 139(3): 239-251.
[6] Bradley D. The Measurement of Laminar Burning Velocities and Markstein Numbers for Iso-Octane –Air and Iso-Octane-N-Heptane-Air Mixtures at Elevated Temperatures and Pressures in an Explosion Bomb[J]. Combustion and Flame, 1998, 115(1-2): 126-144.
[7] Yi Yang, Andre L. Boehman.Experimental Study of Cyclohexane and Methylcyclohexane Oxidation at Low to Intermediate Temperature in a Motored Engine[J]. Proceedings of the Combustion Institute, 2009, 32: 419-426.
[8] Fujia Wu, Kelly Andrew P, Law C K. Laminar Flame Speeds of Cyclohexane and Mono-Alkylated Cyclohexanes at Elevated Pressures[J]. Combustion and Flame,2012, 159: 1417-1425.
[9] 于维铭, 袁振, 钟北京. 正癸烷/甲苯/甲基环己烷火焰传播速度实验研究[J].推进技术, 2014, 35(11):1544-1550.(YU Wei-ming,YUAN Zhen,ZHONG Bei- jing. Experimental Study on Flame Speed of n-Decane/ Toluene/Methylcyclohexane [J]. Journal of Propulsion Technology, 2014, 35 (11): 1544-1550.)
[10] Chunsheng Ji, Enoch Dames, Baptiste Sirjean, et al.An Experimental and Modeling Study of the Propagation of Cyclohexane and Mono-Alkylated Cyclohexane Flames[J].Proceedings of the Combustion Institute,2011, 33: 971-978.
[11] Munzar J D, Akih-Kumgeh B, Denman B M, et al. An Experimental and Reduced Modeling Study of the Laminar Flame Speed of Jet Fuel Surrogate Components[J]. Fuel, 2013, 113: 586-597.
[12] Rotavera B, Vissotski A J, Krejci M C, et al. Laminar Flame Speed Measurements of Methyl Octanoate, n-Nonane, and Methylcyclohexane[R]. AIAA 2013-1166.
[13] 蒋德明. 内燃机燃烧排放学[M]. 西安:西安交通大学出版社, 2011.
[14] Bradley D, Gaskell P H, Gu X J. Burning Velocities, Markstein Lengths, and Flame Quenching for Spherical Methane-Air Flames: A Computational Study[J]. Combustion and Flame, 1996, 104(1/2): 176-198.
[15] Metghalchi M, Keck J C. Burning Velocities of Mixtures of Air with Methanol, Isooctane,and Indolent at High Pressures and Temperatures [J]. Combustion and Flame, 1982, 48: 191-210.
[16] Law C K. Combustion Physics[M]. UK: Cambridge Press, 2006.
[17] Stephen R Turns. An Introduction to Combustion Concepts and Applications[M]. Beijing: Tsinghua University Press, 2008.　　　　　　　　　　　　　*　收稿日期:2015-05-21；修订日期:2014-06-12。作者简介:徐庆尧(1984－), 男,博士,研究领域为先进燃烧理论与燃烧技术；E-mail:yangxqy@163.com(编辑:梅瑛)