活塞式合成射流激励器效率分析与改进研究

推进技术 ›› 2015, Vol. 36 ›› Issue (11): 1648-1655.

活塞式合成射流激励器效率分析与改进研究

额日其太,张亮

北京航空航天大学能源与动力工程学院，北京 100191,北京航空航天大学能源与动力工程学院，北京 100191

发布日期:2021-08-15
作者简介:额日其太(1970—)，男，博士，副研究员，研究领域为红外隐身与排气系统。

A Study of Efficiency Improvement of Piston/Cylinder

School of Energy and Power Engineering，Beihang University，Beijing 100191，China and School of Energy and Power Engineering，Beihang University，Beijing 100191，China

Published:2021-08-15

摘要/Abstract

摘要： 为了研究活塞式合成射流激励器的效率，对所设计的一种活塞式合成射流激励器进行了轴对称非定常数值计算。研究发现，活塞式合成射流激励器的效率在44.9%~67.7%之间，其电能利用率高达21.6%~32.5%，高于电火花式合成射流激励器的电能利用率。研究表明，合成射流孔直径越小或者激励器频率越大，激励器效率越高；而压缩比较大时，压缩比对激励器效率的影响不大。另外，采用辅助进气结构，不仅能减小活塞做功，还能增大射流动能，使激励器的效率由59.59%提高到112.93%。

关键词: 活塞式；合成射流；数值模拟；效率；辅助进气系统

Abstract: In order to study the efficiency of the piston/cylinder synthetic jet actuator，axisymmetric unsteady simulations were done. The results show that efficiency of the piston/cylinder synthetic jet actuator ranges from 44.9% to 67.7%，and their efficiency of electric energy ranges from 21.6% to 32.5%，which is higher than that of plasma synthetic jet actuator. With the decrease of outlet diameter or increase of frequency，the efficiency increases. However，high compression ratio has little effect on the efficiency. An auxiliary air system was adopted to improve the efficiency. With the auxiliary air system，piston work decreases，and synthetic jet kinetic energy increases，and the efficiency improves from 59.59% to 112.93%.

Key words: Piston/cylinder；Synthetic jet；Numerical simulation；Efficiency；Auxiliary air system

额日其太,张亮. 活塞式合成射流激励器效率分析与改进研究[J]. 推进技术, 2015, 36(11): 1648-1655.

ERIQITAI,ZHANG Liang. A Study of Efficiency Improvement of Piston/Cylinder[J]. Journal of Propulsion Technology, 2015, 36(11): 1648-1655.

参考文献

[1] 张攀峰, 王晋军, 冯立好.零质量射流技术及其应用研究进展[J]. 中国科学:技术科学, 2008, 38(3): 321-349.
[2] Luo Z B, Xia z X, Liu B. New Generation of Synthetic Jet Actuators[J]. AIAA Journal, 2006, 44(10).
[3] 谭晓茗, 张靖周. 自耦合射流流动特性和相关参数影响规律的数值研究[J]. 航空动力学报, 2005, 20(5):836-840.
[4] 刘艳明, 伍耐明, 董金钟, 等. 合成射流作用机理及其对共轴射流掺混的影响[J]. 北京航空航天大学学报, 2007, 33(1):5-9.
[5] Cybyk B Z, Wilkerson J T, Grossman K R, et al. Computational Assessment of the Spark Jet Flow Control Actuator[R]. AIAA 2003—3711.
[6] Cybyk B Z, Wilkerson J T, Grossman K R. Performance Characterization of Spark Jet Flow Control Actuators[R]. AIAA 2004-2131.
[7] Grossman K IL, Cybyk B z, Rigling M C, et al. Characterization of Spark Jet Actuators for Flow Control[R]. AIAA 2004-0089.
[8] 王林, 罗振兵, 夏智勋, 等. 等离子体合成射流能量效率及工作特性研究[J]. 物理学报, 2013, 62(12).
[9] Crittenden T M, Glezer A. A High-Speed, Compressible Synthetic Jet[J]. Phys. Fluids, 2006, 18(1).
[10] 曹永飞, 李斌斌, 顾蕴松. 活塞式合成射流激励器工作特性研究[C]. 哈尔滨:中国力学大会2011暨钱学森诞辰100周年纪念大会, 2011.
[11] 刘艳明, 王保国, 刘淑艳. 大功率合成射流激励器设计及其流场特性研究[J]. 推进技术, 2008, 29(5):552-556. (LIU Yan-ming, WANG Bao-guo, LIU Shu-yan. Design of High—Power Synthetic Jet Actuator and its Flow Field Investigation[J]. Journal of Propulsion Technology, 2008, 29(5): 552-556.)
[12] 温文才, 额日其太. 高动量合成射流激励器流场的数值模拟研究[C]. 南京: 中国航空学会, 2006.
[13] 徐惊雷, 沙江, 林春峰, 等. 不同狭缝厚度的零质量射流PIV实验研究[J]. 推进技术, 2007, 28(2):162-166. (XU Jing-lei, SHA Jiang, LIN Chun-feng, et al. Experimental Study on Orifice Depths Effect for Synthetic Jet with Particle Image Velocimetry [J]. Journal of Propulsion Technology, 2007, 28(2): 162-166.)
[14] 刘贺, 董金钟, 伍耐明, 等. 大功率狭缝式活塞激励器流场测量与分析[J]. 北京航空航天大学学报,2012, 38(2).
[15] Gao S, Zhang J Z, Tan X M. Experimental Study on Heat Transfer Characteristics of Synthetic Jet Driven by Piston Actuator[J]. Science China Technological Sciences, 2012, 55: 1732–1738.
[16] Tan Xiao-Ming, Zhang Jing-Zhou. Flow and Heat Transfer Characteristics Under Synthetic Jets Impingement Driven by Piezoelectric Actuator[J]. Experimental Thermal and Fluid Science, 2013, 48: 134–146.
[17] Zhang Jing-zhou, Gao Shan, Tan Xiao-ming. Convective Heat Transfer on a Flat Plate Subjected to Normally Synthetic Jet and Horizontally Forced Flow[J]. International Journal of Heat and Mass Transfer, 2013, 57: 321–330.
[18] 高珊, 张靖周, 谭晓茗. 活塞驱动合成喷流动和传热特性研究[J]. 推进技术, 2012, 33(3): 463-467. (GAO Shan, ZHANG Jing-zhou, TAN Xiao-ming. Flow and Heat Transfer Characteristics of Synthetic Jet Driven by Piston Actuator[J]. Journal of Propulsion Technology, 2012, 33(3): 463-467.)(编辑:梅瑛)　　　　　　　　　　　　　*　收稿日期:2014-08-14；修订日期:2014-10-22。作者简介:额日其太(1970—),男,博士,副研究员,研究领域为红外隐身与排气系统。E-mail: