普通室内机翼尾缘噪声降噪的实验研究

推进技术 ›› 2015, Vol. 36 ›› Issue (5): 703-712.

普通室内机翼尾缘噪声降噪的实验研究

纪　良¹,乔渭阳¹,王良峰¹,英基勇²

西北工业大学动力与能源学院，陕西西安 710072,西北工业大学动力与能源学院，陕西西安 710072,西北工业大学动力与能源学院，陕西西安 710072,中航商用航空发动机有限责任公司，上海 201108

发布日期:2021-08-15
作者简介:纪　良(1985—)，男，博士生，研究领域为叶轮机械气动声学。
基金资助:
国家自然科学基金(51276149)；空气动力学国家重点实验室研究基金(20130201)。

Experimental Investigation of Airfoil Trailing-Edge Noise Reduction in a Normal Indoor Test Bed

School of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China,School of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China,School of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China and AVIC Commercial Aircraft Engine Co.，LTD.，Shanghai 201108，China

Published:2021-08-15

摘要/Abstract

摘要： 为了研究锯齿形尾缘对SD2030低雷诺数翼型尾缘噪声的影响，在普通室内，采用由31路麦克风组成的线性阵列对SD2030吹风试验进行了声学测量。实验过程中，基于机翼弦长的雷诺数范围为2.1×105 ～ 3.2×105。在考虑混响、驻波和壁面反射影响的基础上，设计了一长为1.72m的非等间距线性阵列。当频率大于1kHz时，墙壁反射对测量结果的影响在0.5dB以内，驻波的影响也可以忽略。采用时域波束成形算法对声学信号进行处理之后，成功识别出了风洞噪声源、机翼前缘噪声源和尾缘噪声源。比较直尾缘机翼和锯齿形尾缘机翼的声源分布图发现，在1k～10kHz的频率范围内，采用锯齿形尾缘设计能够降低尾缘噪声声压级最大约5dB。

关键词: 麦克风阵列；机翼；尾缘噪声；混响；锯齿

Abstract: A phased array with 31 microphones is used to investigate the noise reduction effects of serrated trailing edge (TE) on SD2030 low Reynolds number airfoils in a normal indoor test bed. During the acoustic measurement，the Reynolds number based on airfoil chord ranges from 2.1×105 to 3.2×105. After combining array design with the indoor acoustic environments such as reverberation，standing waves and reflection waves from hard walls，an unequal spacing linear microphone array with length of 1.72m is built. The hard wall reflection effects on test signals are less than 0.5dB in frequency range above 1kHz and the influences of standing waves can be neglected，too. Conventional beam-forming in time domain is applied to process the microphone signals，as a result，noise sources including wind tunnel noise source，airfoil leading-edge and trailing-edge noise source have been identified successfully. According to comparison between the noise source distribution maps of straight trailing-edge case and serrated trailing-edge case，the sound pressure level of trailing-edge noise can be approximately reduced by 5 dB at most in frequency ranges from 1kHz to 10kHz.

Key words: Microphone array；Airfoil；Trailing-edge noise；Reverberation；Serrations

纪　良,乔渭阳,王良峰,英基勇. 普通室内机翼尾缘噪声降噪的实验研究[J]. 推进技术, 2015, 36(5): 703-712.

JI Liang¹,QIAO Wei-yang¹,WANG Liang-feng¹,YING Ji-yong². Experimental Investigation of Airfoil Trailing-Edge Noise Reduction in a Normal Indoor Test Bed[J]. Journal of Propulsion Technology, 2015, 36(5): 703-712.

参考文献

[1] Brooks T, Pope D, Marcolini M. Air Self-Noise and Prediction[R]. NASA RP 1218, 1989.
[2] Powell A. Aerodynamic Noise and the Plane Boundary. [J]. Journal of the Acoustical Society of America, 1960, 32:982-990.
[3] Ffowcs Williams J, Hall L. Aerodynamic Sound Generation by Turbulent Flow in the Vicinity of a Scattering Half Plane[J]. Journal of Fluid Mech,1970, 40(4):657-670.
[4] Graham R R. The Silent Flight of Owls[J]. Journal of Royal Aeronautical Society, 1934, 286:837-843.
[5] Lilley G M. A Study of the Silent Flight of the Owl[R]. AIAA 98-2340.
[6] Howe M. S. Aerodynamic Noise of a Serrated Trailing edge[J]. Journal of Fluid and Structures, 1991, 5(1):33-45.
[7] Howe M S. Noise Produced by a Sawtooth Trailing Edge[J]. Journal of the Acoustical Society of America, 1991, 90(1):482-487.
[8] Oerlemans S, Fisher M, Maeder T. Reduction of Wind Turbine Noise Using Optimized Airfoils and Trailing-Edge Serrations[R]. AIAA 2008-2019.
[9] Gruber M, Joseph P F, Chong T P. Experimental Investigation of Airfoil Self Noise and Turbulent Wake Reduction by the Use of Trailing Edge Serrations[R].AIAA 2010-3803.
[10] Gruber M, Azarpeyvand M, Joseph P. Airfoil Trailing edge Noise Reduction by the Introduction of Sawtooth and Slitted Tailing Edge Geometries[C].Sydney: Proceedings of 20th International Congress on Acoustics, 2010.
[11] Gruber M, Phillip F, Joseph P. On the Mechanisms of Serrated Airfoil Trailing Edge Noise Reduction[R]. AIAA 2011-2781.
[12] Jones L, Sandberg R. Numerical Investigation of Airfoil Self-Noise Reduction by Addition of Trailing-Edge Serrations[R]. AIAA 2010-3703.
[13] Danielle J Moreau, Laura A Brooks, Con J Doolan. On the Noise Reduction Mechanisms of a Flat Plate Serrated Trailing Edge at Low-to-Moderate Reynolds Number[R]. AIAA 2012-2186.
[14] Michel U. History of Acoustic Beamforming[R]. BeBeC 2006-01.
[15] Michel U, Bariskow B, Helbig J. et al. Fly-Over Noise Measurements on Landing Aircraft with a Microphone Array[R]. AIAA 98-2336.
[16] 乔渭阳. 二维传声器阵列测量技术及其对飞机进场着陆过程噪声的实验研究[J]. 声学学报, 2001, 26(2):161-168.
[17] Siller H A, Arnold F, Michel U. Investigation of Aero-Engine Using a Phased Microphone Array[R]. AIAA 2001-2269.
[18] San Soo Lee. Phased-Array Measurement of Modern Regional Aircraft Turbofan Engine Noise[R]. AIAA 2006-2653.
[19] Hiroki URA, Yuzuru Yokokawa, Takeshi ITO. Experimental Study of Trailing Edge Noise in Low-Speed Wind Tunnel[R]. AIAA 2007-1038.
[20] Lars Koop and Klaus Ehrenfried. Microphone-Array Processing for Wind Tunnel Measurements with Strong Background Noise[R]. AIAA 2008-2907.
[21] 乔渭阳, Michel U. 基于传声器阵列过顶测量结果的飞机起落架噪声研究[J]. 应用声学, 2001, 20(2):1-6.
[22] Thomas F Brooks, William M Humphreys. A Deconvolution Approach for the Mapping of Acoustic Sources(DAMAS) Determined from Phased Microphone Arrays[J]. Journal of Sound and Vibration, 2006, 294:856-879.
[23] Mueller T J. Aeroacoustic Measurements[M]. Berlin: Springer-Verlag, 2002.
[24] P B?hning, H Siller, K Holland, et al. Novel Methods for Acoustic Indoor Measurements and Applications in Aero-Engine Test Cells[R]. BeBeC 2006-04.
[25] Terrill W Putnam. Review of Aircraft Noise Propagation[R]. NASA TM X-56033, 1975.
[26] H A Siller, S Guerin, U Michel. Localisation and Analysis of Sound Sources on Aircraft in Flight[C]. Berlin:13th CEAS-ASC Workshop & 4th Scientific Workshop of X3-Noise, (DLR) , 2009.(编辑:朱立影)　　　　　　　　　　　　　*　收稿日期:2014-03-25；修订日期:2014-07-06。基金项目:国家自然科学基金(51276149)；空气动力学国家重点实验室研究基金(20130201)。作者简介:纪良(1985—),男,博士生,研究领域为叶轮机械气动声学。E-mail:cainiaojl@sina.com