跨声速压气机转子近失速工况非定常流动及相关机理研究

推进技术 ›› 2016, Vol. 37 ›› Issue (10): 1847-1854.

跨声速压气机转子近失速工况非定常流动及相关机理研究

吴艳辉,安光耀,陈智洋,丁永鹏,刘军,彭文辉

西北工业大学动力与能源学院，陕西西安 710072,西北工业大学动力与能源学院，陕西西安 710072,西北工业大学动力与能源学院，陕西西安 710072,西北工业大学动力与能源学院，陕西西安 710072,西北工业大学动力与能源学院，陕西西安 710072,西北工业大学动力与能源学院，陕西西安 710072

发布日期:2021-08-15
作者简介:吴艳辉，女，博士，教授，研究领域为热机气动热力学。
基金资助:
国家自然科学基金(51276148；51075133)；航空科学基金(2012ZB53017)。

Numerical Investigation into Unsteady Flow and ItsAssociated Flow Mechanism in a Transonic CompressorRotor at Near Stall Conditions

College of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China,College of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China,College of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China,College of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China,College of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China and College of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China

Published:2021-08-15

摘要/Abstract

摘要： 为了探究近失速工况下，跨声速压气机转子中非定常流动及相关流动机制，采用多通道全三维数值模拟方法对跨声速转子其内部流场进行了数值模拟，并利用已有的实验数据对计算结果进行了校核。对近失速工况探针监测结果的分析表明:流场中出现了非定常扰动，且扰动最活跃的区域位于近叶尖通道靠近叶片前缘的压力面侧；随着流量的降低，非定常扰动的幅值增大，波动周期变长。对近叶尖瞬态流场的分析表明:流场中的一个不同于泄漏涡的涡结构(命名为叶尖二次涡)的出现及其沿流向的发展诱发了非定常静压扰动，而且其强度随着流量的降低而增强，由此导致了非定常扰动的周期变长，振幅增加。伴随着叶尖二次涡强度的增加，叶顶通道的阻塞以及由叶尖二次涡诱发的“前缘溢流”也随之增强。因此，叶尖二次涡的出现及其强度的变化是影响该跨声速转子流动稳定性的主要因素之一。

关键词: 数值模拟；非定常扰动；泄漏涡；叶尖二次涡

Abstract: Three-dimensional multi-passage numerical simulations were conducted to investigate the unsteady flow and its associated flow mechanism in a transonic compressor rotor at near stall conditions. The predicted results were compared with the available experimental data and a good agreement was achieved. The numerical monitoring results indicate that pressure disturbance appear at near stall flow conditions，which originate in the near-tip passages with higher amplitudes near the blade leading edge of the pressure side of the passage. With mass flow decreased，the amplitude of the disturbance and its active period increase. Further analyses of instantaneous flow fields show that a vortex structure，termed as tip secondary vortex，and its periodic oscillation lead to the appearance of the pressure disturbance. With mass flow decreased，the strength of TSV increases，thus leading to an increase in the disturbance's amplitude and its active period. Meanwhile，the near-tip flow blockage and "tip spillage flow" induced by TSV increase. As a result，the occurrence of TSV and the variation of its strength is a key factor which sets the stability limit of the investigated rotor.

Key words: Numerical simulation；Unsteady disturbance；Tip leakage vortex；Tip secondary vortex

吴艳辉,安光耀,陈智洋,丁永鹏,刘军,彭文辉. 跨声速压气机转子近失速工况非定常流动及相关机理研究[J]. 推进技术, 2016, 37(10): 1847-1854.

WU Yan-hui,AN Guang-yao,CHEN Zhi-yang,DING Yong-peng,LIU Jun,PENG Wen-hui. Numerical Investigation into Unsteady Flow and ItsAssociated Flow Mechanism in a Transonic CompressorRotor at Near Stall Conditions[J]. Journal of Propulsion Technology, 2016, 37(10): 1847-1854.

参考文献

[1] Furukawa,M, Inoue, M, Saiki, K, et al. The Role of Tip Leakage Vortex Breakdown in Compressor Rotor Aerodynamics[J]. ASME Journal of Turbomachinery, 1999, 121(3): 469-480.
[2] Furukawa M, Saiki K, Yamada K, et al. Unsteady Flow Behavior Due to Breakdown of Tip Leakage Vortex in an Axial Compressor Rotor at Near-Stall Condition[R]. ASME 2000-GT-666.
[3] Vo H D, Tan C S, Greitzer E M. Criteria for Spike Initiated Rotating Stall[J]. ASME Journal of Turbomachinery, 2008, 130(1).
[4] Bergner J, Kinzel M, Schiffer H, et al. Short Length-Scale Rotating Stall Inception in a Transonic Axial Compressor Experimental Investigation[R]. ASME 2006-GT-90209.
[5] Hah C, Bergner J, Schiffer H. Short Length-Scale Rotating Stall Inception in a Transonic Axial Compressor-Criteria and Mechanisms[R]. ASME 2006-GT-90045.
[6] 张卓勋, 吴艳辉, 楚武利, 等. 激波/泄漏涡相互干扰对跨声压气机流动稳定性的影响[J]. 航空动力学报, 2010 (7): 1615-1621.
[7] Yanhui Wu, Qingpeng Li, Jiangtao Tian. Investigation of Pre-Stall Behavior in an Axial Compressor Rotor, Part 1: Unsteadinss of Tip Clearance Flow[J]. ASME Journal of Turbomachinery, 2012, 34: 1-12.
[8] 吴艳辉, 李清鹏, 田江涛, 等. 轴流压气机转子叶尖二次涡的实验验证及形成机理[J]. 推进技术, 2012, 33(3):363-370. (WU Yan-hui, LI Qing-peng, TIAN Jiang-tao, et al. Experimental Validation and Formation Mechanism Analysis of Tip Secondary Vortex in a Compressor Rotor [J]. Journal of Propulsion Technology, 2012, 33(3): 363-370.)
[9] Yanhui Wu, Qingpeng Li, Jiangtao Tian. Investigation of Pre-Stall Behavior in an Axial Compressor Rotor- Part 2: Flow Mechanism of Spike Emergence[J]. ASME Journal of Turbomachinery, 2012, 34: 1-10.
[10] Reid L, Moore R D. Design and Overall Performance of Four Highly-Loaded, High Speed Inlet Stages for an Advanced, High Pressure Ratio Core Compressor[R]. NASA TP-1337, 1978.
[11] Reid L, Moore R D. Performance of a Single-Stage Axial-Flow Transonic Compressor with Rotor and Stator Aspect Ratios of 1.19 and 1.26, Respectively, and with Design Pressure Ratio of 1.82[R]. NASA TP 1338, 1978.
[12] Strazisar A J, Zante D V, Wood J R, et al. Recommendations for Achieving Accurate Numerical Simulation of Tip Clearance Flows in Transomic Compressor Rotor[R]. NASA TM 2000-210347.
[13] Suder K L, Hathaway M D, Thorp S A, et al. Compressor Stability Enhancement Using Discrete Tip Injection[J]. ASME Journal of Turbomachinery, 2001, 123: 14-23.
[14] Strazisar A J, Bright M M, Throp S, et al. Compressor Stall Control Through Endwall Recirculation[R]. ASME GT 2004-54295.
[15] Yamada K, Furukawa M, Nakano K. Unsteady Three-Dimensional Flow Phenomena Due to Breakdown of Tip Leakage Vortex in a Transonic Axial Compressor Rotor[R]. ASME 2004-GT-53745.
[16] Yamada K, Funazaki K, Furukawa M. The Behavior of Tip Clearance Flow at Near-Stall Condition in a Transonic Axial Compressor Rotor[R]. ASME GT 2007-27725.　　　　　　　　　　　　　*　收稿日期:2015-06-25；修订日期:2015-08-14。基金项目:国家自然科学基金(51276148；51075133)；航空科学基金(2012ZB53017)。作者简介:吴艳辉,女,博士,教授,研究领域为热机气动热力学。E-mail: wyh@nwpu.edu.cn(编辑:张荣莉)