跨声压气机近失速流动特征的数值模拟研究

推进技术 ›› 2016, Vol. 37 ›› Issue (6): 1055-1064.

跨声压气机近失速流动特征的数值模拟研究

鞠鹏飞¹,宁方飞^1,2

北京航空航天大学能源与动力工程学院航空发动机气动热力国家级重点实验室，北京 100191,北京航空航天大学能源与动力工程学院航空发动机气动热力国家级重点实验室，北京 100191; 先进航空发动机协同创新中心，北京 100191

发布日期:2021-08-15
作者简介:鞠鹏飞，男，博士生，研究领域为叶轮机气动力学。

Numerical Study of Near-Stall Flow Feature on

National Key Laboratory of Science and Technology on Aero-Engines Aero-Thermodynamics，School of Energy and Power Engineering，Beihang University，Beijing 100191，China and National Key Laboratory of Science and Technology on Aero-Engines Aero-Thermodynamics，School of Energy and Power Engineering，Beihang University，Beijing 100191，China; Collaborative Innovation Center of Advanced Aero-Engine，Beijing 100191，China

Published:2021-08-15

摘要/Abstract

摘要： 为了研究跨声轴流压气机突尖型失速先兆的表现形式与演化规律，探索较为可行的先兆探测方法，对NASA Rotor 37转子近失速工况下的流场进行了三维全环非定常的数值模拟。数值模拟结果表明，在失速团产生之前的约2转时间内，存在一个失速扰动相对缓慢增长的阶段。更早时刻发生的流量持续下降是导致失速团最终形成前缘溢流出现的原因。使用不同的方法对前缘附近机匣处的静压数值探针信号进行处理，探索了各种方法的优缺点，并且发展了一种互相关分析方法，能够取得较好的扰动识别效果。

关键词: 轴流压气机；突尖型失速；数值模拟；失速先兆；相关性系数

Abstract: Three-Dimensional full-annulus time-accurate numerical simulation of the NASA Rotor 37 flow at near-stall condition has been carried out for the purpose of exploring the evolution pattern and feasible detection method of spike-like rotating stall inception in the transonic axial flow compressor. Simulation results show that there is a stage when stalling perturbations grow slowly in approximately 2 revolutions before the first stall cell appears. The leading edge spillage，which eventually leads to the formation of stall cells，is actually the result of continuously decreased mass flow rate which appears at earlier moments. Static pressure signals from numerical probes located on the casing just upstream of the blade leading edge were processed and carefully studied by various methods. It is shown that a new cross-correlation method developed by the author shows better capability in the identification of pre-stall perturbations among the studied methods.

Key words: Axial flow compressor；Spike stall；Numerical simulation；Stall inception；Correlation coefficient

鞠鹏飞,宁方飞. 跨声压气机近失速流动特征的数值模拟研究[J]. 推进技术, 2016, 37(6): 1055-1064.

JU Peng-fei¹,NING Fang-fei^1,2. Numerical Study of Near-Stall Flow Feature on[J]. Journal of Propulsion Technology, 2016, 37(6): 1055-1064.

参考文献

[1] Day I J. Stall Inception in Axial Flow Compressors[J]. Journal of Turbomachinery, 1993, 115(1): 1-9.
[2] Day I J, Freeman C. The Unstable Behavior of Low and High-Speed Compressors[J]. Journal of Turbomachinery, 1994, 116(2): 194-201.
[3] Camp T R, Day I J. A Study of Spike and Modal Stall Phenomena in a Low-Speed Axial Compressor[J]. Journal of Turbomachinery, 1998, 120(3): 393-401.
[4] Hoying D A, Tan C S, Duc Vo H, et al. Role of Blade Passage Flow Structures in Axial Compressor Rotating Stall Inception[J]. Journal of Turbomachinery, 1999, 121(4): 735-742.
[5] Duc Vo H, Tan C S, Greitzer E M. Criteria for Spike Initiated Rotating Stall[J]. Journal of Turbomachinery, 2008, 130(1).
[6] Inoue M, Kuroumaru M, Tanino T, et al. Propagation of Multiple Short-Length-Scale Stall Cells in an Axial Compressor Rotor[J]. Journal of Turbomachinery, 2000, 122(1): 45-54.
[7] Inoue M, Kuroumaru M, Tanino T, et al. Comparative Studies on Short and Long Length-Scale Stall Cell Propagating in an Axial Compressor Rotor[J]. Journal of Turbomachinery, 2001, 123(1): 24-30.
[8] Pullan G, Young A M, Day I J, et al. Origins and Structure of Spike-Type Rotating Stall[J]. Journal of Turbomachinery, 2015, 137(5).
[9] Garnier V H, Epstein A H, Greitzer E M. Rotating Waves as a Stall Inception Indication in Axial Compressors[J]. Journal of Turbomachinery, 1991, 113(2): 290-301.
[10] Tryfonidis M, Hendricks G J, Etchevers O, et al. Prestall Behavior of Several High-Speed Compressors[J]. Journal of Turbomachinery, 1995, 117(1): 62-80.
[11] Lin F, Chen J, Li M. Wavelet Analysis of Rotor-Tip Disturbances in an Axial-Flow Compressor[J]. Journal of Propulsion and Power, 2004, 20(2): 319-334.
[12] Wadia A R, Christensen D, Prasad J. Compressor Stability Management in Aircraft Engines[C]. Hamburg: Proceedings of the 25th Congress of the International Council of the Aeronautical Sciences, 2006.
[13] Tahara N, Kurosaki M, Ohta Y, et al. Early Stall Warning Technique for Axial-Flow Compressors[J]. Journal of Turbomachinery, 2007, 129(3): 448-456.
[14] Park H G. Unsteady Disturbance Structures in Axial Flow Compressor Stall Inception[D]. Cambridge: Massachusetts Institute of Technology, 1994.
[15] Cameron J D, Morris S C. Analysis of Axial Compressor Stall Inception Using Unsteady Casing Pressure Measurements[J]. Journal of Turbomachinery, 2013, 135(2): 21036.
[16] Dunham J. CFD Validation for Propulsion System Components[R]. AGARD-AR-335, 1998.
[17] 宁方飞, 徐力平. 叶根间隙泄漏流对跨声压气机转子性能的影响[J]. 推进技术, 2004, 25(4): 325-328. (NING Fang-fei, XU Li-ping. Numerical Investigation of the Efect of Hub Leakage Flow on Transonic Compressor Rotor[J]. Journal of Propulsion Technology, 2004, 25(4): 325-328.)
[18] 杜鹏程, 宁方飞. 跨声风扇周向畸变流动的谐波平衡法计算[J]. 推进技术, 2012, 33(3): 391-397. (DU Peng-cheng, NING Fang-fei. Numerical Simulation of Transonic Fan Under Circumferential Inlet Distortion Using Harmonic Balance Method[J]. Journal of Propulsion Technology, 2012, 33(3): 391-397.)
[19] 宁方飞. 考虑真实几何复杂性的跨音压气机内部流动的数值模拟[D]. 北京: 北京航空航天大学, 2002.
[20] Ning F. MAP: A CFD Package for Turbomachinery Flow Simulation and Aerodynamic Design Optimization[R]. ASME GT 2014-26515.
[21] 鞠鹏飞, 宁方飞. GPU 平台上的叶轮机械 CFD 加速计算[J]. 航空动力学报. 2014, 29(5): 1154-1162.
[22] Weigl H J, Paduano J D, Frechette L G, et al. Active Stabilization of Rotating Stall and Surge in a Transonic Single-Stage Axial Compressor[J]. Journal of Turbomachinery, 1998, 120(4): 625-636. 　　　　　　　　　　　　　*　收稿日期:2015-01-28；修订日期:2015-03-05。作者简介:鞠鹏飞,男,博士生,研究领域为叶轮机气动力学。E-mail: juzhang.com@buaa.edu.cn(编辑:朱立影)