低速轴流涡轮转静子干涉的非定常数值模拟

推进技术 ›› 2016, Vol. 37 ›› Issue (7): 1233-1240.

低速轴流涡轮转静子干涉的非定常数值模拟

王晓东,梁丽萍,康顺,张辉

华北电力大学能源动力与机械工程学院，北京 102206,华北电力大学能源动力与机械工程学院，北京 102206,华北电力大学能源动力与机械工程学院，北京 102206,华北电力大学能源动力与机械工程学院，北京 102206

发布日期:2021-08-15
作者简介:王晓东，男，博士，副教授，研究领域为叶轮机械气体气动力，CFD数值算法。
基金资助:
国家自然科学基金(51206052)；中央在京高校重大成果转化项目(ZDZH20141005401)；

Unsteady Numerical Simulations on Stator-Rotor Interaction within a Low Speed Axial Turbine

Department of Energy，Power and Mechanical Engineering，North China Electric Power University， Beijing 102206，China,Department of Energy，Power and Mechanical Engineering，North China Electric Power University， Beijing 102206，China,Department of Energy，Power and Mechanical Engineering，North China Electric Power University， Beijing 102206，China and Department of Energy，Power and Mechanical Engineering，North China Electric Power University， Beijing 102206，China

Published:2021-08-15

摘要/Abstract

摘要： 低速涡轮内部流动在低雷诺数进口条件下可能涉及流态转变，增加了流动的复杂性。为了分析低速涡轮在低雷诺数下的三维流动结构，对低速轴流涡轮内部流场进行了数值模拟，获得了叶片通道中的三维流场结构。在与实验结果进行对比确认的基础上，详细分析了由转静干涉效应引起的非定常流动现象及其对涡轮气动性能的影响。结果表明，低雷诺数状态下，转静干涉效应对低速轴流涡轮静叶通道内流动状况的影响小于对动叶通道内流动的影响；动叶表面的分离流区位置位于叶中和叶顶之间，使得顶部通道涡沿周向拉伸。这种拉伸运动使得气流参数在叶顶附近的周期性变化幅度大于叶根附近的变化幅度。

关键词: 转静干涉；非线性谐波方法；低速轴流涡轮；不可压缩流

Abstract: The internal flow structure within a low speed axial turbine is complex due to the underlying flow transition which may exist under low inlet Reynolds number. In order to analyze the three-dimensional flow structure under such condition，numerical simulations were performed on a low speed axial turbine. The three-dimensional structure of the flow field within the cascade passage was obtained. Comparing with the experimental results，the unsteady flow structure arising from the stator-rotor interaction and its influence on the aerodynamic performance of the turbine are analyzed in detail. Results show that the effects of the stator-rotor interaction on the stator flow are smaller than those on the rotor flow. The separated flow on rotor blade suction surface is located between midspan and tip. The tip passage vortex stretched in circumference under the press of separated flow. Thus，the periodic variations of the flow variables close to tip are larger than that close to hub.

Key words: Stator-rotor interaction；Non-linear harmonic method；Low speed axial turbine；Incompressible flow

王晓东,梁丽萍,康顺,张辉. 低速轴流涡轮转静子干涉的非定常数值模拟[J]. 推进技术, 2016, 37(7): 1233-1240.

WANG Xiao-dong,LIANG Li-ping,KANG Shun,ZHANG Hui. Unsteady Numerical Simulations on Stator-Rotor Interaction within a Low Speed Axial Turbine[J]. Journal of Propulsion Technology, 2016, 37(7): 1233-1240.

参考文献

[1] 孙爽, 雷志军, 朱俊强, 等. 粗糙度对超高负荷低压涡轮边界层影响[J]. 推进技术, 2014, 35(3): 356-364. (SUN Shuang, LEI Zhi-jun, ZHU Jun-qiang, et al. Effects of Roughness on Boundary Layer of Ultra-High-Lift Low-Pressure Turbine[J]. Journal of Propulsion Technology, 2014, 35(3): 356-364.)
[2] Schobeiri M T, ?ztürk B, David E. Effect of Reynolds Number and Periodic Unsteady Wake Flow Condition on Boundary Layer Development, Separation, and Intermittency Behavior along the Suction Surface of a Low Pressure Turbine Blade[J]. ASME Journal of Turbomachinery, 2007, 129(1): 92-107.
[3] Mahallati A, Steen A S. Aerodynamics of a Low-Pressure Turbine Airfoil at Low Reynolds Numbers, Part Ⅱ: Blade-Wake Interaction[J]. ASME Journal of Turbomachinery, 2012, 135(1): 011011-10.
[4] Felix F, David S W, Grant I. Reconstruction of the Unsteady Pressure Field in a Low Speed Linear Cascade[R]. ASME GT-2012-69156.
[5] Maclsaac G D, Sjolander S A, Praisner T J. Measurements of Losses and Reynolds Stresses in the Secondary Flow Downstream of a Low-Speed Linear Turbine Cascade[J]. ASME Journal of Turbomachinery, 2012, 134(6): 061015-061015-12.
[6] Reinaldo A, Gomes S S, Franz B, et al. Hot-Film Measurements on a Low Pressure Turbine Linear Cascade with Bypass Transition[J]. ASME Journal of Turbomachinery, 2015, 137(9): 091007-11.
[7] Matsunuma T. Unsteady Flow Field of an Axial-Flow Turbine Rotor at a Low Reynolds Number[J]. ASME Journal of Turbomachinery, 2007, 129(2): 360-371.
[8] Martin G R, Philipp J, Jochen G, et al. Experimentally Observed Unsteady Work at Inlet to and Exit from an Axial Flow Turbine Rotor[J]. ASME Journal of Turbomachinery, 2013, 135(6): 061017-061017-8.
[9] Martin L, Jan H, Martin G. R, et al. Blade-Row Interactions in a Low Pressure Turbine at Design and Strong Off-Design Operation[J]. ASME Journal of Turbomachinery, 2014, 136(11): 111002-10.
[10] 杨彤, 王松涛. 轴向间距变化对低压涡轮定常与非定常气动性能影响的数值研究[J]. 推进技术, 2014, 35(8):1048-1055. (YANG Tong, WANG Song-tao. Numerical Study for Effects of Axial Clearance on Low-Pressure Turbine Steady and Unsteady Aerodynamic Performance[J]. Journal of Propulsion Technology, 2014, 35(8): 1048-1055.)
[11] He L, Chen T, Wells R G, et al. Analysis of Rotor-Rotor and Stator-Stator Interferences in Multi-Stage Turbo Machines[C]. USA: ASME Turbo Expo 2002: Power for Land, Sea, and Air, 2002: 287-298.
[12] Vilmin S, Lorrain E, Hirsch C, et al. Unsteady Flow Modeling across the Rotor/Stator Interface Using the Nonlinear Harmonic Method[C]. USA: ASME Turbo Expo 2006: Power for Land, Sea, and Air, 2006: 1227-1237.
[13] 王晓东, 康顺. 低速轴流涡轮非定常数值模拟的非线性谐波法[J]. 工程热物理学报, 2009, 30(6): 949-952.
[14] 宁方飞, 徐力平. Spalart-Allmaras湍流模型在内流流场数值模拟中的应用[J]. 工程热物理学报, 2001, 22(5): 304-306.
[15] 王晓东. 透平机械内部复杂流动的数值模拟与叶片设计的鲁棒优化[D]. 北京: 华北电力大学, 2010.(编辑:梅瑛)　　　　　　　　　　　　　*　收稿日期:2015-01-04；修订日期:2015-04-27。基金项目:国家自然科学基金(51206052)；中央在京高校重大成果转化项目(ZDZH20141005401)；中央高校基本科研业务费专项资金(2014ZZD04)。作者简介:王晓东,男,博士,副教授,研究领域为叶轮机械气体气动力,CFD数值算法。E-mail: wangxd@ncepu.edu.cn