潜入式喷管对固体火箭发动机工作稳定性影响

推进技术 ›› 2016, Vol. 37 ›› Issue (8): 1529-1534.

潜入式喷管对固体火箭发动机工作稳定性影响

苏万兴,李要建,陈升泽,李吉

中国运载火箭技术研究院，研究发展中心，北京 100076,中国运载火箭技术研究院，研究发展中心，北京 100076,中国运载火箭技术研究院，研究发展中心，北京 100076,中国运载火箭技术研究院，研究发展中心，北京 100076

发布日期:2021-08-15
作者简介:苏万兴，男，博士，工程师，研究领域为固体火箭发动机不稳定燃烧。

Effects of Submerged Nozzle on Stability of

Research and Development Center，China Academy of Launch Vehicle Technology，Beijing 100076，China,Research and Development Center，China Academy of Launch Vehicle Technology，Beijing 100076，China,Research and Development Center，China Academy of Launch Vehicle Technology，Beijing 100076，China and Research and Development Center，China Academy of Launch Vehicle Technology，Beijing 100076，China

Published:2021-08-15

摘要/Abstract

摘要： 为了揭示潜入式喷管对固体火箭发动机工作稳定性的影响，基于VKI (Von Karman Institute for Fluid Dynamics) 模型发动机，利用大涡模拟数值方法与脉冲衰减法，计算分析了潜入式喷管对涡声耦合特性及喷管阻尼的影响。结果表明:在存在障碍物旋涡脱落的条件下，潜入式空腔能够加剧涡声耦合强度，继而诱发明显的压力振荡，含有潜入式空腔模型内的压力振幅是不含潜入式空腔模型下的4倍左右；潜入式喷管削弱了发动机的阻尼特性，无潜入式空腔的喷管阻尼比含潜入式空腔的喷管阻尼提高了8.6%左右，而且喷管阻尼随着潜入式空腔体积的增大基本呈线性减小趋势。潜入式喷管一般而言不利于发动机工作稳定性。

关键词: 固体火箭发动机；燃烧不稳定性；潜入式喷管；涡声耦合；喷管阻尼

Abstract: In order to reveal the effects of submerged nozzle on the working stability of solid rocket motor，the vortex-acoustic phenomenon and nozzle damping characteristics are numerically studied via large eddy simulation (LES) and pulsed decay method based on VKI (Von Karman Institute for Fluid Dynamics) motor. Results indicate that the submerged cavity can enhance the vortex-acoustic coupling intensity under the condition of obstacle vortex shedding，which results in obvious pressure oscillations. The normalized pressure magnitude in the motor with submerged cavity is three times higher than that without submerged cavity. The submerged cavity can reduce the nozzle damping. The damping rate of no-submerged nozzle is 8.6% higher than that of submerged nozzle. Besides，the nozzle damping rate is inversely linear with the submerged nozzle cavity volume. The larger submerged nozzle cavity volume has，the smaller damping rate is. The submerged nozzle is usually harmful to the stability of solid rocket motors.

Key words: Solid rocket motor；Combustion instability；Submerged nozzle；Vortex-acoustic coupling；Nozzle damping

苏万兴,李要建,陈升泽,李吉. 潜入式喷管对固体火箭发动机工作稳定性影响[J]. 推进技术, 2016, 37(8): 1529-1534.

SU Wan-xing,LI Yao-jian,CHEN Sheng-ze,LI Ji. Effects of Submerged Nozzle on Stability of[J]. Journal of Propulsion Technology, 2016, 37(8): 1529-1534.

参考文献

[1] 孙维申. 体火箭发动机不稳定燃烧[M]. 北京:北京工业学院出版社, 1987.
[2] Blomshield F S. Lessons Learned in Solid Rocket Combustion Instability[R]. AIAA 2007-5803.
[3] Fabignon Y, Dupays J. Instability and Pressure Oscillations in Solid Rocket Motors[J]. Aerospace Science and Technology, 2003, 7(3): 191-200.
[4] 王宁飞, 张峤, 李军伟, 等. 固体火箭发动机不稳定燃烧研究进展[J]. 航空动力学报, 2011, 26(6):1405-1414.
[5] 刘佩进, 金秉宁, 李强. 战术导弹固体发动机燃烧不稳定研究概述[J]. 固体火箭技术, 2012, 35(4):446-449.
[6] 杨尚荣, 刘佩进, 魏祥庚, 等. 固体火箭发动机径向加质流局部稳定性分析方法研究[J] 推挤技术, 2013, 34(7): 925-931. (YANG Shang-rong, LIU Pei-jin, WEI Xiang-geng, et al. A Study of Anlysis Method for Hydrodynamic Stabilities of Solid Rocket Motors with Side-Induced Flow[J]. Journal of Propulsion Technolgy, 2013, 34(7): 925-931.)
[7] 刘佩进, 杨尚荣, 陈晓龙. 介质温度和工作压强对发动机燃烧室中压强振荡的影响[J]. 推进技术, 2012, 33(6): 902-906. (LIU Pei-jin, YANG Shang-rong, CHEN Xiao-long. Effects of Temperature and Pressure on Pressure Oscillation in the Chamber of Solid Rocket Motor[J]. Journal of Propulsion Technology, 2012, 33(6): 902-906.)
[8] 苏万兴, 李军伟, 张峤, 等. 涡脱位置及温度对涡声效应压力振荡影响研究[J]. 推进技术, 2013, 34(2):248-253. ( SU Wan-xing, LI Jun-wei, ZHANG Qiao, et al. Effects of Vortex Shedding Position and Temperature on Vortex-Acoustic Pressure Oscillation Characteristics[J]. Journal of Propulsion Technolgy, 2013, 34(1): 61-66.)
[9] 张峤, 李军伟, 王伟臣, 等. 固体火箭发动机涡声耦合特性数值研究[J]. 推挤技术, 2011, 32(3): 348-354. (ZHANG Qiao, LI Jun-wei, WANG Wei-chen, et al. Numerical Analysis on Vortex Acoustic Coupling Characteristics in Solid Rocket Motors[J]. Journal of Propulsion Technology, 2011, 28(10): 2376-2383. )
[10] Zhang Qiao, Wei Zhijun, Su Wanxing, et al. Theoretical Modeling and Numerical Study for Thrust Oscillation Characteristics in Solid Rocket Motors[J]. Journal of Propulsion and Power, 2012, 28(2): 312-322.
[11] 苏万兴, 李世鹏, 张峤, 等. 某固体火箭发动机工作末期不稳定燃烧数值研究[J]. 航空动力学报, 2013, 28(10): 2376-2383.
[12] 王元有. 固体火箭发动机设计[M]. 北京:国防工业出版社, 1984.
[13] Prevost M, Vuillot F, Traineau J C. Vortex Shedding Driven Oscillations in Subscale Motors for the Ariane 5 MPS P230[R]. AIAA 96-3247.
[14] Anthoine J, Buchlin J M, Hirschberg A. Effect of Nozzle Cavity on Resonance in Large SRM: Theoretical Modeling[J]. Journal of Propulsion and Power, 2002, 18(2): 304-311.
[15] Anthoine J, Buchlin J M, Guery J F. Effect of Nozzle Cavity on Resonance in Large SRM: Numerical Simulations[J]. Journal of Propulsion and Power, 2003, 19(3): 374-384.
[16] Anthoine J. Experimental and Numerical Study of Aeroacoustic Phenomena in Large Solid Propellant Boosters [D]. Brussels Belgium: Von Karman Institute for Fluid Dynamics, 2000.
[17] 陈晓龙, 何国强, 刘佩进, 等. 潜入式喷管对燃烧室中压力振荡的影响[J]. 固体火箭技术, 2010, 33(3):252-255.
[18] 吴亚可, 何国强, 刘佩进, 等. 潜入式喷管背区空腔对压强振荡及旋涡运动影响的实验研究[J]. 固体火箭技术, 2010, 33(6): 621-625.
[19] 胡春波, 何国强, 刘佩进, 等. 潜入喷管背壁区熔渣溢流沉积实验研究[J]. 推进技术, 2001, 22(3):204-206. (HU Chun-bo, HE Guo-qiang, LIU Pei-jin, et al. Experimental Study on Slag Accumulation in Back Wall Region of SRM Submerged Nozzle[J]. Journal of Propulsion Technology, 2001, 22(3): 204-206.)
[20] 向红军, 方国尧. 固体火箭发动机熔渣沉积数值模拟[J]. 推进技术, 2002, 23(5): 366-369. (XIANG Hong-jun, FANG Guo-yao. Numerical Simulation of Slag Accumulation for Solid Rocket Motors[J]. Journal of Propulsion Technology, 2002, 23(5): 366-369.)
[21] Janardan B A, Zinn B T. Rocket Nozzle Damping Characteristics Measured Using Different Experimental Techniques[J]. AIAA Journal, 1977, 15(3): 442-444.
[22] 苏万兴. 大长径比固体火箭发动机不稳定燃烧预示及抑制方法研究[D]. 北京:北京理工大学, 2015.(编辑:史亚红)　　　　　　　　　　　　　*　收稿日期:2015-04-02；修订日期:2015-05-12。作者简介:苏万兴,男,博士,工程师,研究领域为固体火箭发动机不稳定燃烧。E-mail: suwx_bit@163.com