锯齿电极等离子体激励器对气膜冷却效率影响的数值研究

推进技术 ›› 2017, Vol. 38 ›› Issue (11): 2548-2554.

锯齿电极等离子体激励器对气膜冷却效率影响的数值研究

李国占,俞建阳,刘华坪,陈浮,李林熹

哈尔滨工业大学能源科学与工程学院，黑龙江哈尔滨 150001,哈尔滨工业大学能源科学与工程学院，黑龙江哈尔滨 150001,哈尔滨工业大学能源科学与工程学院，黑龙江哈尔滨 150001,哈尔滨工业大学能源科学与工程学院，黑龙江哈尔滨 150001,哈尔滨工业大学能源科学与工程学院，黑龙江哈尔滨 150001

发布日期:2021-08-15
作者简介:李国占，男，博士生，研究领域为燃气轮机叶片气膜冷却技术。
基金资助:
国家自然科学基金(51306042)。

Numerical Simulation of Effects of Saw Tooth Plasma Actuator on Film Cooling Efficiency

School of Energy Science and Engineering，Harbin Institute of Technology，Harbin 150001，China,School of Energy Science and Engineering，Harbin Institute of Technology，Harbin 150001，China,School of Energy Science and Engineering，Harbin Institute of Technology，Harbin 150001，China,School of Energy Science and Engineering，Harbin Institute of Technology，Harbin 150001，China and School of Energy Science and Engineering，Harbin Institute of Technology，Harbin 150001，China

Published:2021-08-15

摘要/Abstract

摘要： 为获得锯齿电极等离子体激励器提高气膜冷却效率的机理，对有/无锯齿电极等离子体激励器作用下的平板气膜冷却流场进行了数值研究，并采用唯象模型模拟锯齿电极等离子体激励器对流场所施加的电场力。结果表明，冷却射流在锯齿电极等离子体激励器的下拉诱导作用下对主流的穿透率降低，射流中心轨迹高度的下降幅度沿流向发展逐渐增大；锯齿电极等离子体激励器气动激励作用下气膜孔下游的肾形涡的强度与尺度均减小，同时肾形涡的两侧产生与其旋转方向相反的小尺度的反肾形涡，进一步抑制了肾形涡的发展；锯齿电极等离子体激励器产生的展向扩散效应提高了冷却射流的展向扩张能力，从而提高了气膜冷却效率，与无等离子体气动激励相比，锯齿电极等离子体激励器作用下平板中心线与展向平均气膜冷却效率分别提高了50%与200%。

关键词: 锯齿电极；等离子体；气膜冷却；肾形涡；冷却效率

Abstract: In this article，to reveal the mechanism of saw tooth plasma actuator on enhancing flat plate film cooling efficiency，the film cooling flow fields with and without plasma actuation are numerically investigated. A phenomenological plasma model was used to provide the electric field generated by the saw tooth plasma actuator，resulting in a plasma force vector. Results show that with the downward plasma force，the penetration depth of the cold jet into the crossflow greatly reduces，and the reduction of the jet trajectory height gradually increases while approaching downstream，thus the strength and the size of the kidney shaped vortex are decreased. Moreover，the saw tooth plasma actuator induces small scale anti-kidney shaped vortices，which have opposite rotating direction with the kidney shaped vortex，so the strength of the kidney shaped vortex is further weakened. The spanwise-spreading effects of the saw tooth plasma actuator promote the spanwise spreading rate of the cold jet，thus the film cooling efficiency is enhanced. When the saw tooth plasma actuation is applied，the centerline and the spanwise-averaged film cooling efficiency are improved by 50% and 200% at most，respectively.

Key words: Saw tooth actuator；Plasma；Film cooling；Kidney shaped vortex；Cooling efficiency

李国占,俞建阳,刘华坪,陈浮,李林熹. 锯齿电极等离子体激励器对气膜冷却效率影响的数值研究[J]. 推进技术, 2017, 38(11): 2548-2554.

LI Guo-zhan,YU Jian-yang,LIU Hua-ping,CHEN Fu,LI Lin-xi. Numerical Simulation of Effects of Saw Tooth Plasma Actuator on Film Cooling Efficiency[J]. Journal of Propulsion Technology, 2017, 38(11): 2548-2554.

参考文献

[1] 吴宏, 杨庆. 抑涡孔气膜冷却的大涡模拟[J]. 航空动力学报, 2012, 27(12): 2649-2654.
[2] Bunker R S. A Review of Shaped Hole Turbine Film-Cooling Technology[J]. Journal of Heat Transfer, 2005, 127: 441-453.
[3] Kusterer K, Bohn D, Sugimoto T, et al. Double-Jet Ejection of Cooling Air for Improved Film-Cooling[J]. Journal of Turbomachinery, 2007, 129(4): 809-815.
[4] Yuen C H N, Martinez-Botas R F. Film Cooling Characteristics of Rows of Round Holes at Various Streamwise Angles in a Crossflow, Part I: Effectiveness[J]. International Journal of Heat and Mass Transfer, 2005, 48: 4995-5016.
[5] 戴萍, 林枫. 横向槽结构对气膜冷却效果影响的数值研究[J]. 推进技术, 2011, 32(2): 253-260. (DAI Ping, LIN Feng. Numerical Investigation on the Influence of Transverse Slot Configurations on Film Cooling Effect[J]. Journal of Propulsion Technology, 2011, 32(2): 253-260.)
[6] Moreau E. Airflow Control by Non-Thermal Plasma Actuators[J]. Journal of Physics D: Applied Physics, 2007, 40: 605-636.
[7] 何立明, 苏建勇, 白晓峰, 等. 等离子体气动激励改善气膜冷却效率的数值研究[J]. 空军工程大学学报(自然科学版), 2008, 9(3): 1-5.
[8] 代胜吉, 何立明, 丁未, 等. 马蹄形等离子体激励器强化气膜冷却效率机理[J]. 航空动力学报, 2013, 28(9): 1982-1987.
[9] Roy S, Wang C C. Plasma Actuated Heat Transfer[J]. Journal of Applied Physics, 2008, 92(23): 231501-231503.
[10] Roy S, Wang C C. Numerical Investigation of Three-Dimensional Plasma Actuation[J]. Journal of Thermophysics and Heat Transfer, 2013, 27(3): 489-497.
[11] Wang C C, Durscher R, Roy S. Three-Dimensional Effects of Curved Plasma Actuators in Quiescent Air[J].Journal of Applied Physics, 2011, 109: 1-9.
[12] 刘志丰, 王连泽, 张明明. 锯齿电极等离子体激励器诱导流场特性分析[C]. 西安:中国工程热物理学会2014年度学术年会, 2014.
[13] Joussot R, Leroy A, Weber R, et al. Plasma Morphology and Induced Airflow Characterization of a DBD Actuator with Serrated Electrode[J]. Journal of Physics D: Applied Physics, 2013, 46: 1-12.
[14] shyy W, Jayaraman B, Andersson A. Modeling of Glow Discharge-Induced Fluid Dynamics[J]. Journal of Applied Physics, 2002, 92(11): 6434-6443.
[15] 李国占, 陈浮, 李林熹, 等. 基于等离子体控制的平板气膜冷却流动特性的大涡模拟[C]. 厦门:中国工程热物理学会2015年度学术年会, 2015.
[16] 李国占, 陈浮, 李林熹, 等. 不同等离子体激励强度下气膜冷却特性的大涡模拟研究[J]. 推进技术, 2017, 38(1). (LI Guo-zhan, CHEN Fu, LI Lin-xi, et al. Large Eddy Simulation of the Film Cooling Flow Characteristics under Different Plasma Actuation Strengths[J].Journal of Propulsion Technology, 2017, 38(1).)
[17] Liu Z F, Wang L Z, Fu S. Study of Flow Induced by Sine Wave and Saw Tooth Plasma Actuators[J]. Science China Physics, Mechanics and Astronomy, 2011, (54): 2033-2039.
[18] Kohli A, Bogard D G. Adiabatic Effectiveness, Thermal Fields, and Velocity Fields for Film Cooling with Large Angle Injection[J]. Journal of Turbomachinery, 1997, 119: 352-358.(编辑:史亚红)　　　　　　　　　　　　　*　收稿日期:2016-06-12；修订日期:2016-08-31。基金项目:国家自然科学基金(51306042)。作者简介:李国占,男,博士生,研究领域为燃气轮机叶片气膜冷却技术。E-mail: liguozhan90@gmail.com