高负荷压气机静叶根部叶型气动性能实验研究

推进技术 ›› 2017, Vol. 38 ›› Issue (3): 581-587.

高负荷压气机静叶根部叶型气动性能实验研究

李晓东,钟兢军,高宇

大连海事大学轮机工程学院，辽宁大连 116026,大连海事大学轮机工程学院，辽宁大连 116026,大连海事大学轮机工程学院，辽宁大连 116026

发布日期:2021-08-15
作者简介:李晓东，男，博士生，研究领域为叶轮机械气动热力学。
基金资助:
国家自然科学基金重点项目(51436002)；辽宁省高校创新团队支持计划资助(LT2015004)；中央高校基本科研

Experimental Investigation on Performance of a Profile at Cascade Hub in a High Load Compressor Stator

Marine Engineering College，Dalian Maritime University，Dalian 116026，China,Marine Engineering College，Dalian Maritime University，Dalian 116026，China and Marine Engineering College，Dalian Maritime University，Dalian 116026，China

Published:2021-08-15

摘要/Abstract

摘要： 为研究高负荷压气机静叶根部流动状态，抽取该静叶根部叶型并模化成为平面叶栅进行吹风实验，冲角变化范围为-6°～+6°、进口马赫数变化范围为0.5～0.7。对叶栅出口截面气动参数进行了详细的测量，结果表明:非正冲角时叶展中部节距平均总压损失系数小于等于0.036，尾迹宽度和总压损失峰值随马赫数变化均不明显，正冲角时尾迹宽度和总压损失峰值急剧增加；端壁处的压力梯度随马赫数和冲角的增加而增加；0°冲角下随马赫数的增大，出口叶展中部截面二次流动能系数增加，二次流动得到加强，高能量损失区域增大并且尾迹略有变宽。

关键词: 静叶；高负荷；平面叶栅；气动性能；实验研究

Abstract: In order to study the flow field at the hub zone in a high load compressor stator，profile of the stator hub had been extracted and modeled into a cascade. A detailed experimental investigation on the cascade with the incidence ranges from -6° to +6° and inlet Mach number ranges from 0.5 to 0.7 was carried out. The aerodynamic parameters at the outlet of the cascade were measured in detail. The results show that，at the incidence no greater than 0°，the pitch-averaged total pressure loss coefficient at mid-span is no greater than 0.036，neither the peak value of total pressure loss coefficient nor the width of wake changes significantly with the inlet Mach number. With the incidences greater than 0°，both the width of the wake and the peak value of total pressure loss will grow rapidly. Pressure gradient at the endwall increases with the increase of inlet Mach number and incidence. At 0° incidence，as the inlet Mach number grows，the secondary flow kinetic energy coefficient will grow and the secondary flow will be enhanced，and there is a slight increase in the area of high energy loss coefficient and the wake width，too.

Key words: Compressor stator；High load；Cascade；Aerodynamic performance；Experimental investigation

李晓东,钟兢军,高宇. 高负荷压气机静叶根部叶型气动性能实验研究[J]. 推进技术, 2017, 38(3): 581-587.

LI Xiao-dong,ZHONG Jing-jun,GAO Yu. Experimental Investigation on Performance of a Profile at Cascade Hub in a High Load Compressor Stator[J]. Journal of Propulsion Technology, 2017, 38(3): 581-587.

参考文献

[1] Miller G R, Lewis Jr G W, Harmann M J. Shock Losses in Transonic Compressor Blade Rows[J]. Journal of Engineering for Power, 1961, 83(3): 235-242.
[2] Gallus H E, Bohn D, Broichhausen K-D. Measurements of Quasi-Steady and Unsteady Flow Effects in a Supersonic Compressor Stage[J]. Journal of Engineering for Power, 1977, 99(4): 537-544.
[3] Moore R D, Reid L. Performance of Single-Stage Axial-Flow Transonic Compressor with Rotor and Stator Aspect Ratios of 1.19 and 1.26, Respectively, and with Design Pressure Ratio of 2.05[R]. NASA Technical, 1659-1980.
[4] Calvert W J, Stapleton A W. Detailed Flow Measurements and Predictions for a Three-Stage Transonic Fan[J]. Journal of Turbomachinery, 1994, 116(2): 298-305.
[5] Hah C, Reid L. A Viscous Flow Study of Shock-Boundary Layer Interaction, Radial Transport, and Wake Development in a Transonic Compressor[J]. Journal of Turbomachinery, 1992, 114(3): 538-547.
[6] Strazisar A J. Investigation of Flow Phenomena in a Transonic Fan Rotor Using Laser Anemometry[J]. Journal of Engineering for Gas Turbines and Power, 1985, 107(2): 427-435.
[7] 宁方飞. 考虑真实几何复杂性的跨音压气机内部流动的数值模拟[D]. 北京:北京航空航天大学, 2002.
[8] 卢根新. 轴流压气机内部流动失稳及其被动控制策略研究[D]. 西安:西北工业大学, 2007.
[9] 杜文海. 跨声速多级轴流压气机非设计点性能预测[D]. 西安:西北工业大学, 2007.
[10] 胡江峰, 竺晓程, 欧阳华, 等. 轴流压气机非设计点性能计算[J]. 航空动力学报, 2012, 27(3): 682-688.
[11] 王剑, 欧阳华, 吴亚东, 等. 跨声速轴流压气机非设计点特性计算[J]. 汽轮机技术, 2012, 54(4): 253-256.
[12] Boyer K M. An Improved Streamline Curvature Approach for Off-Design Analysis of Transonic Compression Systems[D]. Blacksburg, US: Virginia Polytechnic Institute and State University, 2001.
[13] Cetin M, Ueer A S, Hirseh C, et al. Application of Modified Loss and Deviation Correlations to Transonic Axial Compressors[R]. AGARD-R-745, 1987.
[14] Dunham J. A New Endwall Model for Axial Compressor through Flow Calculations[J]. Journal of Turbomachinery, 1995, 117(4): 533-540.
[15] 刘波, 马乃行, 杨小东, 等. 适应较大叶型弯角范围的轴流压气机落后角模型[J]. 航空动力学报, 2014, 29(8): 1824-1831.
[16] 邓熙, 刘波, 马乃行. 高亚声速大弯角轴流压气机平面叶栅损失模型研究[J]. 推进技术, 2015, 36(9): 1302-1308. (DENG Xi, LIU Bo, MA Nai-xing. Investigation of Loss Model Applicable to Large Range of High Subsonic Cascades in Axial-Flow Compressor[J]. Journal of Propulsion Technology, 2015, 36(9):1302-1308.)
[17] 杜文海, 吴虎, 阮建刚. 跨声速轴流压气机特性计算用激波损失模型[J]. 推进技术, 2007, 28(4): 378-382. (DU Wen-hai, WU Hu, RUAN Jian-gang. A Shock Loss Model for the Transonic Axial Compressor[J]. Journal of Propulsion Technology, 2007, 28(4):378-382.)
[18] 李根深, 陈乃兴, 强国芳. 船用燃气轮机轴流式叶轮机械气动热力学(原理、设计与试验研究)下册[M]. 北京:国防工业出版社, 1985.
[19] 钟兢军, 高海洋, 武卉, 等. 变马赫数涡轮平面叶栅流场的实验研究[J]. 工程热物理学报, 2013, 34(1): 45-49.
[20] 钟兢军, 宋彦萍, 卢文才, 等. 五孔探针非对向测量法在风洞自动测试系统的应用[J]. 哈尔滨工业大学学报, 1997, 29(3): 61-64.
[21] 刘华坪, 陈焕龙, 杨晓光, 等. 基于耗散函数的低速扩压叶栅损失机理探讨[J]. 航空动力学报, 2011, 26(2): 289-296.
[22] 陈懋章. 粘性流体动力学基础[M]. 北京:高等教育工业出版社, 2002.
[23] 李相君, 楚武利, 张皓光. 高负荷轴流压气机叶栅二次流动与损失关联性探讨[J]. 推进技术, 2014, 35(7): 914-925. (LI Xiang-jun, CHU Wu-li, ZHANG Hao-guang. Investigation on Relation Between Secondary Flow and Loss on a High Loaded Axial-Flow Compressor Cascade[J]. Journal of Propulsion Technology, 2014, 35(7): 914-925.)
[24] 谭春青, 陈海生, 康顺, 等. 一种典型透平静叶型叶片正弯曲作用的实验研究[J]. 工程热物理学报, 2001, 22(3): 294-297.　收稿日期:2016-05-20；修订日期:2016-07-21。基金项目:国家自然科学基金重点项目(51436002)；辽宁省高校创新团队支持计划资助(LT2015004)；中央高校基本科研业务费专项资金(3132016334)。作者简介:李晓东,男,博士生,研究领域为叶轮机械气动热力学。E-mail: dmulxd@hotmail.com(编辑:张荣莉)