超声速燃烧室煤油多点喷注实验研究

推进技术 ›› 2017, Vol. 38 ›› Issue (3): 604-610.

超声速燃烧室煤油多点喷注实验研究

王洪亮,卢传喜,谭宇

中国空气动力研究与发展中心吸气式高超声速技术研究中心，四川绵阳 621000,中国空气动力研究与发展中心吸气式高超声速技术研究中心，四川绵阳 621000,中国空气动力研究与发展中心吸气式高超声速技术研究中心，四川绵阳 621000

发布日期:2021-08-15
作者简介:王洪亮，男，本科，助理研究员，研究领域为高超声速推进技术及超声速燃烧室点火与燃烧技术实验。

Experimental Study of Kerosene Injection with Multi-Location in a Supersonic Combustor

Air-Breathing Hypersonic Technology Research Center，China Aerodynamics Research and Development Center，Mianyang 621000，China,Air-Breathing Hypersonic Technology Research Center，China Aerodynamics Research and Development Center，Mianyang 621000，China and Air-Breathing Hypersonic Technology Research Center，China Aerodynamics Research and Development Center，Mianyang 621000，China

Published:2021-08-15

摘要/Abstract

摘要： 为了解决超声速燃烧室内局部煤油当量油气比过高造成的点火及稳定燃烧困难，在Ma=5，总当量油气比接近的条件下，研究了不同煤油喷注位置相互匹配方法对发动机点火性能和推力性能的影响。研究结果表明:多个油位匹配喷注，有利于煤油点火及燃烧，发动机推力性能更好。“值班火焰”引燃煤油时，其余煤油由更多位置喷注且单个位置当量油气比更低时更容易点火燃烧。“值班火焰”的当量油气比由0.51增加到0.55时，煤油燃烧性能变差，比冲降低46N·s/kg；当量油气比均为0.51时，其余煤油由三个位置喷注比两个位置喷注时比冲增加66N·s/kg。同一截面内上部壁面喷注结合下部支杆喷注，可以优化煤油在燃烧室高度方向上的分布，获得更好的发动机性能。上游位置喷注对煤油的预混作用不明显，煤油未燃烧会造成“值班火焰”当量油气比升高，导致发动机点火性能和推力性能变差。

关键词: 超声速燃烧室；喷注位置匹配；煤油分布；推力收益

Abstract: In order to solve the problems of ignition and flame-holding in some zones of a supersonic combustor where the fuel is too rich，experimental researches of different multi-location injections and their influences on the combustion/engine performances are studied under free stream Mach number 5 and with nearly the same total kerosene/air ratio. Some conclusions can be drawn: Multi-location injections are beneficial to the ignition and combustion of the kerosene and can result in better thrust performance. Combustions become much easier for cases with piloted flame and injection of kerosene from other locations with lower fuel/air ratio for a single injection location. The kerosene’s combustion performance becomes worse and the thrust specific decreases 46N·s/kg if the fuel/air ratio of piloted flame increased from 0.51 to 0.55. When the fuel/air ratio of piloted flame is 0.51 and the remainder kerosene is injected from three injection locations，the thrust specific increases 66N·s/kg，compared with the case which kerosene is injected from two injection locations. In the same section，kerosene injection from pylons on bottom wall combined with wall injection on top wall can enhance the kerosene distribution well-proportioned along the combustor height and get better thrust performance. Upstream injections do not premix kerosene well with the main flow. If ignition fails，the fuel/air ratio of piloted flame will increase，which will restrain the ignition of kerosene injected from other injectors and result in worse thrust performance.

Key words: Supersonic combustor；Multi-location injection；Kerosene distribution；Thrust benefit

王洪亮,卢传喜,谭宇. 超声速燃烧室煤油多点喷注实验研究[J]. 推进技术, 2017, 38(3): 604-610.

WANG Hong-liang,LU Chuan-xi,TAN Yu. Experimental Study of Kerosene Injection with Multi-Location in a Supersonic Combustor[J]. Journal of Propulsion Technology, 2017, 38(3): 604-610.

参考文献

[1] Routovsky V B. Study of Kerosene Auto-Ignition(Stage Ⅲ)[R]. Moscow State Aviation Institute, Technical Report F61708-96-WO₂86, 1997.
[2] 鲍加尔斯基 A B,苏金 B K. 液体燃料喷气式发动机的工作过程[M]. 北京:国防工业出版社, 1964.
[3] 严传俊, 范玮. 燃烧学[M]. 西安:西北工业大学出版社, 2005.
[4] 刘陵, 刘敬华, 张榛, 等. 超音速燃烧与超音速燃烧冲压发动机[M]. 西安:西北工业大学出版社, 1993.
[5] 王洪亮, 陈军, 白菡尘. 超声速燃烧室中煤油分布对燃烧性能的影响[J]. 推进技术, 2012, 33(5): 779-784. (WANG Hong-liang, CHEN Jun, BAI Han-chen. Study of the Effect of Distribution on Combustion Performance in Supersonic Combustor[J]. Journal of Propulsion Technology, 2012, 33(5): 779-784.)
[6] Sara Rocci-Denis, Dominic Maier, Hans-Peter Kau. Stage Injection in a Dual-Model Combustor for an Air-Breathing Engine[R]. AIAA 2008-2632.
[7] 李大鹏, 潘余, 梁剑寒. 喷注方式对双模态冲压发动机燃烧稳定性的影响[J]. 国防科技大学学报, 2006, 28(3): 10-14.
[8] 史新兴, 韦宝禧, 闫明磊, 等. 基于气动斜坡/燃气发生器的超燃燃烧室实验[J]. 推进技术, 2010, 31(5):549-554. (SHI Xin-xing, WEI Bao-xi, YAN Ming-lei, et al. Experiments of Integrated Aeroramp Injector/Gas-Portfire in a Supersonic Combustion[J]. Journal of Propulsion Technology, 2010, 31(5): 549-554.)
[9] Johe M Seiner, Dash S M. Historical Survey on Enhanced Mixing in Scramjet Engine[R]. AIAA 99-4869.
[10] 吴海燕, 周进, 邵艳, 等. 后掠结构对超声速燃烧斜坡喷注器性能的影响[J]. 航空动力学报, 2009, 24(6): 1248-1252.
[11] 王靛, 宋文艳, 曹玉吉, 等. 台阶和扩张形式对超燃燃烧室影响的数值研究[J]. 计算机仿真, 2008, 25(10): 82-85.
[12] Gruber M R, Nejad A S, Chen T H, et al. Mixing and Penetration Studies of Sonic Jets in a Mach 2 Free-stream[J]. Journal of Propulsion and Power, 1995, 11(2): 315-323.
[13] Palekar A, Truman C R, Vorobieff P. Prediction of Transverse Injection of a Sonic Jet in Supersonic Crossflow[R]. AIAA 2005-5366.
[14] Su-Hee Won, In-Seuck Jeung. Three-Dimensional Dynamic Characteristics of Transverse Fuel Injection into a Supersonic Crossflow[R]. AIAA 2008-2515.
[15] Cox-Stouffer S K, Gruber M R. Effects of Injector Yaw on Mixing Characteristics of Aerodynamic Ramp Injectors[R]. AIAA 99-0086.　　收稿日期:2015-09-30；修订日期:2015-12-10。作者简介:王洪亮,男,本科,助理研究员,研究领域为高超声速推进技术及超声速燃烧室点火与燃烧技术实验。 (编辑:梅瑛)