来流条件对微燃烧室中庚烷燃烧特性的影响

推进技术 ›› 2017, Vol. 38 ›› Issue (4): 869-877.

来流条件对微燃烧室中庚烷燃烧特性的影响

陈新建,姚荣,李军伟,冯芒,王宁飞

北京理工大学宇航学院，北京 100081,北京理工大学宇航学院，北京 100081,北京理工大学宇航学院，北京 100081,北京理工大学宇航学院，北京 100081,北京理工大学宇航学院，北京 100081

发布日期:2021-08-15
作者简介:陈新建，男，硕士生，研究领域为微尺度液体燃料燃烧。E-mail: 2120140035@bit.edu.cn 通讯作者:李军伟，男，博士，副教授，研究领域为微尺度燃烧和火箭发动机中的燃烧和流动。
基金资助:
国家自然科学基金(50906004)；北京高等学校“青年英才计划”(YETP1176)；北京理工大学基础研究基金

Effects of Inlet Flow on Combustion Characteristics of n-Heptane in a Micro-Combustor

School of Aerospace Engineering，Beijing Institute of Technology，Beijing 100081，China,School of Aerospace Engineering，Beijing Institute of Technology，Beijing 100081，China,School of Aerospace Engineering，Beijing Institute of Technology，Beijing 100081，China,School of Aerospace Engineering，Beijing Institute of Technology，Beijing 100081，China and School of Aerospace Engineering，Beijing Institute of Technology，Beijing 100081，China

Published:2021-08-15

摘要/Abstract

摘要： 为了通过改变来流条件提高微燃烧器中火焰的稳定性，使用液体正庚烷作为燃料，在内径为4mm的微燃烧室中，对不同庚烷流量和氧气浓度下庚烷液滴的燃烧特性进行了实验研究。结果表明，固定当量比为0.9，庚烷流量由10μL/min增大到30μL/min时，点火时间缩短，液滴滴落并形成液膜，液膜对点火以及稳定火焰有利。固定来流速度为0.33m/s时，加入氧气后，火焰出现瞬时喷射现象，但火焰不会熄灭。增加氧气浓度可以缩短点火时间，增强火焰稳定性。随着氧气浓度的增大，火焰长度总体上先增大后减小。燃烧声振呈现出低频特性，氧气浓度为0.46时声振最为强烈。

关键词: 微小尺度燃烧；火焰稳定性；氧气浓度；庚烷液滴；声振

Abstract: In order to improve flame stability by changing inlet flow condition，following experiments were performed by using n-heptane as fuel in a micro-combustor of 4mm internal diameter to study effects of fuel flowrate and oxygen concentration on n-heptane droplet combustion in micro-tube. It was found that，when equivalence ratio is fixed at 0.9 and heptane flow rate increases from 10μL/min to 30μL/min，ignition time decreases and droplet drips. Then the film was formed，which was beneficial for ignition and flame stability. At a fixed inlet flow velocity of 0.33m/s，instantaneous jet flame appeared when pure oxygen was added to air and the flame didn’t quench. Increasing oxygen concentration can reduce ignition time and improve flame stability. With increasing of oxygen concentration，flame length first increased and then decreased on the whole. Combustion sound-vibration exhibited low frequency characteristics and became most intense when oxygen concentration is 0.46.

Key words: Micro scale combustion；Flame stability；Oxygen concentration；n-heptane droplet；Sound vibration

陈新建,姚荣,李军伟,冯芒,王宁飞. 来流条件对微燃烧室中庚烷燃烧特性的影响[J]. 推进技术, 2017, 38(4): 869-877.

CHEN Xin-jian,YAO Rong,LI Jun-wei,FENG Mang,WANG Ning-fei. Effects of Inlet Flow on Combustion Characteristics of n-Heptane in a Micro-Combustor[J]. Journal of Propulsion Technology, 2017, 38(4): 869-877.

参考文献

[1] Deng W, Klemic JF, Li X, et al. Liquid Fuel Microcombustor Using Microfabricated Multiplexed Electrospray Sources[J]. Proceedings of the Combustion Institute, 2007, 31(2): 2239-2246.
[2] Sirignano W A, Pham T K, Dunn-Rankin D. Miniature-Scale Liquid-Fuel-Film Combustor[J]. Proceedings of the Combustion Institute, 2002, 29(1): 925-931.
[3] Ju Y, Maruta K. Microscale Combustion: Technology Development and Fundamental Research[J]. Progress in Energy and Combustion Science, 2011, 37(6): 669-715.
[4] Jejurkar S Y, Mishra D P. Flame Stability Studies in a Hydrogen-Air Premixed Flame Annular Microcombustor[J]. International Journal of Hydrogen Energy, 2011, 36(12): 7326-7338.
[5] Kaisare N S, Stefanidis G D, Vlachios D G. Comparison of Ignition Strategies for Catalytic Microburners[J]. Proceedings of the Combustion Institute, 2009, 32(2):3027-3034.
[6] Karagiannidis S, Mantzaras J. Numerical Investigation on the Start-up of Methane-Fueled Catalytic Microreactors[J]. Combustion and Flame, 2010, 157(7): 1400-1413.
[7] 李军伟, 钟北京. 微细直管燃烧器的散热损失研究[J]. 中国机电工程学报. 2007, 27(20): 59-63.
[8] 李军伟, 钟北京, 王建华. 甲烷/空气在微小型Swiss_roll燃烧器内燃烧的实验研究[J]. 热能与动力工程, 2008, 23(2): 195-200.
[9] 陈俊杰, 闫龙飞, 宋稳亚, 等. 传热对微型发动机预混催化燃烧特性影响的研究[J]. 推进技术, 2014, 35(10): 1363-1371. (CHEN Jun-jie, YAN Long-fei, SONG Wen-ya, et al. Effects of Heat Transfer on Premixed Catalytic Combustion Characteristics of Micro Engine[J]. Journal of Propulsion Technology, 2014, 35(10): 1363-1371.)
[10] Yuliati L, Seo T, Mikami M. Liquid-Fuel Combustion in a Narrow Tube Using an Electrospray Technique[J]. Combustion and Flame, 2012, 159(1): 462-464.
[11] 甘云华, 佟洋, 罗智斌. 乙醇在微尺度单电极燃烧器内的雾化与燃烧[J]. 化工学报, 2015, 66(11):4597-4602.
[12] Yueh-Heng Li, Yei-Chin Chao, Derek Dunn-Rankin. Combustion in a Meso-Scale Liquid-Fuel-Film Combustor with Central-Porous Fuel Inlet[J]. Combustion Science & Technology, 2008, 180(10): 1900-1919.
[13] Li J, Huang J, Yan M, et al. Experimental Study of N-heptane/air Combustion in Meso-Scale Burners with Porous Media[J]. Experimental Thermal and Fluid Science, 2014, 52(1): 47-58.
[14] Mikami M, Maeda Y, Matsui K, et al. Combustion of Gaseous and Liquid Fuels in Meso-Scale Tubes with Wire Mesh[J]. Proceedings of the Combustion Institute, 2013, 34(2): 3387-3394.
[15] Behrens D A, Lee I C, Waits C M. Catalytic Combustion of Alcohols for Microburner Applications[J]. Journal of Power Sources, 2010, 195(7): 2008-2013.
[16] Vijayan V, Gupta A K. Thermal Performance of a Meso-Scale Liquid-Fuel Combustor[J]. Applied Energy,2011, 88(7): 2335-2343.
[17] 李聪, 方蜀州, 张平. 微型涡喷发动机燃烧室数值模拟[J]. 推进技术, 2008, 29(5): 513-518. (LI Cong, FANG Shu-zhou, ZHANG Ping. Numerical Simulation of Annular Combustion Chamber for Micro-Turbine Engine[J]. Journal of Propulsion Technology, 2008, 29(5):513-518.)
[18] Rathore G K, Jacobs T. Formation Kinetics of Nitric Oxide of a Biodiesel Surrogate Relative to N-Heptane under Comparable Oxygen Equivalence Ratio in a Homogeneous Reactor[J]. Fuel, 2012, 93(1): 319-328.
[19] Liang Y, Shu G, Wei H, et al. Effect of Oxygen Enriched Combustion and Water-Diesel Emulsion on the Performance and Emissions of Turbocharged Diesel Engine[J]. Energy Conversion and Management, 2013, 73(5): 69-77.
[20] 罗斌, 张武高, 陈晓玲, 等. 氧浓度对斯特林发动机燃用不同燃料时燃烧火焰特征的影响[J]. 上海交通大学学报, 2013, 47(11): 1733-1737.
[21] 尤鸿燕. Rijke型预混燃烧器热声不稳定特性的试验研究[D]. 杭州:浙江大学, 2007.
[22] 马大猷. 现代声学理论基础[M]. 北京:科学出版社, 2004.　　　　　　　　　　　　　*　收稿日期:2015-10-22；修订日期:2016-02-05。基金项目:国家自然科学基金(50906004)；北京高等学校“青年英才计划”(YETP1176)；北京理工大学基础研究基金 (20130142009)。作者简介:陈新建,男,硕士生,研究领域为微尺度液体燃料燃烧。E-mail: 2120140035@bit.edu.cn通讯作者:李军伟,男,博士,副教授,研究领域为微尺度燃烧和火箭发动机中的燃烧和流动。E-mail: david78lee@gmail.com(编辑:梅瑛)