喷前压力脉动对撞击式喷嘴雾化特性的影响

推进技术 ›› 2017, Vol. 38 ›› Issue (5): 1100-1106.

喷前压力脉动对撞击式喷嘴雾化特性的影响

杨尚荣,杨岸龙,李龙飞,费俊,张锋

西安航天动力研究所液体火箭发动机技术重点实验室，陕西西安 710100,西安航天动力研究所液体火箭发动机技术重点实验室，陕西西安 710100,西安航天动力研究所液体火箭发动机技术重点实验室，陕西西安 710100,西安航天动力研究所液体火箭发动机技术重点实验室，陕西西安 710100,西安航天动力研究所液体火箭发动机技术重点实验室，陕西西安 710100

发布日期:2021-08-15
作者简介:杨尚荣，男，博士，工程师，研究领域为液体火箭发动机喷雾燃烧。
基金资助:
国家自然科学基金(11502186；51606138)。

Effects of Pressure Pulsation Upstream of Injector on Impinging Injector Atomization

Science and Technology on Liquid Rocket Engine Laboratory，Xi’an Aerospace Propulsion Institute，X’an 710100，China,Science and Technology on Liquid Rocket Engine Laboratory，Xi’an Aerospace Propulsion Institute，X’an 710100，China,Science and Technology on Liquid Rocket Engine Laboratory，Xi’an Aerospace Propulsion Institute，X’an 710100，China,Science and Technology on Liquid Rocket Engine Laboratory，Xi’an Aerospace Propulsion Institute，X’an 710100，China and Science and Technology on Liquid Rocket Engine Laboratory，Xi’an Aerospace Propulsion Institute，X’an 710100，China

Published:2021-08-15

摘要/Abstract

摘要： 为研究液体火箭发动机供应系统压力脉动对撞击式喷嘴雾化特性的影响，进行了撞击式喷嘴的动态雾化实验。通过脉动装置在喷嘴供应系统上施加不同频率和幅值的周期性压力脉动，利用两套高速摄影系统分别获得了动态雾化图像和雾场横截面上的散射光强，以此分析了撞击式喷嘴对喷前周期性压力脉动的响应频率和响应幅值范围及其对平均雾化角度的影响。结果表明，在研究的脉动频率范围内(0～4050Hz)，当喷前压力脉动幅值大于某一阈值后，雾化出现了明显的周期性质量聚集现象，其频率与喷前压力脉动的频率相同。脉动幅值增加，散射光强度的振荡幅值也增加，参与混合燃烧过程的介质流量振荡幅值加剧。平均雾化角度受脉动频率和幅值的影响都较小，变化范围处在均值的±4%以内。

关键词: 撞击式喷嘴；压力脉动；雾化；响应特性

Abstract: In order to investigate the effects of pressure pulsation of feed system on the atomization characteristic of an impinging injector in liquid rocket engines，the cold flow experiments on the dynamic response of liquid jet atomization have been carried out with water as the working fluid. Controlled perturbations of the injector inlet mass flow were realized by using a hydromechanical pulsator. Images of spray and scattered light intensity of a cross-section of spray field obtained using two high-speed photography systems were used to assess the range of the response frequency and amplitude and their effect on the average spray cone angle. The experimental results show that periodic cluster of droplets appears at pulsating frequencies up to 4050 Hz when pulsation amplitudes upstream of the injector exceed some critical amplitudes. The frequency of periodic cluster of droplets is the same as pulsating frequencies upstream of the injector. The amplitude of scattered light intensity increases with increasing pulsation amplitude，indicating that the pulsation amplitude of mass flux involved in mixing and combustion process is strengthened. However，the frequency and amplitude of pulsation have little influence on the average spray cone angle with the standard deviation less than 4%.

Key words: Impinging injector；Pressure pulsation；Atomization；Dynamic response

杨尚荣,杨岸龙,李龙飞,费俊,张锋. 喷前压力脉动对撞击式喷嘴雾化特性的影响[J]. 推进技术, 2017, 38(5): 1100-1106.

YANG Shang-rong,YANG An-long,LI Long-fei,FEI Jun,ZHANG Feng. Effects of Pressure Pulsation Upstream of Injector on Impinging Injector Atomization[J]. Journal of Propulsion Technology, 2017, 38(5): 1100-1106.

参考文献

[1] 杨 V, 安德松 W E . 液体火箭发动机燃烧不稳定性[M]. 北京:科学出版社, 2001.
[2] Anderson W E, Ryan H M, Santoro R J. Combustion Instability Mechanisms in Liquid Rocket Engines Using Impinging Jet Injectors[R]. AIAA 95-2357.
[3] Ryan H M, Anderson W E, Pal S, et al. Atomization Characteristics of Impinging Liquid Jets[J]. Journal of Propulsion and Power, 1995, 11(1): 135-145.
[4] Ibrahim E A. Comment on “Atomization Characteristics of Impinging Liquid Jets”[J]. Journal of Propulsion and Power, 2009, 25(6): 1361-1362.
[5] Anderson W E, Ryan H M, Santoro R J. Impact Wave-Based Model of Impinging Jet Atomization[J]. Atomization and Sprays, 2006, 16(7): 791-805.
[6] Chen X, Ma D, Yang V. Mechanism Study of Impact Wave in Impinging Jets Atomization[R]. AIAA 2012-1089.
[7] Rodrigues N S, Kulkarni V, Gao J, et al. An Experimental and Theoretical Investigation of Spray Characteristics of Impinging Jets in Impact Wave Regime[J]. Experimental in Fluids, 2015, 56: 50-52.
[8] 费俊, 孙璠, 杨伟东, 等. 射流撞击式雾化液滴运动过程与粒径分布特性的试验研究[J]. 火箭推进, 2015, 41(1): 10-14.
[9] 李佳楠, 费俊, 周立新, 等. 工质粘性对两股射流撞击雾化特性影响试验研究[J]. 火箭推进, 2015, 41(2): 43-49.
[10] 强洪夫, 刘虎, 陈福振, 等. 基于SPH方法的射流撞击仿真[J]. 推进技术, 2012, 33(3): 424-429. (QIANG Hong-fu, LIU Hu, CHEN Fu-zhen, et al. Simulation on Jet Impingement Based on SPH Method[J]. Journal of Propulsion Technology, 2012, 33(3): 424-429.)
[11] 郑刚, 聂万胜, 何博, 等. 撞击角对撞击式喷嘴雾化特性影响研究[J]. 推进技术, 2015, 36(4): 608-613. (ZHENG Gang, NIE Wan-sheng, HE Bo, et al. Effects of Impingement Angle on Atomization Characteristics of Impinging Jets Injector[J]. Journal of Propulsion Technology, 2015, 36(4): 608-613.)
[12] Anderson W E, Miller K L, Ryan H M, et al. Effects of Periodic Atomization on Combustion Instability in Liquid-Fueled Propulsion Systems[J]. Journal of Propulsion and Power, 1998, 14(5): 818-825.
[13] Mulmule A S, Tirumkudulu M S, Ananthkrishnan N, et al. Liquid Sheet Instability in the Presence of Acoustic Forcing[R]. AIAA 2007-5688.
[14] Chao C C, Heister S D. Contributions of Atomization to F-1 Engine Combustion Instabilities[J]. Engineering Analysis with Boundary Elements, 2004, 28: 1045-1053.
[15] Chehroudi B. Physical Hypothesis for the Combustion Instability in Cryogenic Liquid Rocket Engines[J]. Journal of Propulsion and Power, 2010, 26(6): 1153-1160.
[16] Sweeney B A, Frederick R A. The Effect of Liquid Jet Breakup Length on the Spray Dynamics of Like-Doublet Impinging Injectors[R]. AIAA 2014-3501.
[17] Sweeney B A, Frederick R A. Experimental Study on the Effects of Varying the Impingement Distance of Like-Doublet Injectors[R]. AIAA 2015-3846.
[18] Ahn B, Ismailov M, Heister S. Experimental Study Swirl Injector Dynamic Response Using a Hydromechanical Pulsator[J]. Journal of Propulsion and Power, 2012, 28(3): 585-595.
[19] Le Gal P, Farrugia N, Greenhalgh D A. Laser Sheet Dropsizing of Dense Sprays[J]. Optics & Laser Technology, 1999, 31: 75-83.
[20] Sirignano W A. Advances in Droplet Array Combustion Theory and Modeling[J]. Progress in Energy and Combustion Science, 2014, 42: 54-86.
[21] Jung K, Koh H, Yoon Y. Assessment of PLIF Measurement for Spray Mass Distribution of Like-Doublet Injector[J]. Measurement Science and Technology, 2003, 14(8): 1387-1395.　　　　　　　　　　　　*　收稿日期:2016-01-27；修订日期:2016-04-01。基金项目:国家自然科学基金(11502186；51606138)。作者简介:杨尚荣,男,博士,工程师,研究领域为液体火箭发动机喷雾燃烧。E-mail: yangnihaoma@126.com(编辑:张荣莉)