硼颗粒点火燃烧模型求解及影响因素分析

推进技术 ›› 2017, Vol. 38 ›› Issue (5): 1180-1187.

硼颗粒点火燃烧模型求解及影响因素分析

敖文¹,权恩²

西北工业大学燃烧、流动和热结构国家级重点实验室，陕西西安 710072,西安航天动力技术研究所，陕西西安 710025

发布日期:2021-08-15
作者简介:敖文，男，博士，讲师，研究领域为金属燃料燃烧和固体发动机燃烧不稳定研究。
基金资助:
国家自然科学基金(51506181)；中央高校基本科研业务费专项资金资助(3102015ZY083；3102014ZD0032)。

Numerical Model Solution and Analysis of Effect Factors of Boron Ignition and Combustion Behaviors

Science and Technology on Combustion，Internal Flow and Thermal-Structure Laboratory， Northwestern Polytechnical University，Xi’an 710072，China and Xi’an Aerospace Propulsion Institute，Xi’an 710072，China

Published:2021-08-15

摘要/Abstract

摘要： 简要介绍了含氧气和水蒸气环境下硼颗粒点火动力学模型和燃烧动力学模型，并给出了详细的数值求解方法，采用权威实验数据校验模型的合理性和准确性。利用模型预测硼颗粒点火燃烧特性，分析表面氧化层厚度，粒径，环境压强，氧分压，水蒸气分压及环境温度等因素对硼的点火燃烧特性的影响，并与相应的实验结果进行比较。结果显示，硼颗粒点火时间和燃烧时间均随粒径增大而增加。当粒径小于20μm时，燃烧时间与粒径基本呈正比关系。而当粒径大于20μm时，燃烧时间随粒径增大呈二次方增长。点火时间随初始氧化层厚度增加单调递增，增长率达到65ms/μm。点火时间和燃烧时间随环境压强增大基本呈现减小的趋势，但3MPa以上均不敏感。氧分压的提高对点火时间没有影响，但使燃烧时间明显减小，而水蒸气分压的升高则显著降低点火时间，但对燃烧时间几乎没有影响。环境温度的升高会减小点火时间，但对燃烧时间的影响可忽略。

关键词: 固体推进剂；硼；点火；燃烧；动力学模型

Abstract: The ignition and combustion kinetic model for single boron particles in oxygenated environment containing O₂ and H2O was developed. The specific numerical solution method was introduced. Prediction of the models was in good agreement with experimental data. The effects of particle size，initial oxide thickness，ambient pressure，partial pressure of oxygen，partial pressure of water vapor，and ambient temperature on boron ignition and combustion were investigated by numerical calculation. The results were compared with experiment as well. The results show both the ignition and combustion time increase with increasing particle size. The combustion time is found to be in direct proportion to particle size，but this dependency changes to quadratic when the particle size exceeds 20μm. The ignition time increases significantly as the initial oxide layer increases with a growth rate of 65ms/μm. Increased ambient pressure reduces both the ignition and combustion time，whereas the sensitivity is very weak at pressure higher than 3MPa. The ignition time is independent of oxygen partial pressure but decreases with increased water vapor partial pressure. On the contrary，the combustion time is independent of water vapor partial pressure but decreases with increased oxygen partial pressure. Similar effects on the ignition and combustion time as function of ambient temperature are obtained.

Key words: Solid propellant；Boron；Ignition；Combustion；Kinetic model

敖文,权恩. 硼颗粒点火燃烧模型求解及影响因素分析[J]. 推进技术, 2017, 38(5): 1180-1187.

AO Wen¹,QUAN En². Numerical Model Solution and Analysis of Effect Factors of Boron Ignition and Combustion Behaviors[J]. Journal of Propulsion Technology, 2017, 38(5): 1180-1187.

参考文献

[1] Hussmann B, Pfitzner M. Extended Combustion Model for Single Boron Particles-Part I: Theory[J]. Combustion and Flame, 2010, 157(4): 803-821.
[2] Ulas A, Kuo K K, Gotzmer C. Effects of Fluorine-Containing Species on the Ignition and Combustion of Boron Particles: Experiment and Theory[J]. International Journal of Energetic Materials and Chemical Propulsion, 2002, 5(1-6): 453-463.
[3] Zhou W, Yetter R A, Dryer F L, et al. Multi-Phase Model for Ignition and Combustion of Boron Particles[J]. Combustion and Flame, 1999, 117(1-2): 227-243.
[4] 毛成立, 李葆萱, 胡松启, 等. 热空气中硼粒子点火模型研究综述 [J]. 推进技术, 2001, 22(1): 6-9. (MAO Cheng-li, LI Bao-xuan, HU Song-qi, et al. Overview of Models of Boron Particle Ignition in Hot Air [J]. Journal of Propulsion Technology, 2001, 22(1): 6-9.)
[5] 范红杰, 王宁飞, 樊学忠, 等. 含硼富燃料推进剂点火特性[J]. 推进技术, 2008, 29(1): 102-104. (FAN Hong-jie, WANG Ning-fei, FAN Xue-zhong, et al. Ignition Characteristics of Boron-Based Fuel-Rich Propellants[J]. Journal of Propulsion Technology, 2008, 29(1): 102-104.)
[6] 敖文, 杨卫娟, 韩志江, 等. 硼颗粒点火燃烧模型研究进展[J]. 固体火箭技术, 2012, 35(3): 361-366.
[7] King M K. Boron Ignition and Combustion in Air-Augmented Rocket Afterburners[J]. Combustion Science and Technology, 1972, 5(4): 155-164.
[8] King M K. Boron Particle Ignition in Hot Gas Streams[J]. Combustion Science and Technology, 1974, 8(5-6): 255-273.
[9] King M K. Ignition and Combustion of Boron Particles and Clouds[J]. Journal of Spacecraft and Rockets, 1982, 19(4): 294-306.
[10] Yeh C L, Kuo K K. Ignition and Combustion of Boron Particles[J]. Progress in Energy and Combustion Science, 1996, 22(6): 511-541.
[11] Yeh C L, Kuo K K, Klimkiewicz M. Environmental Scanning Electron Microscopy Studies of Diffusion Mechanism of Boron Particle Combustion[J]. Scanning, 1997, 19(2): 114-118.
[12] Hussmann B, Pfitzner M. Extended Combustion Model for Single Boron Particles - Part II: Validation[J]. Combustion and Flame, 2010, 157(4): 822-833.
[13] Talley C P. Combustion of Elemental Boron[J]. Aero/Space Engineer, 1959, (18): 37-40.
[14] Ao W, Zhou J H, Liu J Z, et al. Kinetic Model of Single Boron Particle Ignition Based upon Both Oxygen and (BO)(n) Diffusion Mechanism[J]. Combustion Explosion and Shock Waves, 2014, 50(3): 262-271.
[15] Krier H, Burton R L, Spalding M J, et al. Ignition Dynamics of Boron Particles in a Shock Tube[J]. Journal of Propulsion and Power, 1998, 14(2): 166-172.
[16] Ao W, Wang Y, Li H P, et al. Effect of Initial Oxide Layer on Ignition and Combustion of Boron Powder[J]. Propellants Explosives Pyrotechnics, 2014, 39(2): 185-191.
[17] Liu T K, Shyu I M, Hsia Y S. Effect of Fluorinated Graphite on Combustion of Boron and Boron-Based Fuel-Rich Propellants[J]. Journal of Propulsion and Power, 1996, 12(1): 26-33.
[18] Robert O F, Rodney L B, Krier H. Boron Particle Ignition and Combustion at 30-150 ATM[J]. Combustion and Flame, 1999, (117): 32-58.
[19] Krier H, Burton R L, Pirman S R, et al. Shock Initiation of Crystalline Boron in Oxygen and Fluorine Compounds[J]. Journal of Propulsion and Power, 1996, 12(4): 672-679.
[20] Ulas A, Kuo K K, Gotzmer C. Ignition and Combustion of Boron Particles in Fluorine-Containing Environments[J]. Combustion and Flame, 2001, 127(1-2): 1935-1957.
[21] Yoshida T, Yuasa S. Effect of Water Vapor on Ignition and Combustion of Boron Lumps in an Oxygen Stream[J]. Proceedings of the Combustion Institute, 2000, (28): 2735-2741.
[22] Yuasa S, Isoda H. Ignition and Combustion of Small Boron Lumps in an Oxygen Stream[J]. Combustion and Flame, 1991, 86(3): 216-222.
[23] Yuasa S, Yoshida T, Kawashima M, et al. Effects of Pressure and Oxygen Concentration on Ignition and Combustion of Boron in Oxygen/Nitrogen Mixture Streams[J]. Combustion and Flame, 1998, 113(3): 380-387.
[24] 敖文, 杨卫娟, 汪洋, 等. 不同气氛下硼粉燃烧特性及动力学研究[J]. 中国电机工程学报, 2012, 32(29): 59-65.
[25] 敖文, 汪洋, 李和平, 等. 不同气氛下硼燃烧发射光谱分析及火焰形态研究[J]. 推进技术, 2014, 35(5): 648-653. (AO Wen, WANG Yang, LI He-ping, et al. Study on Emission Spectroscopy and Flame of Boron Combustion in Different Atmosphere[J]. Journal of Propulsion Technology, 2014, 35(5): 648-653.)
[26] Yang W, Ao W, Zhou J, et al. Impacts of Particle Size and Pressure on Reactivity of Boron Oxidation[J]. Journal of Propulsion and Power, 2013, 29(5): 1207-1213.　　　　　　　　　　　　　*　收稿日期:2016-03-14；修订日期:2016-04-22。基金项目:国家自然科学基金(51506181)；中央高校基本科研业务费专项资金资助(3102015ZY083；3102014ZD0032)。作者简介:敖文,男,博士,讲师,研究领域为金属燃料燃烧和固体发动机燃烧不稳定研究。E-mail: aw@nwpu.edu.cn(编辑:史亚红)