双支板超燃燃烧室变当量比喷注试验研究

推进技术 ›› 2017, Vol. 38 ›› Issue (9): 2011-2019.

双支板超燃燃烧室变当量比喷注试验研究

纪鹏飞,朱韶华,陈兵,徐旭

北京航空航天大学宇航学院，北京 100191,北京航空航天大学宇航学院，北京 100191,北京航空航天大学宇航学院，北京 100191,北京航空航天大学宇航学院，北京 100191

发布日期:2021-08-15
作者简介:纪鹏飞，男，硕士生，研究领域为超燃冲压发动机试验与数值模拟。
基金资助:
国家自然基金(51176003；51276007)。

Experimental Investigation of Dual-Struts Supersonic Combustor with Varying Equivalence Ratio Injections

School of Astronautics，Beihang University，Beijing 100191，China,School of Astronautics，Beihang University，Beijing 100191，China,School of Astronautics，Beihang University，Beijing 100191，China and School of Astronautics，Beihang University，Beijing 100191，China

Published:2021-08-15

摘要/Abstract

摘要： 为研究超燃冲压发动机分级喷注的性能特点，基于双支板燃烧室开展变当量比喷注下的燃烧现象、释热规律以及发动机内推力性能试验研究。燃烧室入口马赫数2，总温1436K。煤油流量的调节速率分别为11.97g/s2和35.90g/s2。不同当量比调节速率的试验表明，当量比调节速率不影响试验结果。随着上游当量比的减小，上游火焰由充满支板尾部逐渐转变为在剪切层附近分叉。试验中发现，燃烧室存在两种稳定的燃烧状态:上游燃烧状态和下游燃烧状态。上游燃烧状态下，上游当量比相同而下游当量比不同时，燃烧室内推力差别不显著；下游燃烧状态下，增加上游喷注会提高燃烧室性能。上游燃烧状态变化到下游燃烧状态的上游当量比为0.19。在相同总当量比下，上游多分配当量比获得的上游燃烧状态可使内推力增加。

关键词: 超燃冲压发动机；燃烧室；分级喷注；燃烧；内推力

Abstract: To investigate the performance of scramjet with multi-staged injection，based on a dual-struts combustor，the combustion phenomenon，heat release law and internal thrust of the engine experimentally with varying equivalence ratio were studied. Mach number and total temperature of chamber inlet were 2 and 1436K，respectively. The mass flow rate of kerosene changed at rate of 11.97g/s2 and 35.90g/s2，respectively. Experiments show that different varying rate of equivalence ratio make no difference to the results. As equivalence ratio at the upstream decreased，upstream flame transformed from full of the tail behind strut into a branch near the shear layer gradually. There are two steady combustion states in experiments: upstream combustion and downstream combustion. As for upstream combustion，change of equivalence ratio at downstream had no significant influence on internal thrust when keeping equivalence ratio at upstream unchanged，while the combustor performance could be improved with more kerosene injected from upstream for downstream combustion state. At upstream equivalence ratio 0.19，the upstream combustion turns into the downstream combustion. Internal thrust of the engine could be enhanced with higher equivalence ratio at the upstream on the condition of upstream combustion when keeping the total equivalence ratio unchanged.

Key words: Scramjet；Combustor；Staged injections；Combustion；Internal thrust

纪鹏飞,朱韶华,陈兵,徐旭. 双支板超燃燃烧室变当量比喷注试验研究[J]. 推进技术, 2017, 38(9): 2011-2019.

JI Peng-fei,ZHU Shao-hua,CHEN Bing,XU Xu. Experimental Investigation of Dual-Struts Supersonic Combustor with Varying Equivalence Ratio Injections[J]. Journal of Propulsion Technology, 2017, 38(9): 2011-2019.

参考文献

[1] 任春雷. 超燃冲压发动机支板混合增强机理研究[D]. 长沙:国防科技大学研究生院, 2009.
[2] 王晓栋, 乐嘉陵, 宋文艳. 带支板的冲压燃烧室的燃烧性能研究[J]. 空气动力学学报, 2004, 22(3):274-278.
[3] 刘兴洲. 中国超燃冲压发动机研究回顾[J]. 推进技术, 2008, 29(4): 385-395. (LIU Xing-zhou. Review of Scramjet Research in China[J]. Journal of Propulsion Technology, 2008, 29(4): 385-395.)
[4] Sadatake Tomioka, Atsuo Murakamit, Kenji Kudot, et al. Effects of Injection Scheme on Performance of a Staged Supersonic Combustor[R]. AIAA 99-2107.
[5] Sadatake Tomioka, Kan Kobayashi, Kenji Kudo, et al. Distributed Injection for Performance Improvement of a Supersonic Combustor with Multi-Staged Wall-Injections[R]. AIAA 2003-6991.
[6] Sadatake Tomioka, Atsuo Murakami, Kenji Kudo, et al. Combustion Tests of a Staged Supersonic Combustor with a Strut[J]. Journal of Propulsion and Power, 2001, 17(2): 293-300.
[7] Jiby Vellaramkalayil, Tobias Scheuermann, Jens von Wolfersdorf. Analysis of a Two-Staged Supersonic Combustion Chamber Using Experiments and Simulations[R]. AIAA 2011-2247.
[8] Sirka Fuhrmann, Andreas Hupfer, Hans-Peter Kau. The Investigations on Multi-Stage Supersonic Combustion in a Model Combustor [R]. AIAA 2011-2332.
[9] Taichang Zhang , Yueming Yuan , Jianguo Li, et al. Characteristics of a Supersonic Model Combustor with Two-Staged Injections of Supercritical Kerosene[R]. AIAA 2012-3762.
[10] Ramya Hande, Ani G Marathe. A Computational Study on Supersonic Combustion with Struts as Flame Holder[R]. AIAA 2008-4712.
[11] 俞刚, 李建国. 氢/空气超声速燃烧研究[J]. 流体力学实验与测量, 1999, 13(1):1-12.
[12] 冮强, 周乐仪, 覃正等. 液体碳氢燃料超燃冲压发动机支板凹槽稳焰技术试验[J]. 推进技术, 2011, 32(5): 680-683. (GANG Qiang, ZHOU Le-yi, QIN Zheng, et al. Experimental Investigation of Strut-Cavity Flameholder Technology in Liquid Hydrocarbon Fueled Scramjet Combustor[J]. Journal of Propulsion Technology, 2011, 32(5): 680-683.)
[13] Shinji Nakaya, Yuta Hikichi, Yoshiki Nakazawa, et al. Ignition and Supersonic Combustion Behavior of Liquid Ethanol in a Scramjet Model Combustor with Cavity Flame Holder[J]. Proceedings of the Combustion Institute, 2015, 35(2): 2091-2099.
[14] 范周琴, 刘卫东, 林志勇, 等. 支板喷射超声速燃烧火焰结构实验[J]. 推进技术, 2012, 33(6): 923-927. (FAN Zhou-qin, LIU Wei-dong, LIN Zhi-yong, et al. Experimental Investigation of Supersonic Combustion Flame Structure with Strut Injectors[J]. Journal of Propulsion Technology, 2012, 33(6): 923-927.)
[15] 徐旭, 陈兵, 徐大军. 冲压发动机原理及技术[M]. 北京:北京航空航天大学出版社, 2014.　　　　　　　　　　　　　*　收稿日期:2016-10-22；修订日期:2016-12-30。基金项目:国家自然基金(51176003；51276007)。作者简介:纪鹏飞,男,硕士生,研究领域为超燃冲压发动机试验与数值模拟。E-mail: jipengfei@buaa.edu.cn(编辑:史亚红)