高负荷压气机气弹效应对叶顶间隙流影响数值研究

推进技术 ›› 2017, Vol. 38 ›› Issue (9): 2093-2099.

高负荷压气机气弹效应对叶顶间隙流影响数值研究

邓小文¹,覃海起^1,2,尹洪¹,史久志¹

广东电网有限责任公司电力科学研究院，广东广州 510080,广东电网有限责任公司电力科学研究院，广东广州 510080; 西北工业大学动力与能源学院，陕西西安 710072,广东电网有限责任公司电力科学研究院，广东广州 510080,广东电网有限责任公司电力科学研究院，广东广州 510080

发布日期:2021-08-15
作者简介:邓小文，男，博士，教授级高级工程师，研究领域为燃气轮机转子振动及监测系统。
基金资助:
重型燃机压气机故障系统研制及工程应用(GDKJ00000005)。

Effects of Aero-Elasticity on Tip Clearance Flow of a High-Loading Compressor

Electric Power Research Institute of Guangdong Power Corporation，Guangzhou 510080，China,Electric Power Research Institute of Guangdong Power Corporation，Guangzhou 510080，China; School of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China,Electric Power Research Institute of Guangdong Power Corporation，Guangzhou 510080，China and Electric Power Research Institute of Guangdong Power Corporation，Guangzhou 510080，China

Published:2021-08-15

摘要/Abstract

摘要： 以NASA Rotor 67跨声速压气机转子为研究对象，在刚性叶片条件下进行了内流场非定常流动分析，并以此为基础，应用双向流固耦合(FSI)方法分析了该压气机在近失速点工况下气弹效应对叶顶间隙区流场的影响。通过对比分析，研究了刚性叶片与柔性叶片条件下该压气机的宏观非定常波动特征，分析了气弹效应对宏观性能波动频率、叶尖附面层分离起始点与尾缘涡脱落频率的影响，给出了叶片振动对前缘处宏观性能波动频率的影响大于尾缘处的原因。研究了气弹效应对叶顶间隙泄漏涡运动轨迹、波动频率以及作用范围的影响。结果显示，气弹效应使得尾缘处宏观性能以及泄露涡的波动频率分别增大了33.2%、2.28%，叶尖附面层分离涡与尾缘脱落涡的波动频率分别降低5.75%、0.75%，同时使得叶尖附面层分离起始点前移。

关键词: 跨声速压气机；气弹效应；近失速工况；叶顶泄漏流

Abstract: Unsteady flow field of transonic compressor NASA Rotor67 was analyzed under the assumption of rigid blade，and then two-way fluid-structure interaction (FSI) numerical method was used to analyze the effects of aero-elasticity on the tip clearance flow field under near stall condition. Through the comparisons between flow fields of rigid blade and flexible blade，unsteady characteristics of macro property of the flow fields were investigated，and the effects of aero-elasticity on the fluctuation frequency of macro property，the starting point of boundary layer separation at tip clearance and the shedding frequency of trailing edge vortex were also analyzed. Moreover，emphasis was given to the effect of aero-elasticity on the trajectory，fluctuation frequency and influence scope of tip clearance leakage vortex. Results shows that the effects of aero-elasticity increases，the fluctuation frequency of macro property and leakage vortex by 33.2% and 2.28%，respectively，while decreases the fluctuation frequency of boundary layer separation and shedding vortex at trailing edge by 5.75% and 0.75%，respectively. Also，it moves forward the starting point of separation at tip of blade.

Key words: Transonic compressor；Aero-elastic effects；Near stall condition；Tip leakage flow

邓小文,覃海起,尹洪,史久志. 高负荷压气机气弹效应对叶顶间隙流影响数值研究[J]. 推进技术, 2017, 38(9): 2093-2099.

DENG Xiao-wen¹,QIN Hai-qi^1,2,YIN Hong¹,SHI Jiu-zhi¹. Effects of Aero-Elasticity on Tip Clearance Flow of a High-Loading Compressor[J]. Journal of Propulsion Technology, 2017, 38(9): 2093-2099.

参考文献

[1] Im H, Zha G C. Investigation of Non-Synchronous Vibration Mechanism for a High Speed Axial Compressor Using Delayed DES[R]. AIAA 2014-0789.
[2] Hu Z J, Zha G C, Parallel Computation of Forced Vibration for a Compressor Cascade[R]. AIAA 2006-628.
[3] Gottfried D A, Fleeter S. Aerodynamic Damping Predictions in Turbomachinery Using a Coupled Fluid-Structure Model[J]. Journal of Propulsion and Power, 2005 21(2): 327-334 .
[4] 李立州, 王婧超, 吕震宇, 等. 涡轮叶片流固耦合协作优化方法[J]. 推进技术, 2008, 29(5): 604-608. (LI Li-zhou, WANG Jing-chao, LV Zhen-yu, et al. Collaborative Optimization Method for Fluid-Solid Coupling Problem of Turbine Blade[J]. Journal of Propulsion Technology, 2008, 29(5): 604-608.)
[5] 张翔, 黄秀全, 张恒铭, 等. 激波对跨声速风扇叶片颤振特性的影响[J]. 推进技术, 2016, 37(3): 411-418. (ZHANG Xiang, HUANG Xiu-quan, ZHANG Heng-ming, et al. Effects of Shock Wave on Blade Flutter Characteristics in Transonic Fan[J]. Journal of Propulsion Technology, 2016, 37(3): 411-418.)
[6] Ubulom I A, Shankar K, Neely A J. Turbine Blade Life Prediction Using Fluid-Thermal-Structure Interaction Modeling[R]. ASME GT 2015-43071.
[7] 王征, 吴虎, 史亚峰, 等. 基于CFD/CSD技术的压气机叶片流固耦合及颤振分析[J]. 航空动力学报, 2011, 26(5): 1077-1084.
[8] He L. Unsteady Flow in Oscillating Turbine Cascade; Part1: Linear Cascade Experiment[R]. ASME 96- GT-374.
[9] 李彬, 宋立明, 李军. 基于双向流固耦合的长叶片气动和强度性能的数值研究[J]. 推进技术, 2014, 35(2): 202-207. (LI Bin, SONG Li-ming, LI Jun. Numerical Investigations on Aerodynamic and Mechanical Performance of Long Blade Based on Two-Way Fluid-Structure Coupling Approach[J]. Journal of Propulsion Technology, 2014, 35(2): 202-207.)
[10] 王宏亮, 席光, 离心叶轮几何形变对气动性能的影响[J]. 西安交通大学学报, 2009, 43(5): 46-50.
[11] Wilson M J, Imregun M, Sayma A I . The Effect of Stagger Variability in Gas Turbine Fan Assemblies[J]. Journal of Turbomachinery, 2007, 129(2): 404-411.
[12] Harald S, Thomas B. Aeroelasticity at Reversed Flow Conditions, Part II: Application to Compressor Surge[J].Journal of Turbomachinery, 2012, 134(6): 061031-061031-8.
[13] Vahdati M, Simpson G, Imregun M. Unsteady Flow and Aeroelasticity Behavior of Aeroengine Core Compressors During Rotating Stall and Surge[J]. Journal of Turbomachinery, 2008, 130(3).
[14] Strazisar A, Wood J, Hathaway M, et al. Laser Anemometer Measurements in a Transonic Axial-Flow Fan Rotor[R]. NASA Technical Paper, 2879, 1989.
[15] 杜鹃. 跨音压气机/风扇转子叶顶泄漏流动的刚性叶片流场机理研究[D]. 北京:中国科学院研究生院, 2010.
[16] 陶海亮, 朱阳历, 郭宝亭, 等. 压气机叶片流固耦合数值计算[J]. 航空动力学报, 2012, 27(5): 1054-1060.
[17] 侯安平, 周盛. 对圆柱和二维扩压叶栅在平面风洞中漩涡脱落的试验研究[J]. 空气动力学学报, 2004, 22(1): 101-108.
[18] Inoue M, Kuroumaru M, Iwamoto T, et al. Detection of a Rotating Stall Precursor in Isolated Axial Compressor Rotors[J]. ASME Journal of Turbomachinery, 1991, 113(2): 281-289.(编辑:史亚红)　　　　　　　　　　　　　*　收稿日期:2016-04-27；修订日期:2016-06-04。基金项目:重型燃机压气机故障系统研制及工程应用(GDKJ00000005)。作者简介:邓小文,男,博士,教授级高级工程师,研究领域为燃气轮机转子振动及监测系统。E-mail:gzdxw@163.com