风扇单音噪声模态识别及其误差传递特性研究

推进技术 ›› 2018, Vol. 39 ›› Issue (1): 185-195.

风扇单音噪声模态识别及其误差传递特性研究

许坤波¹,乔渭阳¹,霍施宇²,魏人可¹,仝帆¹

西北工业大学动力与能源学院，陕西西安 710072,西北工业大学动力与能源学院，陕西西安 710072,中航工业飞机强度研究所，陕西西安 710065,西北工业大学动力与能源学院，陕西西安 710072,西北工业大学动力与能源学院，陕西西安 710072

发布日期:2021-08-15
作者简介:许坤波，男，博士生，研究领域为叶轮机械气动声学。
基金资助:
国家自然科学基金(51476134)；中国—欧盟航空科技国际合作项目(688971)。

Research of Mode Identification and Error Transfer Property on Fan Tonal Noise

School of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China,School of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China,AVIC Aircraft Strength Research Institute，Xi’an 710065，China,School of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China and School of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China

Published:2021-08-15

摘要/Abstract

摘要： 为了探究不同阵列对风扇单音噪声模态识别的影响，对径向耙和轴向传声器阵列在模态分解中的优缺点和误差传递特性进行了数值和实验研究。数值研究中通过在人造声场中加入随机扰动研究了不同阵列在径向模态分解中的误差传递特性，从而对两种阵列在径向模态分解方面的适用性和局限性进行评估。以此为指导，实验中通过旋转轴向阵列测量了风扇管道内顺流和逆流传播的模态波结构。结果表明中低频时径向耙式阵列误差较大，在模态截通频率处其传递函数的条件数大于100，而轴向阵列的条件数要小于10。轴向阵列在径向模态分解时，其精度强烈依赖于阵列轴向间距。实验结果表明管道内入射声波比反射声波能量高10dB左右。在入射声波中，转静干涉模态是其主导模态，而在反射声波中，模态能量分布规律不明显。

关键词: 单音噪声；模态；阵列；叶轮机械；风扇

Abstract: In order to analyze the influence on fan tonal noise mode decomposition with different arrays， the merits and drawbacks in mode decomposition using radial rakes and axial arrays and also the error transfer property were investigated in a numerical and experimental way. In the numerical study， the synthetic sound fields were superimposed by stochastic perturbation mode amplitude to analyze the error transfer characteristics of different arrays， the feasibility and limitation of arrays were evaluated subsequently. With above instruction， modal components propagating downstream and upstream were experimentally investigated using rotating axial arrays. Results show that error of radial rakes is larger in low and medium frequencies， the condition number of transfer function at mode cut-on frequencies is larger than 100， however， it is less than 10 in axial arrays. The precision of axial arrays is strongly dependent on the axial interval of the sensors in radial mode analysis. Experimental results show that the sound power of incident sound wave is 10dB higher than the reflected waves. Rotor-stator interaction modes dominate the incident mode waves， however， the general trend of the modal energy is inconclusive.

Key words: Tonal noise；Mode；Array；Turbomachinery；Fan

许坤波,乔渭阳,霍施宇,魏人可,仝帆. 风扇单音噪声模态识别及其误差传递特性研究[J]. 推进技术, 2018, 39(1): 185-195.

XU Kun-bo¹,QIAO Wei-yang¹,HUO Shi-yu²,WEI Ren-ke¹,TONG Fan¹. Research of Mode Identification and Error Transfer Property on Fan Tonal Noise[J]. Journal of Propulsion Technology, 2018, 39(1): 185-195.

参考文献

[1] 乔渭阳. 航空发动机气动声学[M]. 北京:北京航空航天大学出版社, 2010.
[2] 王良锋, 乔渭阳, 纪良, 等. 风扇进口噪声预测模型的改进[J]. 推进技术, 2015, 36(2): 226-231. (WANG Liang-feng, QIAO Wei-yang, JI Liang, et al. An Improved Prediction Model for Fan Inlet Noise[J]. Journal of Propulsion Technology, 2015, 36(2): 226-231.
[3] 乔渭阳, 李文兰. 飞机螺旋桨噪声的数值计算[J]. 推进技术, 1992, (5): 44-49. (QIAO Wei-yang, LI Wen-lan. The Numerical Calculation of Aircraft Propeller Noise[J]. Journal of Propulsion Technology, 1992, (5): 44-49.
[4] 何敬玉, 李晓东. 锯齿型喷口抑制热喷流噪声的实验研究[J]. 推进技术, 2015, 36(2): 167-174. (HE Jing-yu, LI Xiao-dong. Investigation into Hot Jet Noise Reduction Mechanisms of Chevron Nozzles[J]. Journal of Propulsion Technology, 2015, 36(2): 167-174.)
[5] Bolleter U, Crocker M J. Theory and Measurement of Modal Spectra in Hard-Walled Cylindrical Ducts [J]. Journal of the Acoustical Society of America, 1972, 51: 1439-1447.
[6] Bolleter U, Cohen R, WANG J. Design Considerations for an in-Duct Sound Power Measuring System[J]. Journal of Sound and Vibration, 1973, 28(4): 669-685.
[7] Moore C J. Measurement of Radial and Circumferential Modes in Annular and Circular Ducts[J]. Journal of Sound and Vibration, 1979, 62(2): 235-256.
[8] Joppa P D. Acoustic Mode Measurements in the Inlet of a Turbofan Engine[J]. Journal of Aircraft, 1987, 24(9).
[9] Heidelberg L and Hall D G. Inlet Acoustic Mode Measurements Using a Continuously Rotating Rake[J]. Journal of Aircraft, 1996, 32(4).
[10] Holste F, Neise W. Noise Source Identification in a Profane Model by Means of Acoustical Near Field Measurements[J]. Journal of Sound and Vibration, 1997, 203(4): 641-665.
[11] Enghardt L, Zhang Y, Neise W. Experimental Verification of a Radial Mode Analysis Technique Using Wall-Flush Mounted Sensors[C]. Berlin: 137th Regular Meeting of the Acoustical Society of America, 1999.
[12] Lan J H, Premo J W, Sutliff D L. Inlet Mode Measurements with an Inflow Control Device Microphone Array[R]. AIAA 2002-2563.
[13] Sutliff D L. Rotating Turbofan Duct Mode Measurement System[R]. NASA-TM-213828, 2005.
[14] Farassat F, Nark D M, Thomas R H. The Detection of Radiated Modes from Ducted Fan Engines[R]. AIAA 2001-2138.
[15] Tapken U, Enghardt L. Optimization of Sensor Arrays for Radial Mode Analysis in Flow Ducts[R]. AIAA 2006-2638.
[16] Enghardt L, Tapken U, Neise W, et al. Active Control of Fan Noise from High-Bypass Aeroengines: Experimental Results[J]. The Aeronautical Journal of the Royal Aeronautical Society, 2002, 106(3).
[17] Enghardt L, Tapken U, Kornow O, et al. Acoustic Mode Decomposition of Compressor Noise under Consideration of Radial Flow Profiles[R]. AIAA 2005-2833.
[18] Enghardt L, Tapken U, Neise W, et al. Turbine Blade/Vane Interaction Noise: Acoustic Mode Analysis Using In-duct Sensor Rakes[R]. AIAA 2001-2153.
[19] Tapken U, Bauers R, Neuhaus L, et al. A New Modular Fan Rig Noise Test and Radial Mode Detection Capability[R]. AIAA 2011-2897.
[20] Dahl M D, Hixon R, Sutliff D L. Further Development of Rotating Rake Mode Measurement Data Analysis[R]. AIAA 2013-2246.
[21] Taddei F, Lucia M D, Torzo D, et al. A Comparison Between Radial Rakes of Sensors and Axial Arrays of Microphones for the Experimental Investigation of Tone Noise in LPTs[R]. AIAA 2013-2245.
[22] Spitalny M, Tapken U. Radial Mode Analysis of Ducted Sound Fields with Sensor Rakes and Wall Flush Sensor Arrays under Consideration of a Radial Flow Profile[R]. AIAA 2016-3037.
[23] Nelson P A, Yoon S H. Estimation of Acoustic Source Strength by Inverse Methods: Part I, Conditioning of the Inverse Problem[J]. Journal of Sound and Vibration, 2000, 233(4): 639-664.
[24] Kim Y, Nelson P A. Estimation of Acoustic Source Strength within a Cylindrical Duct by Inverse Methods[J]. Journal of Sound and Vibration, 2004, 275(1): 391-41.(编辑:史亚红)　　　　　　　　　　　　　*　收稿日期:2017-02-14；修订日期:2017-05-28。基金项目:国家自然科学基金(51476134)；中国—欧盟航空科技国际合作项目(688971)。作者简介:许坤波,男,博士生,研究领域为叶轮机械气动声学。E-mail: xukunbo0424@163.com