脉冲燃烧风洞中空气节流对煤油燃料超燃冲压发动机火焰稳定影响研究

推进技术 ›› 2018, Vol. 39 ›› Issue (10): 2161-2170.

• 院士专稿 • 下一篇

脉冲燃烧风洞中空气节流对煤油燃料超燃冲压发动机火焰稳定影响研究

乐嘉陵¹,田野¹,杨顺华¹,岳茂雄²,苏铁²,钟富宇¹,田晓强¹

中国空气动力研究与发展中心超高速空气动力研究所高超声速冲压发动机技术重点实验室，四川绵阳 621000,中国空气动力研究与发展中心超高速空气动力研究所高超声速冲压发动机技术重点实验室，四川绵阳 621000,中国空气动力研究与发展中心超高速空气动力研究所高超声速冲压发动机技术重点实验室，四川绵阳 621000,中国空气动力研究与发展中心设备设计与测试技术研究所，四川绵阳 621000,中国空气动力研究与发展中心设备设计与测试技术研究所，四川绵阳 621000,中国空气动力研究与发展中心超高速空气动力研究所高超声速冲压发动机技术重点实验室，四川绵阳 621000,中国空气动力研究与发展中心超高速空气动力研究所高超声速冲压发动机技术重点实验室，四川绵阳 621000

发布日期:2021-08-15
作者简介:乐嘉陵，男，中国工程院院士，研究领域为高超声速空气动力学。
基金资助:
国家自然科学基金(51706237)；中国空气动力研究与发展中心风雷青年创新基金(20160024)。

Study on Flame Stabilization in a Kerosene Fueled Scramjet Combustor with Air Throttling in a Pulse Combustion Wind Tunnel

Science and Technology on Scramjet Laboratory of Hypervelocity Aerodynamics Institute，CARDC，Mianyang 621000，China,Science and Technology on Scramjet Laboratory of Hypervelocity Aerodynamics Institute，CARDC，Mianyang 621000，China,Science and Technology on Scramjet Laboratory of Hypervelocity Aerodynamics Institute，CARDC，Mianyang 621000，China,Facility Design and Instrumentation Institute of CARDC，Mianyang 621000，China,Facility Design and Instrumentation Institute of CARDC，Mianyang 621000，China,Science and Technology on Scramjet Laboratory of Hypervelocity Aerodynamics Institute，CARDC，Mianyang 621000，China and Science and Technology on Scramjet Laboratory of Hypervelocity Aerodynamics Institute，CARDC，Mianyang 621000，China

Published:2021-08-15

摘要/Abstract

摘要： 采用试验与数值模拟方法研究了空气节流对煤油燃料超燃冲压发动机火焰稳定的影响。发动机入口气流总温、总压和马赫数分别为1100K，1.0MPa和2.0。空气节流位置距离发动机入口625mm，空气节流流量为入口发动机空气流量的27.2%。多种非接触光学测量手段被应用于超燃冲压发动机燃烧流场结构和火焰传播规律的诊断，包括纹影、阴影、差分干涉、自发光照相和OH-PLIF。首先考察了有、无空气节流时超燃冲压发动机冷流流场的结构，结果显示:在实施空气节流后，流场内产生了激波串结构。激波串促使流场的静温和静压升高，马赫数降低。同时激波串与边界层相互作用，导致了边界层分离，促进了燃料与空气的高效混合，实现了煤油的可靠点火。其次考察了先锋氢气燃烧流场的火焰传播规律与稳定形态，结果表明:当先锋氢气当量比为0.3时，燃烧流场振荡；当先锋氢气当量比为0.1时，燃烧流场稳定。最后研究了空气节流对煤油燃料超燃冲压发动机火焰稳定的影响，结果表明:不实施空气节流时，液态室温煤油吹熄了先锋火焰，煤油点火失败；实施空气节流后，煤油成功点火，当先锋氢气和空气节流撤除后，煤油仍然保持稳定的燃烧。

关键词: 超燃冲压发动机；空气节流；煤油；火焰稳定

Abstract: In order to investigate the effects of air throttling on flame stabilization in a kerosene fueled scramjet combustor， numerical and experimental results were showed in the present paper. Stagnation conditions were 1100K and 1.0MPa and the Mach number at the isolator entrance was 2.0. The location of air throttling was 625mm downstream the combustor entrance， and the flux ratio (the ratio of air throttling flux rate to inflow flux rate) was 27.2% . Various measurements included schlieren， shadow， differential interferometry， flame emission and OH-PLIF were made during the experiments in an attempt to better understand the combustion flow structure and flame development. The flow structure of non-reacting flow with and without air throttling was investigated firstly， the results showed a shock train was generated by the throttling air in the combustor. The resultant increased in the temperature and pressure of the flow in the combustor， along with the decrease in the flow velocity， lead to smooth and reliable ignition. The flame development and stabilization of pilot hydrogen was studied secondly， when the ER of pilot hydrogen was 0.3， the pilot flame oscillated with the combustion flow; when the ER of pilot hydrogen was 0.1， the combustion flow was stable. Finally the effects of air throttling on flame stabilization were investigated， the pilot flame in the combustor without air throttling was blown off by the room temperature liquid kerosene. But the kerosene was ignited successfully by the pilot hydrogen with the aid of air throttling， and even when the throttling air and pilot hydrogen were removed， the flame was still stable.

Key words: Scramjet；Air throttling；Kerosene；Flame stabilization

乐嘉陵,田野,杨顺华,岳茂雄,苏铁,钟富宇,田晓强. 脉冲燃烧风洞中空气节流对煤油燃料超燃冲压发动机火焰稳定影响研究[J]. 推进技术, 2018, 39(10): 2161-2170.

LE Jia-ling¹,TIAN Ye¹,YANG Shun-hua¹,YUE Mao-xiong²,SU Tie²,ZHONG Fu-yu¹,TIAN Xiao-qiang¹. Study on Flame Stabilization in a Kerosene Fueled Scramjet Combustor with Air Throttling in a Pulse Combustion Wind Tunnel[J]. Journal of Propulsion Technology, 2018, 39(10): 2161-2170.

参考文献

[1] Yang V, Li J, Choi J, et al. Ignition Transient in an Ethylene Fueled Scramjet Engine with Air Throttling Part I: Non-Reacting Flow Development and Mixing[R].AIAA 2010-409.
[2] Yang V, Li J, Choi J. et al. Ignition Transient in an Ethylene Fueled Scramjet Engine with Air Throttling Part2:Ignition and Flame Development[R]. AIAA 2010-410.
[3] Donbar J, Powell O, Gruber M, et al. Post-Test Analysis of Flush-Wall Fuel Injection Experiments in a Scramjet Combustor[R]. AIAA 2001-3197.
[4] Li J, Ma F, Yang V, et al. Control and Optimization of Ignition Transient in Scramjet Engine Using Air Throttling[R]. AIAA 2006-1028.
[5] Choi J, Noh J, Yang V, et al. Numerical Investigation of Combustion/Shock-Train Interactions in a Dual-Mode Scramjet Engine[R]. AIAA 2011-2395.
[6] Noh J, Choi J, Yang V, et al. Numerical Simulation of Auto-Ignition of Ethylene in a Scramjet Combustor with Air Throttling[R] . AIAA 2010-7036.
[7] Gruenig C, Avrashkov V, Mayinger F. Self-Ignition and Supersonic Reaction of Pylon-Injected Hydrogen Fuel[J]. Journal of Propulsion and Power, 2000, 16(1).
[8] 田野, 乐嘉陵, 杨顺华, 等. 空气节流对超燃燃烧室流场结构和燃料混合影响的数值研究[J]. 推进技术, 2013, 34(1): 47-53. (TIAN Ye, LE Jia-ling, YANG Shun-hua, et al. Numerical Study on Air Throttling Influence of Flow Structure and Fuel-Air Mixing in the Scramjet Combustor [J]. Journal of Propulsion Technology, 2013, 34(1): 47-53.)
[9] 田野, 乐嘉陵, 杨顺华, 等. 空气节流对超燃燃烧室火焰稳定影响的数值研究[J]. 推进技术, 2013, 34(6): 795-801. (TIAN Ye, LE Jia-ling, YANG Shun-hua, et al. Numerical Study on Air Throttling Influence of Flame Stabilization in the Scramjet Combustor[J].Journal of Propulsion Technology, 2013, 34(6): 795-801.)
[10] 田野, 杨顺华, 邓维鑫, 等. 超燃冲压发动机燃烧室空气节流技术研究[J]. 推进技术, 2014, 35(4):499-506. (TIAN Ye, YANG Shun-hua, DENG Wei-xin, et al. Study on Air Throttling Technology in the Scramjet Combustor[J]. Journal of Propulsion Technology, 2014, 35(4): 499-506.)
[11] 田野, 乐嘉陵, 杨顺华, 等. 空气节流对超燃燃烧室起动点火影响的数值研究[J]. 航空动力学报, 2013, 28(7): 1495-1502.
[12] 田野, 杨顺华, 乐嘉陵, 等. 空气节流对乙烯燃料超燃冲压发动机流场结构影响研究[J]. 推进技术, 2015, 36(4): 481-487. (TIAN Ye, YANG Shun-hua, LE Jia-ling, et al. Study on the Flow Structure of an Ethylene-Fueled Scramjet Combustor with Air Throttling[J]. Journal of Propulsion Technology, 2015, 36(4): 481-487.)
[13] 田野, 杨顺华, 肖保国, 等. 空气节流对煤油燃料超燃冲压发动机燃烧性能影响研究[J]. 宇航学报, 2015, 36(12): 1421-1427.
[14] Tian Ye, Le Jia-ling, Yang Shun-hua. Study on the Effect of Air Throttling on Flame Stabilization of an Ethylene Fueled Scramjet Combustor[J]. International Journal of Aerospace Engineering, DOI:10.1155/2015/504684, 2015.
[15] Tian Ye, Le Jia-ling, Yang Shun-hua. Numerical Study on Effect of Air Throttling on Combustion Mode Formation and Transition in a Dual-Mode Scramjet Combustor[J]. Aerospace Science and Technology, 2016, 52: 173-180.
[16] Tian Ye, Yang Shun-hua, Le Jia-ling, et al. Investigation of Combustion and Flame Stabilization Modes in a Hydrogen Fueled Scramjet Combustor[J]. International Journal of Hydrogen Energy, 2016, 41: 19218-19230.
[17] Tian Ye, Xiao Bao-guo, Zhang Shun-ping, et al. Experimental and Computational Study on Combustion Performance of a Kerosene Fueled Dual-Mode Scramjet Engine[J]. Aerospace Science and Technology, 2015, 46: 451-458.
[18] Tian Ye, Yang Shun-hua, Xiao Bao-guo, et al. Experimental Study on the Effect of Air Throttling on Supersonic Combustion[J]. Journal of Aerospace Engineering, 2016, 232(3).
[19] Tian Ye, Yang Shun-hua, Le Jia-ling. Study on Flame Stabilization of a Hydrogen and Kerosene Fueled Combustor[J]. Aerospace Science and Technology, 2016, 59: 183-188.
[20] Bao W, Hu J, Zong Y, et al. Ignition Characteristic of a Liquid Kerosene Fueled Scramjet by Air Throttling Combined with a Gas Generator[J]. Journal of Aerospace Engineering, 2013, (2).
[21] Kok J. Resolving the Dependence on Free-Stream Values for the k-ω Turbulence Model[R]. AIAA Journal, 2000, 38(7).　　　　　　　　　　　　　*　收稿日期:2017-01-23；修订日期:2017-06-03。基金项目:国家自然科学基金(51706237)；中国空气动力研究与发展中心风雷青年创新基金(20160024)。作者简介:乐嘉陵,男,中国工程院院士,研究领域为高超声速空气动力学。E-mail: lejl123@126.com(编辑:史亚红)

脉冲燃烧风洞中空气节流对煤油燃料超燃冲压发动机火焰稳定影响研究

Study on Flame Stabilization in a Kerosene Fueled Scramjet Combustor with Air Throttling in a Pulse Combustion Wind Tunnel

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 0

编辑推荐

Metrics

本文评价