自燃推进剂旋转爆震燃烧实验研究

推进技术 ›› 2018, Vol. 39 ›› Issue (9): 1986-1993.

自燃推进剂旋转爆震燃烧实验研究

严宇,胡洪波,洪流,杨岸龙,陈帆

西安航天动力研究所液体火箭发动机技术重点实验室，陕西西安 710100,西安航天动力研究所液体火箭发动机技术重点实验室，陕西西安 710100,西安航天动力研究所液体火箭发动机技术重点实验室，陕西西安 710100,西安航天动力研究所液体火箭发动机技术重点实验室，陕西西安 710100,西安航天动力研究所液体火箭发动机技术重点实验室，陕西西安 710100

发布日期:2021-08-15
基金资助:
国家自然科学基金(51506157；11502186；11602086)。

Experimental Investigation on Rotated Detonation Combustion of Hypergolic Propellants

Science and Technology on Liquid Rocket Engine Laboratory，Xi’an Aerospace Propulsion Institute， Xi’an 710100，China,Science and Technology on Liquid Rocket Engine Laboratory，Xi’an Aerospace Propulsion Institute， Xi’an 710100，China,Science and Technology on Liquid Rocket Engine Laboratory，Xi’an Aerospace Propulsion Institute， Xi’an 710100，China,Science and Technology on Liquid Rocket Engine Laboratory，Xi’an Aerospace Propulsion Institute， Xi’an 710100，China and Science and Technology on Liquid Rocket Engine Laboratory，Xi’an Aerospace Propulsion Institute， Xi’an 710100，China

Published:2021-08-15

摘要/Abstract

摘要： 为了拓展旋转爆震燃烧方式在液体火箭发动机领域的应用范围，以一甲基肼为燃料，四氧化二氮为氧化剂，在圆环形燃烧室中组织旋转爆震燃烧。燃烧室内径为30mm，外径为60mm，采用了24对撞击式喷嘴，氧化剂喷孔0.4mm，燃料喷孔0.3mm。用稳态压力传感器和高频动态压力传感器记录供应及燃烧状态。实验中发现:自燃推进剂能够发生旋转爆震燃烧，频率达到7340Hz，爆震波峰值压力达到0.6MPa，爆震波速度达到1384m/s；爆震波引起的压力震荡可向上游喷注器传播；由于自燃推进剂为液/液反应，着火延迟时间约为10ms，在本燃烧室中该时间大于爆震波旋转一周所需的时间，因而爆震波到达时仍有较多的可燃混合物能够参与爆震燃烧；自燃推进剂发生旋转爆震燃烧需要足够大的流量密度，本实验中最小为103.7[kg/(s?m2)]；自燃推进剂在富燃条件下更容易发生旋转爆震燃烧。实验结果表明在火箭的姿态控制发动机上应用旋转爆震燃烧具有一定的可行性。

关键词: 旋转爆震；燃烧；自燃推进剂；实验

Abstract: In order to extend applied scope of rotating detonation in liquid rocket engine，rotating detonation was organized in an annular combustor using methyl hydrazine as fuel and nitrogen tetroxide as oxidizer. In the combustor with inner diameter 30mm and outer diameter 60mm，twenty-four pairs of impinging injection elements were used with oxidizer orifice 0.4mm and fuel orifice 0.3mm. Pressure sensors with low sampling rate and high frequency pressure sensors were used to record supply and combustion situation. The experiments demonstrate that rotating detonation can happen using hypergolic propellants with frequency of 7340Hz，with peak pressure of detonation wave 0.6MPa and detonation velocity 1384m/s. The pressure fluctuation caused by detonation combustion can propagate upwind injectors. Hypergolic combustion is liquid/liquid reaction with ignition delay of 10ms，which is longer than the time that detonation wave rotating a circle in combustor，so there is still enough amount of mixture for detonation combustion when detonation wave arrived. Mass flow rate density must be large enough for successful hypergolic rotating detonation，in this study the minimum value is 103.7[kg/(s?m2)]. Hypergolic rotating detonation tended to happen in fuel rich condition. The experimental results indicate it’s possible that rotating detonation can be used in attitude control system for rockets.

Key words: Rotating detonation；Combustion；Hypergolic propellants；Experiments

严宇,胡洪波,洪流,杨岸龙,陈帆. 自燃推进剂旋转爆震燃烧实验研究[J]. 推进技术, 2018, 39(9): 1986-1993.

YAN Yu,HU Hong-bo,HONG Liu,YANG An-long,CHEN Fan. Experimental Investigation on Rotated Detonation Combustion of Hypergolic Propellants[J]. Journal of Propulsion Technology, 2018, 39(9): 1986-1993.

参考文献

[1] Bykovskii F A, Zhdan S A, Vedernikov E F. Continuous Spin Detonations[J]. Journal of Propulsion and Power, 2006, 22(6): 1204-1216.
[2] Bykovskii F A, Zhdan S A, Vedernikov E F. Continuous Spin Detonation of Hydrogen-Oxygen Mixtures (1) Annular Cylindrical Combustion[J]. Combustion, Explosion, and Shock Waves, 2008, 44(2): 150-162.
[3] Bykovskii F A, Zhdan S A, Vedernikov E F. Continuous Spin Detonation of Hydrogen-Oxygen Mixtures (2) Combustor with an Expanding Annular Channel[J]. Combustion, Explosion, and Shock Waves, 2008, 44(3): 330-342.
[4] Jason C S. Development and Testing of a Rotating Detonation Engine Run on Hydrogen and Air [D]. Wright-Patterson AFB: Air Force Institute of Technology, 2012.
[5] 刘世杰. 连续旋转爆震波结构、传播模态及自持机理研究 [D]. 长沙:国防科学技术大学, 2012.
[6] 刘世杰, 林志勇, 刘卫东, 等. 连续旋转爆震波传播过程研究(II):双波对撞传播模式[J]. 推进技术, 2014, 35(2): 269-275. (LIU Shi-jie, LIN Zhi-yong, LIU Wei-dong, et al. Research on Continuous Rotating Detonation Wave Propagation Process (II): Two-Wave Collision Propagation Mode[J]. Journal of Propulsion Technology, 2014, 35(2): 269-275.)
[7] 刘世杰, 林志勇, 林伟, 等. H2/Air连续旋转爆震波的起爆及传播过程试验[J]. 推进技术, 2012, 33(3): 483-489. (LIU Shi-jie, LIN Zhi-yong, LIN Wei, et al. Experiment on the Ignition and Propagation Process of H2/Air Continuous Rotating Detonation Wave[J]. Journal of Propulsion Technology, 2012, 33(3): 483-489.)
[8] Chao Wang, Weidong Liu, Shijie Liu, et al. Experimental Investigation on Detonation Combustion Patterns of Hydrogen/Vitiated Air within Annular Combustor[J]. Experimental Thermal and Fluid Science, 2015, 66: 269-278.
[9] 刘世杰, 林志勇, 孙明波, 等. 旋转爆震波发动机二维数值模拟[J]. 推进技术, 2010, 31(5): 634-640. (LIU Shi-jie, LIN Zhi-yong, SUN Ming-bo, et al. Two-Dimensional Numerical Simulation of Rotating Detonation Wave Engine[J]. Journal of Propulsion Technology, 2010, 31(5): 634-640.)
[10] 刘世杰, 覃慧, 林志勇, 等. 连续旋转爆震波细致结构及自持机理[J]. 推进技术, 2011, 32(3): 431-436. (LIU Shi-jie, QIN Hui, LIN Zhi-yong, et al. Detailed Structure and Propagating Mechanism Research on Continuous Rotating Detonation Wave[J]. Journal of Propulsion Technology, 2011, 32(3): 431-436.)
[11] Frolov S M, Aksenov V S, Ivanov V S, et al. Large-Scale Hydrogeneair Continuous Detonation Combustor[J]. International Journal of Hydrogen Energy, 2015, 40: 1616-1623.
[12] Bruno Le Naour, Francois Falempin. Recent Experimental Results Obtained on Continuous Detonation Wave Engine[R]. AIAA 2011-2235.
[13] Francois Falempin, Bruno Le Naour. R&T Effort on Pulsed and Continuous Detonation Wave Engines[R]. AIAA 2009-7284.
[14] Zhou Rui, Wang Jian-Ping. Numerical Investigation of Flow Particle Paths and Thermodynamic Performance of Continuously Rotating Detonation Engines[J]. Combustion and Flame, 2012, 159: 3632-3645.
[15] 郑权, 翁春生, 白桥栋. 倾斜环缝喷孔式连续旋转爆轰发动机试验[J]. 推进技术, 2014, 35(4): 570-576. (ZHENG Quan, WENG Chun-sheng, BAI Qiao-dong. Experiment on Continuous Rotating Detonation Engine with Tilt Slot Injector[J]. Journal of Propulsion Technology, 2014, 35(4): 570-576.)
[16] 陈洁, 王栋, 马虎, 等. 轴向长度对旋转爆震发动机的影响[J]. 航空动力学报, 2013, 28(4): 844-849.
[17] 王健平, 周蕊, 武丹. 连续旋转爆轰发动机的研究进展[J]. 实验流体力学, 2015, 29(4): 12-25.
[18] Jan Kindracki. Experimental Research on Rotating Detonation in Liquid Fuel-Gaseous Air Mixtures[J]. Aerospace Science and Technology, 2015, 43: 445-453.
[19] Brandon K Kan, Stephen D Heister. Chamber Volume Effects on Hypergolic Pulse Detonation Rocket Engine [R]. AIAA 2014-3657.
[20] Brandon K Kan, Stephen D Heister. Characterization of Injector Response in a Hypergolic Pulse Detonation Rocket Engine [R]. AIAA 2015-3766.
[21] Yang C, Wu X, Ma H, et al. Experimental Research on Initiation Characteristics of a Rotating Detonation Engine[J]. Experimental Thermal and Fluid Science, 2016, 71: 154-163.(编辑:张荣莉)　　　　　　　　　　　　　*　收稿日期:2017-07-20；修订日期:2017-10-12。基金项目:国家自然科学基金(51506157；11502186；11602086)。通讯作者:严宇,男,博士,高级工程师,研究领域为液体推进剂喷雾燃烧及爆震燃烧。E-mail: yanyunwpu@163.com