微小尺度多循环爆震实验研究

推进技术 ›› 2018, Vol. 39 ›› Issue (9): 2060-2067.

微小尺度多循环爆震实验研究

马鹏飞¹,范玮²,何建男²,张启斌²

西安航空学院飞行器学院，陕西西安 710077,西北工业大学动力与能源学院，陕西西安 710072,西北工业大学动力与能源学院，陕西西安 710072,西北工业大学动力与能源学院，陕西西安 710072

发布日期:2021-08-15
作者简介:马鹏飞，男，硕士，助教，研究领域为微爆震燃烧及推进技术。E-mail: pengfeima12@163.com 通讯作者:范玮，女，博士，教授、博导，研究领域为爆震燃烧。
基金资助:
国家自然科学基金(91641101；51376151；91441201)；西北工业大学博士创新基金(CX201714)；西安航空学院校级基金(2018KY1117)。

Experimental Research on Multi-Cycle De tonations at Micro Scale

School of Aerocraft，Xi’an Aeronautical University，Xi’an 710077，China,School of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China,School of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China and School of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China

Published:2021-08-15

摘要/Abstract

摘要： 为了探索爆震燃烧应用于微型推进器的可行性，进行了微小尺度多循环爆震实验的研究。实验管道采用截面为6mm×6mm，长度为500mm的方型爆震室，氧化剂和燃料分别为40%的富氧空气和乙烯，工作频率范围为1～30Hz。实验中采用高速摄影仪拍摄反应波的传播过程，用压力传感器测量反应波的压力变化。结果表明，工作频率在1～20Hz内时可以成功实现多循环爆震，爆震波离开爆震室的速度约为2500m/s，频率越高，缓燃向爆震转变(Deflagration to Detonation Transition，简称DDT)的距离越长；工作频率为10Hz和20Hz时，同一频率下，不同爆震循环的DDT开始位置不同，并且DDT距离也存在差异；工作频率为25Hz和30Hz时，由于混合气填充量的减小，不能形成爆震。

关键词: 微小尺度；爆震；多循环；缓燃向爆震转变

Abstract: To investigate the feasibility of the application of detonation combustion in micro-thruster， experiments were carried out on multi-cycle detonations at micro scale. The micro detonation chamber is 500mm in length with a 6mm×6mm rectangular cross-section. Oxygen-enriched air (40% by volume) and ethylene were used as oxidizer and fuel， and the operating frequencies ranged from 1 to 30Hz. High-speed camera was used to capture the propagation process of the reaction waves， whose pressures were measured by piezoelectric transducers. The results showed that， when the operation frequency ranging from 1 to 20Hz， multi-cycle detonation could be successfully obtained， and the detonation waves propagated at approximately 2500m/s before reaching the chamber exit. And the higher the frequency， the longer the DDT distanceis. When operated at 10Hz and 20Hz， both the DDT point and the DDT distance vary in different cycles at the same operation frequency. When the frequency was 25Hz and 30Hz， detonation failed to occur due to the insufficient gas filling and mixing.

Key words: Micro-scale；Detonation；Multi-cycle；Deflagration to detonation transition

马鹏飞,范玮,何建男,张启斌. 微小尺度多循环爆震实验研究[J]. 推进技术, 2018, 39(9): 2060-2067.

MA Peng-fei¹,FAN Wei²,HE Jian-nan²,ZHANG Qi-bin². Experimental Research on Multi-Cycle De tonations at Micro Scale[J]. Journal of Propulsion Technology, 2018, 39(9): 2060-2067.

参考文献

[1] 严传俊, 范玮. 脉冲爆震发动机原理及关键技术 [M]. 西安:西北工业大学出版社, 2005.
[2] Kailasanath K. Recent Developments in the Research on Pulse Detonation Engines[J]. AIAA Journal, 2003, 41(2): 145-159.
[3] Wu M H, Burke M P, Son S F, et al. Flame Acceleration and the Transition to Detonation of Stoichiometric Ethylene/Oxygen in Microscale Tubes[J]. Proceedings of the Combustion Institute, 2007, 31(2): 2429-2436.
[4] Wu M H, Wang C Y. Reaction Propagation Modes in Millimeter-Scale Tubes for Ethylene/Oxygen Mixtures[J]. Proceedings of the Combustion Institute, 2011, 33(2): 2287-2293.
[5] Maruta K, Kataoka T, Kima N, et al. Characteristics of Combustion in a Narrow Channel with a Temperature Gradient[J]. Proceedings of the Combustion Institute, 2005, 30(2): 2429-2436.
[6] Maruta K, Parc J K, Oh K C, et al. Characteristics of Microscale Combustion in a Narrow Heated Channel[J]. Combustion, Explosion, and Shock Waves, 2004, 40(5): 516-523.
[7] Minaev S, Maruta K, Fursenko R. Nonlinear Dynamics of Flame in a Narrow Channel with a Temperature Gradient[J]. Combustion Theory and Modelling, 2007, 11(2): 187-203.
[8] Fan Y, Suzuki Y, Kasagi N. Experimental Study of Micro-Scale Premixed Flame in Quartz Channels[J]. Proceedings of the Combustion Institute, 2009, 32(2): 3083-3090.
[9] Ishii K, Itoh K, Tsuboia T. A Study on Velocity Deficits of Detonation Waves in Narrow Gaps[J]. Proceedings of the Combustion Institute, 2002, 29(2): 2789-2794.
[10] Jackson S I. Gaseous Detonation Initiation Via Wave Implosion[D]. USA: California Institute of Technology, 2005.
[11] Manzhalei V I. Low-Velocity Detonation Limits of Gseous Mixtures[J]. Combustion, Explosion, and Shock Waves, 1999, 35(3): 89-96.
[12] Gao Y, Lee J H S, Ng H D. Velocity Fluctuation Near the Detonation Limits[J]. Combustion and Flame, 2014, 161(11): 2982-2990.
[13] Starr A, Lee J H S, Ng H D. Detonation Limits in Rough Walled Tubes[J]. Proceedings of the Combustion Institute, 2015, 35(2): 1989-1996.
[14] 卢杰, 郑龙席, 王治武, 等. 多管脉冲爆震发动机压力反传特性试验与数值研究[J]. 推进技术, 2014, 35(11): 1558-1565. (LU Jie, ZHENG Long-xi, WANG Zhi-wu, et al. Experimental and Numerical Investigation on Propagation of Back-PressureWaves of a Four-Tube Pulse Detonation Engine[J]. Journal of Propulsion Technology, 2014, 35(11): 1558-1565.)
[15] 王永佳, 范玮, 高瞻, 等. 脉冲爆震火箭发动机引射模态的起爆实验研究[J]. 推进技术, 2013, 34(8): 1147-1152. (WANG Yong-jia, FAN Wei, GAO Zhan, et al. Experimental Investigation on Initiation in Main Detonation Chamber at Ejector Mode of a PDRE[J]. Journal of Propulsion Technology, 2013, 34(8): 1147-1152.)
[16] 严宇, 杨岸龙, 范玮, 等. 脉冲爆震发动机部分填充效应理论分析[J]. 推进技术, 2015, 36(8): 1361-1368. (YAN Yu, YANG An-long, FAN Wei, et al. Theoretical Analysis of Partial-Filling Effect of Pulse Detonation Engine[J]. Journal of Propulsion Technology, 2015, 36(8): 1361-1368.)
[17] Wu M H, Lu T H. Development of a Chemical Microthruster Based on Pulsed Detonation[J]. Journal of Micromechanics and Microengineering, 2012, 22(10): 105040-105049.
[18] 何建男, 范玮, 肖强, 等. 六毫米内径管道中的单次爆震实验研究[J]. 推进技术, 2014, 35(12): 1722-1728. (HE Jian-nan, FAN Wei, XIAO Qiang, et al. Experimental Research on Single-Cycle Detonation in Tubes with an Inner Diameter of 6 Millimeters[J]. Journal of Propulsion Technology, 2014, 35(12): 1722-1728.)(编辑:梅瑛)　　　　　　　　　　　　　*　收稿日期:2017-12-07；修订日期:2018-02-06。基金项目:国家自然科学基金(91641101；51376151；91441201)；西北工业大学博士创新基金(CX201714)；西安航空学院校级基金(2018KY1117)。作者简介:马鹏飞,男,硕士,助教,研究领域为微爆震燃烧及推进技术。E-mail: pengfeima12@163.com通讯作者:范玮,女,博士,教授、博导,研究领域为爆震燃烧。E-mail: weifan419@nwpu.edu.cn