超临界环境下煤油替代物液滴燃烧特性数值研究

doi:10.13675/j.cnki. tjjs. 190002

推进技术 ›› 2019, Vol. 40 ›› Issue (11): 2537-2545.DOI: 10.13675/j.cnki. tjjs. 190002

超临界环境下煤油替代物液滴燃烧特性数值研究

吴海龙¹,聂万胜¹,郑直¹,何博¹

航天工程大学宇航科学与技术系，北京 101416

发布日期:2021-08-15
作者简介:吴海龙，硕士生，研究领域为煤油液滴蒸发燃烧仿真。E-mail：hailong408@qq.com
基金资助:
国家自然科学基金 51876219国家自然科学基金（51876219）。

Numerical Investigation on Combustion Characteristics of Kerosene Surrogate Droplet in Supercritical Environment

Department of Aerospace Science and Technology,Space Engineering University,Beijing 101416,China

Published:2021-08-15

摘要/Abstract

摘要： 为研究液氧/煤油火箭发动机燃烧室内经喷注形成的煤油液滴的燃烧过程，基于实际气体状态方程、高压热物性修正、高压气液平衡和详细化学反应动力学，建立一维的全瞬态液滴燃烧模型，对超临界环境下两组分煤油替代物液滴的燃烧特性及液滴初始直径的影响进行仿真研究。结果表明，在超临界环境下，相比于煤油液滴纯蒸发过程，煤油液滴燃烧过程的迁移时刻大大提前；煤油液滴着火之后很快进入超临界燃烧阶段，此时液滴燃烧过程可以看成中心附近的燃料高浓度区与外侧氧气高浓度区之间的扩散燃烧过程；煤油液滴的火焰半径先增大，达到最大值之后开始减小，并减小为零，火焰温度在着火之后快速上升至最大值，并基本保持不变，在火焰半径减小为零之后开始降低；随着液滴初始直径的增大，火焰特性以及液滴中心参数变化曲线趋势不变、整体延迟，着火时间、迁移时间和液滴寿命增大。

关键词: 煤油替代物;液滴;超临界环境;燃烧特性;数值仿真

Abstract: To study the combustion process of kerosene droplet which was injected into the combustion chamber of LOX/kerosene rocket engine, based on the equation of state for actual gases, the correction of thermal physical properties under high pressure, vapor-liquid equilibrium under high pressure and detailed chemical-kinetic mechanisms, a one-dimensional transient droplet combustion model was established. The model was used to simulate the combustion characteristics and the influence of the initial droplet diameter of the bicomponent kerosene surrogate droplet in supercritical environment. The results show that, in supercritical environment, the migration time of combustion for kerosene droplet is much earlier than that of pure evaporation. The kerosene droplet enters the supercritical combustion stage soon after ignition and the droplet combustion process can be regarded as the diffusion combustion process between the high concentration of fuel near the center and the high concentration of oxygen outside. The flame radius of kerosene droplet first increases, and then decreases to zero after reaching the maximum. The flame temperature rises rapidly to the maximum after ignition, then almost keeps steady, and finally reduced after the flame radius decreases to zero. With the increase of initial droplet diameter, the variation tendency of flame characteristic and droplet center parameter is almost unchanged, only overall delay. The ignition time, migration time and droplet life increase as the initial diameter of the droplet increases.

Key words: Kerosene surrogate;Droplet;Supercritical environment;Combustion characteristic;Numerical simulation

吴海龙,聂万胜,郑直,何博. 超临界环境下煤油替代物液滴燃烧特性数值研究[J]. 推进技术, 2019, 40(11): 2537-2545.

WU Hai-long¹,NIE Wan-sheng¹,ZHENG Zhi¹,HE Bo¹. Numerical Investigation on Combustion Characteristics of Kerosene Surrogate Droplet in Supercritical Environment[J]. Journal of Propulsion Technology, 2019, 40(11): 2537-2545.

参考文献

[1] 邢继发, 刘国球，黄坚定，等. 世界导弹与航天发动机大全[M]. 北京:军事科学出版社， 1999.
[2] 杨涛，方丁酉，唐乾刚. 火箭发动机燃烧原理[M]. 长沙: 国防科技大学出版社， 2008.
[3] Sirignano W A. Fluid Dynamics and Transport of Droplets and Sprays (Second Edition)[M]. New York: Cambridge University Press， 2010.
[4] Jun'ichi Sato， Mitsuhiro Tsue， Mario Niwa， et al. Effects of Natural Convection on High-Pressure Droplet Combustion[J]. Combustion and Flame， 1990， 82(2): 142-150.
[5] 张蒙正，徐胜利. 超临界环境下煤油和UDMH单滴燃烧现象[J]. 火箭推进， 2013， 39(5): 1-6.
[6] Ma Z， Li Y， Li Z， et al. Evaporation and Combustion Characteristics of Hydrocarbon Fuel Droplet in Sub- and Super-Critical Environments[J]. Fuel， 2018， 220: 763-768.
[7] Shuen J S， Yang V， Hsiao C C. Combustion of Liquid-Fuel Droplet in Supercritical Conditions[J]. Combustion and Flame， 1992， 89(4): 299-319.
[8] Hsieh K C， Shuen J S， Yang V. Droplet Vaporization in High Pressure Environments near Critical Conditions [J]. Combustion Science and Technology， 1991， 76(3): 111-132.
[9] 孙凤贤，李磊. 相对静止热环境中正庚烷液滴的蒸发燃烧数值模拟[C]. 西安:中国工程热物理学会燃烧学学术会议， 2008.
[10] 孙凤贤，夏新林，沈淳，等. 非等温液滴蒸发燃烧的传热传质特性[J]. 工程热物理学报， 2010， 31(8): 1403-1406.
[11] 王宏楠，何旭，鹿盈盈. 超临界环境条件对碳氢燃料液滴燃烧特性的影响[J]. 工程热物理学报， 2015， 36(8): 1815-1819.
[12] Ruszalo R. Modeling of Ignition of Liquid Hydrocarbon Droplets at High Pressure[D]. Ottawa: The University of Ottawa， 1990.
[13] 何鹏. 超临界环境下燃料液滴蒸发及其影响因素研究[D]. 北京：北京航空航天大学， 2010.
[14] Ferraris G B， Manca D. BzzOde: A New C++ Class for the Solution of Stiff and Non-Stiff Ordinary Differential Equation Systems[J]. Computers & Chemical Engineering， 1998， 22(11): 1595-1621.
[15] Ferraris G B. BzzMath: Numerical Libraries in C++［EB/OL］. https://super.chem.polimi.it/downloadfiles/3235， 2015 -07-07.
[16] 周舟，范玮，靳乐，等. 单个RP-3航空煤油液滴的超临界蒸发实验研究[J]. 推进技术， 2016， 37 (8): 1422-1430.
[17] 王慧汝. RP-3航空煤油详细化学反应机理初步研究[J]. 燃气涡轮试验与研究， 2015， 28(5): 19-23.
[18] Honnet S， Seshadri K， Niemann U， et al. A Surrogate Fuel for Kerosene[J]. Proceedings of the Combustion Institute， 2009， 32: 485-492.
[19] Poling B E， Prausnitz J M， O’Connell J P. The Properties of Gases and Liquids[M]. New York: MCGRAW- HILL， 2001.
[20] 童景山，李敬. 流体热物理性质的计算[M]. 北京: 清华大学出版社， 1982.
[21] Lee H， Thodos G. Generalized Treatment of Self-Diffusivity for the Gaseous and Liquid States of Fluids[J]. Industrial & Engineering Chemistry Fundamentals， 1983， 22(1): 17-26.
[22] Chueh P L， Prausnitz J M. Vapor- Liquid Equilibria at High Pressures: Calculation of Critical Temperatures， Volumes and Pressures of Nonpolar Mixtures[J]. AICHE Journal， 1967， 13(6): 1107-1113.
[23] Cuoci A， Mehl M， Ferraris G B， et al. Autoignition and Burning Rates of Fuel Droplets under Microgravity[J]. Combustion and Flame， 2005， 143(3): 211-226.
[24] Westbrook C K， Pitz W J， Herbinet O， et al. A Comprehensive Detailed Chemical Kinetic Reaction Mechanism for Combustion of n-Alkane Hydrocarbons from n-Octane to n-Hexadecane[J]. Combustion and Flame， 2008， 156 (1): 181-199.

超临界环境下煤油替代物液滴燃烧特性数值研究

Numerical Investigation on Combustion Characteristics of Kerosene Surrogate Droplet in Supercritical Environment

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 0

编辑推荐

Metrics

本文评价