跟踪微分器在变流量燃气发生器上的应用研究

推进技术 ›› 2019, Vol. 40 ›› Issue (5): 1153-1168.

跟踪微分器在变流量燃气发生器上的应用研究

柴金宝¹,陈雄¹,何坤²,周景亮¹,李旭东¹

南京理工大学机械工程学院，江苏南京 210094,南京理工大学机械工程学院，江苏南京 210094,中国航天科技集团公司四川航天系统工程研究所，四川成都 610100,南京理工大学机械工程学院，江苏南京 210094,南京理工大学机械工程学院，江苏南京 210094

发布日期:2021-08-15
作者简介:柴金宝，硕士生，研究领域为固冲发动机燃气流量调节技术。E-mail: 654991492@qq.com 通讯作者:陈雄，博士，教授，研究领域为航空宇航推进理论与工程。
基金资助:
国家自然科学基金(51606098)；江苏省自然科学基金(BK20140772)。

Research on Tracking Differentiator for Variable Flow Gas Generator

School of Mechanical Engineering，Nanjing University of Science and Technology，Nanjing 210094，China,School of Mechanical Engineering，Nanjing University of Science and Technology，Nanjing 210094，China,Systems Engineering Institute of Sichuan Aerospace，China Aerospace Science and Technology Corporation， Chengdu 610100，China,School of Mechanical Engineering，Nanjing University of Science and Technology，Nanjing 210094，China and School of Mechanical Engineering，Nanjing University of Science and Technology，Nanjing 210094，China

Published:2021-08-15

摘要/Abstract

摘要： 变流量固冲发动机(VFDR)工作时，常采用PID控制器控制燃气发生器内燃气压强。对于阶跃或方波形式的压力指令，往往由于误差信号的突变使执行机构瞬时输出的控制力过大，产生较大的燃气压强超调与燃气流量负调，严重影响了控制系统的性能。为解决上述问题，在常规的PID控制器基础上，引入跟踪微分器(TD)给压力指令信号合理地安排一个快速无超调的过渡过程并提取微分信号。然后令燃气压强跟踪这个安排的过渡过程，使压强达到期望值。通过对变流量燃气发生器的非线性模型进行仿真试验，结果表明:相比于PID控制器，无论压力指令在高或低压强范围内，所提出的控制器均具有更高的稳态精度和快速性，压强的超调量不超过3.7%，响应时间在1s以内。此外，该控制器在抑制燃气流量的负调量上展现了巨大的优势，可将最大负调量减小2.7～3.25倍，显著地提升了VFDR的性能。

关键词: 变流量固冲发动机；燃气发生器；跟踪微分器；安排过渡过程；闭环控制；流量负调

Abstract: PID controller is often used to control gas pressure of gas generator when variable flow ducted rocket (VFDR) works. The pressure instruction in the form of step or square wave often makes instantaneous output control force of actuator too large due to the mutation of error signal， and produce larger overshoot of gas pressure and anti-regulation of gas flow， which seriously affect the performance of control system. In order to solve this problem， the tracking differentiator (TD) was introduced to arrange a rapid and no-overshoot transient process to pressure instruction signal and extracted differential signal based on conventional PID controller. Then gas pressure was traced to the transient process so that the pressure reached expected value. The nonlinear model of a variable flow gas generator was simulated. Simulation results show: compared with PID controller， this controller has higher steady-state accuracy and speediness in both high and low pressure range and the overshoot of pressure is below 3.7%， the response time is within 1s. In addition， this controller shows great advantage in reducing anti-regulation of gas flow. It can reduce anti-regulation about 2.7～3.25 times and significantly improves the performance of VFDR. So it has an important engineering application prospect.

Key words: Variable flow ducted rocket；Gas generator；Tracking differentiator；Arrange transient process；Close-loop control；Flow anti-regulation

柴金宝,陈雄,何坤,周景亮,李旭东. 跟踪微分器在变流量燃气发生器上的应用研究[J]. 推进技术, 2019, 40(5): 1153-1168.

CHAI Jin-bao¹,CHEN Xiong¹,HE Kun²,ZHOU Jing-liang¹,LI Xu-dong¹. Research on Tracking Differentiator for Variable Flow Gas Generator[J]. Journal of Propulsion Technology, 2019, 40(5): 1153-1168.

参考文献

[1] Nakayama H, Ikegami Y, Yoshida A.Full-Scale Firing Tests of Variable Flow Ducted Rocket Engines Employing GAP Solid Fuel Gas Generator[R]. AIAA 2009-5121.
[2] Fry R S. A Century of Ramjet Propulsion Technology Evolution[J]. Journal of Propulsion and Power, 2004, 20(1): 27-58.
[3] Pinto P C, Kurth G. Robust Propulsion Control in all Flight Stages of a Throttleable Ducted Rocket[R]. AIAA 2011-5611.
[4] MacInnis D V. Effects of Gas Generator Burn Rate Variability on Variable Flow Ducted Rocket Design and Performance[R]. AIAA 2012-3828.
[5] 魏祥庚, 李娜, 李江, 等. 涡流阀固体变推力发动机控制流参数影响规律研究[J]. 推进技术, 2017, 38(6): 1235-1240. (WEI Xiang-geng, LI Na, LI Jiang, et al. Research on Influence Law of Vortex Value SRM Thrust Modulation Affected by Control Flow Parameters[J]. Journal of Propulsion Technology, 2017, 38(6): 1235-1240.)
[6] Lee J H, Kim Y C, Park S H, et al. A Study on the Performance Characteristics of Blunt Body Pintle Nozzle[R]. AIAA 2013-4080.
[7] 龚晰, 何保成, 刘志明. 固体火箭冲压发动机发展与流量调节现状[J]. 飞航导弹, 2015(2):74-78.
[8] 霍东兴, 闫大庆, 高波. 可变流量固体冲压发动机技术研究进展与展望[J]. 固体火箭技术, 2017, 40(1): 7-15.
[9] Lee J H, Park B H, Yoon W. Parametric Investigation of the Pintle-Perturbed Conical Nozzle Flows[J]. Aerospace Science and Technology, 2013, 26(1): 268-279.
[10] 王佳兴, 魏志军, 王宁飞. 高燃温喉栓式变推力固体火箭发动机试验[J]. 推进技术, 2012, 33(1): 89-92.(WANG Jia-xing, WEI Zhi-jun, WANG Ning-fei. High Burning Temperature Experiment on Pintle Controlled Solid Motor[J]. Journal of Propulsion Technology, 2012, 33(1): 89-92.)
[11] NIU W Y, Bao W, Chang J T, et al. Control System Design and Experiment of Needle-Type Gas Regulating System for Ducted Rocket[J]. Journal of Aerospace Engineering, 2010, 224(5): 563-573.
[12] Bao W, Li B, Chang J T. Switching Control of Thrust Regulation and Inlet Buzz Protection for Ducted Rocket[J]. Acta Astronautica, 2010, 67(7–8): 764-773.
[13] 刘源翔, 姚晓先, 聂聆聪, 等. 一种流量可调燃气发生器压强控制算法的研究[J]. 固体火箭技术, 2014, 37(1): 43-46.
[14] 聂聆聪, 刘志明, 刘源翔. 流量可调燃气发生器压力闭环模糊控制算法[J]. 推进技术, 2013, 34(4): 551-556. (NIE Ling-cong, LIU Zhi-ming, LIU Yuan-xiang. Pressure Close Loop Fuzzy Control Method of a Flow Adjustable Gas Generator[J]. Journal of Propulsion Technology, 2013, 34(4): 551-556.)
[15] 何坤, 陈雄, 郑健, 等. 模糊PI控制算法在燃气发生器上的应用[J]. 推进技术, 2017, 38(8):1878-1884. (HE Kun, CHEN Xiong, ZHENG Jian, et al. Fuzzy PI Control Algorithm for Gas Generator[J]. Journal of Propulsion Technology, 2017, 38(8): 1878-1884.)
[16] 刘源翔, 聂聆聪, 张皎, 等. 基于线性自抗扰控制器的燃气流量可调发生器压强控制算法研究[J]. 推进技术, 2015, 36(12):1768-1773. (LIU Yuan-xiang, NIE Ling-cong, ZHANG Jiao, et al. Research on Pressure Control Algorithm of a Flow Adjustable Gas Generator Based on Linear Active Disturbance Rejection Control[J]. Journal of Propulsion Technology, 2015, 36(12): 1768-1773.)
[17] 柴金宝, 陈雄, 余业辉, 等. 基于Fuzzy-PI双模控制器的燃气发生器压强控制算法研究[J]. 推进技术, 2018, 39(5): 1151-1156. (CHAI Jin-bao, CHEN Xiong, YU Ye-hui, et al. Research on Pressure Control Algorithm of Gas Generator Based on Fuzzy-PI Dual-Mode Controller[J]. Journal of Propulsion Technology, 2018, 39(5): 1151-1156.)
[18] 黄焕袍, 万晖, 韩京清. 安排过渡过程是提高闭环系统“鲁棒性、适应性和稳定性”的一种有效方法[J]. 控制理论与应用, 2001, 18(S1): 89-94.
[19] 韩京清. 自抗扰控制技术——估计补偿不确定因素的控制技术[M]. 北京:国防工业出版社, 2008.
[20] 何勇攀, 陈玉春, 于守志, 等. 固体火箭冲压发动机燃气发生器动态特性影响分析[J]. 航空动力学报, 2017, 32(1): 227-232.
[21] Bauer C, Davenne F, Hopfe N, et al. Modeling of a Throttleable Ducted Rocket Propulsion System[R]. AIAA 2011-5610.
[22] 杨石林, 高波, 董新刚. 滑盘式流量调节燃气发生器动态特性分析[J]. 固体火箭技术, 2009, 32(5):506-510.
[23] 聂聆聪, 张政伟, 李岩. 燃气发生器压力闭环波动描述函数分析方法研究[J]. 推进技术, 2016, 37(3):540-545. (NIE Ling-cong, ZHANG Zheng-wei, LI Yan. Research of Describing Function Method on Gas Generator Pressure Closed-Loop Oscillation[J]. Journal of Propulsion Technology, 2016, 37(3): 540-545.)
[24] Wilkerson F S, Lucac J T. Variable Flow Solid Propellant Gas Generator for Missile Control Systems[R]. AIAA 81-1464.
[25] 曹军伟, 何国强, 崔金平, 等. 固体火箭冲压发动机燃气流量调节的负调现象[J]. 固体火箭技术, 2015, 38(3): 332-335.
[26] Ma L K, Xia Z X, Hu J X, et al. Investigation on the Anti-regulation Characteristic of Variable Flow Ducted Rocket[J]. Journal of Aerospace Engineering, 2013, 227(9): 1488-1497.
[27] 韩京清. 自抗扰控制器及其应用[J]. 控制与决策, 1998, 13(1): 19-23.
[28] 高志强. 自抗扰控制思想探究[J]. 控制理论与应用, 2013, 30(12): 1498-1510.
[29] 郭赣, 朱熙. 基于过渡过程安排的PID控制器设计[J]. 宇航学报, 2012, 33(7): 930-935.
[30] 武俊峰, 刘亮亮, 仲小虎. 带有跟踪微分器的无模型自适应控制[J]. 电机与控制学报, 2007, 11(5): 547-550.(编辑:史亚红)　　　　　　　　　　　　　　收稿日期:2018-04-12；修订日期:2018-05-21。基金项目:国家自然科学基金(51606098)；江苏省自然科学基金(BK20140772)。作者简介:柴金宝,硕士生,研究领域为固冲发动机燃气流量调节技术。E-mail: 654991492@qq.com通讯作者:陈雄,博士,教授,研究领域为航空宇航推进理论与工程。E-mail: chenxiong@njust.edu.cn