Acoustic Emission Data Reduction Technique of
Inter-Shaft Bearing with Fault Based on Peak
Hold Down Sample Algorithm

Journal of Propulsion Technology ›› 2018, Vol. 39 ›› Issue (5): 1157-1163.

• Test,Experiment and Control • Previous Articles Next Articles

Acoustic Emission Data Reduction Technique of Inter-Shaft Bearing with Fault Based on Peak Hold Down Sample Algorithm

School of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China,Liaoning Key Laboratory of Advanced Measurement and Test Technology for Aviation Propulsion System，Shenyang Aerospace University，Shenyang 110136，China,School of Power and Energy，Northwestern Polytechnical University，Xi’an 710072，China,Liaoning Key Laboratory of Advanced Measurement and Test Technology for Aviation Propulsion System，Shenyang Aerospace University，Shenyang 110136，China and Liaoning Key Laboratory of Advanced Measurement and Test Technology for Aviation Propulsion System，Shenyang Aerospace University，Shenyang 110136，China

Published:2021-08-15

基于峰值保持降采样算法的中介轴承故障声发射数据缩减技术

田晶¹,艾延廷²,赵明¹,张凤玲²,王志²

西北工业大学动力与能源学院，陕西西安 710072,沈阳航空航天大学辽宁省航空推进系统先进测试技术重点实验室，辽宁沈阳 110136,西北工业大学动力与能源学院，陕西西安 710072,沈阳航空航天大学辽宁省航空推进系统先进测试技术重点实验室，辽宁沈阳 110136,沈阳航空航天大学辽宁省航空推进系统先进测试技术重点实验室，辽宁沈阳 110136

作者简介:田晶，男，博士生，工程师，研究领域为航空发动机强度、振动及可靠性。
基金资助:
国家自然科学基金(51675351)；中航工业产学研(cxy2012sh17)。

Abstract

Abstract: In order to solve the problems of large amount of data and difficulty in analysis and storage of acoustic emission signals， a data reduction technique based on peak hold down sampling (PHDS) and spectral kurtosis (SK) algorithm is proposed. The double rotor test rig is used to simulate the outer ring fault of the inter-shaft bearing， and the acoustic emission signal is collected. At the same time， the dynamic model is established to simulate the outer ring fault. PHDS-SK technology is used to reduce the experimental and simulation results. The results show that the experimental and simulated signal data are reduced to 1/1250 and 1/400 of the original data respectively. The periodic impulse characteristics of the inter-shaft bearing fault are retained while the fault signal data is reduced. The outer ring fault frequency of the inter-shaft bearing is extracted accurately.

Key words: Peak hold；Inter-shaft bearing；Aacoustic emission；Data reduction；Spectral kurtosis

摘要： 针对声发射信号数据量大、分析和保存困难的缺点，提出一种峰值保持降采样(PHDS)和谱峭度(SK)算法相结合的声发射信号数据缩减技术。采用双转子试验台开展中介轴承外圈故障模拟实验并采集声发射信号。同时，建立动力学模型对外圈故障进行数值仿真。利用PHDS-SK技术对实验和仿真结果进行数据缩减。结果表明:实验和仿真信号数据量分别缩减为原始数据的1/1250和1/400，故障信号数据缩减的同时保留了中介轴承外圈故障的周期冲击特征，并在缩减后的信号中准确提取出中介轴承外圈故障频率。

关键词: 峰值保持；中介轴承；声发射；数据缩减；谱峭度

TIAN Jing¹,AI Yan-ting²,ZHAO Ming¹,ZHANG Feng-ling²,WANG Zhi². Acoustic Emission Data Reduction Technique of Inter-Shaft Bearing with Fault Based on Peak Hold Down Sample Algorithm[J]. Journal of Propulsion Technology, 2018, 39(5): 1157-1163.

田晶,艾延廷,赵明,张凤玲,王志. 基于峰值保持降采样算法的中介轴承故障声发射数据缩减技术[J]. 推进技术, 2018, 39(5): 1157-1163.

References

[1] 廖明夫, 马振国, 刘永泉, 等. 航空发动机中介轴承的故障特征与诊断方法[J]. 航空动力学报, 2013, 28(12): 2752-2758.
[2] 艾延廷, 陈潮龙, 田晶, 等. 基于信息熵距和 FSVM 隶属度的转子振动状态评估方法[J]. 推进技术, 2013, 34(11): 1543-1548. (AI Yan-ting, CHEN Chao-long, TIAN Jing. et al. Studies on Assessing Method of Rotor Vibration State Based on Information Entropy Distance and FSVM Membership[J]. Journal of Propulsion Technology, 2013, 34(11): 1543-1548.)
[3] 费成巍, 白广忱, 李晓颖. 基于过程功率谱熵SVM的转子振动故障诊断方法[J]. 推进技术, 2012, 33(2): 293-298. (FEI Cheng-wei, BAI Guang-chen, LI Xiao-ying. Method of Rotor Vibration Fault Diagnosis from Process Power Spectrum Entropy and SVM[J]. Journal of Propulsion Technology, 2012, 33(2): 293-298.)
[4] 郝如江, 褚福磊, 张新明. 基于小波变换的滚动轴承故障声发射信号提纯技术[J]. 振动与冲击, 2006, 8(25): 335-337.
[5] Qu Y, He D, Yoon J, et al. Gearbox Tooth Cut Fault Diagnostics Using Acoustic Emission and Vibration Sensors-a Comparative Study[J]. Sensors, 2014, 14(1): 1372-1393.
[6] Hecke B V, Qu Y, He D, et al. A New Spectral Average-Based Bearing Fault Diagnostic Approach[J]. Journal of Failure Analysis and Prevention, 2014, 14(3):354-362.
[7] Hecke B V, Yoon J, He D. Low Speed Bearing Fault Diagnosis Using Acoustic Emission Sensors[J]. Applied Acoustics, 2016, 105: 35-44.
[8] 张斌, 王彤, 谷传纲, 等. 基于小波分析的湍流采样数据量缩减算法[J]. 上海交通大学学报, 2008, 42(11): 1896-1899.
[9] 王实, 王晖, 高文. 格子机数据挖掘方法[J]. 计算机学报, 2000, 23(6): 570-575.
[10] Robinson J C, Vanvoorhis B, Miller W. Machine Fault Detection Using Vibration Signal Peak Detector[P]. US: 5895857A, 1999.
[11] Robinson J C, Piety K R. PeakVue Analysis, New Methodology for Bearing Fault Detection[J]. Sound and Vibration, 1996, 30: 22-25.
[12] Lin T R, Kim E, Tan A C. A Practical Signal Processing Approach for Condition Monitoring of Low Speed Machinery Using Peak-Hold-Down-Sample Algorithm[J].Mechanical Systems and Signal Processing, 2013, 36(2): 256-270.
[13] 刘国华. 声发射信号处理关键技术研究[D]. 杭州:浙江大学, 2008.
[14] Dwyer R. Detection of non-Gaussian Signals by Frequency Domain Kurtosis Estimation[C]. USA: IEEE International Conference on Acoustics, Speech, and Signal Processing, 2003.
[15] Antoni J. Fast Computation of the Kurtogram for the Detection of Transient Faults[J]. Mechanical Systems and Signal Processing, 2007, 21(1): 108-124.
[16] Patil M S, Mathew J, Rajendrakumar P K, et al. A Theoretical Model to Predict the Effect of Localized Defect on Vibrations Associated with Ball Bearing[J]. International Journal of Mechanical Sciences, 2010, 52(9): 1193-1201.(编辑:史亚红)　　　　　　　　　　　　　*　收稿日期:2017-04-11；修订日期:2017-05-31。基金项目:国家自然科学基金(51675351)；中航工业产学研(cxy2012sh17)。作者简介:田晶,男,博士生,工程师,研究领域为航空发动机强度、振动及可靠性。E-mail: tianjing@188.com

Acoustic Emission Data Reduction Technique of Inter-Shaft Bearing with Fault Based on Peak Hold Down Sample Algorithm

基于峰值保持降采样算法的中介轴承故障声发射数据缩减技术

PDF

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 0

Recommended Articles

Metrics

Comments