Investigation of Flow Rate Characteristics of Coal

Journal of Propulsion Technology ›› 2016, Vol. 37 ›› Issue (8): 1515-1521.

• Combustion , Heat and Mass Transfer • Previous Articles Next Articles

Investigation of Flow Rate Characteristics of Coal

School of Aerospace，Tsinghua University，Beijing 100084，China; Beijing Research Institute of Aviation Oil，Beijing 100076，China,School of Aerospace，Tsinghua University，Beijing 100084，China,School of Aerospace，Tsinghua University，Beijing 100084，China,School of Aerospace，Tsinghua University，Beijing 100084，China,School of Aerospace，Tsinghua University，Beijing 100084，China and Beijing Research Institute of Aviation Oil，Beijing 100076，China

Published:2021-08-15

煤液化油在雾化过程中的流量特性研究

李辉^1,2,龚景松¹,朴英¹,陆奇志¹,刘海¹,崔健²

清华大学航天航空学院，北京 100084; 北京航空油料技术开发中心，北京 100076,清华大学航天航空学院，北京 100084,清华大学航天航空学院，北京 100084,清华大学航天航空学院，北京 100084,清华大学航天航空学院，北京 100084,北京航空油料技术开发中心，北京 100076

作者简介:李辉，男，博士生，研究领域为液体燃料的开发与燃烧。E-mail: lhui110@126.com 通讯作者:朴英，女，博士，教授，研究领域为航空发动机推力技术。
基金资助:
国家“八六三”高技术研究发展计划资助项目(2012AA051007);

Abstract

Abstract: In order to study the atomization performance of coal liquefied oil in the aero-engine，the pressure-swirl atomizer was employed to test the mass flow rate，spray cone angle and radial fuel distribution at different fuel injection pressure and the results were compared with results from RP-3 jet fuel. The experimental results show that the mass flow rate of coal liquefied oil is 4.24% higher than that of RP-3 jet fuel as the fuel injection pressure within 1.8MPa. When the fuel injection pressure is more than 1.8MPa，the mass flow rates of two fuels are close to each other. The spray cone angle of coal liquefied oil increases with increasing the fuel injection pressure up to around 0.8MPa and above it keeps the value about 99°. The spray cone angle of coal liquefied oil is 4° lower than that of RP-3 jet fuel under the same fuel injection pressure. The radial fuel distribution of coal liquefied oil and RP-3 jet fuel are similar，and the heterogeneous degree of distribution is within 10%.

Key words: Coal liquefied oil；Pressure-swirl atomizer；Spray cone angle；Mass flow rate

摘要： 为了考察煤液化油在航空发动机上的雾化特性，利用离心式喷嘴测量了不同燃油压差下煤液化油的质量流量、雾化角和径向流量分布并与RP-3喷气燃料进行了对比。实验结果表明:在燃油压差低于1.8MPa时，煤液化油的质量流量比RP-3喷气燃料平均高出4.24%，继续增大燃油压差，两种燃料的质量流量不断接近。煤液化油的雾化角随着燃油压差的增大有小幅增加，当压差超过0.8MPa后雾化角基本保持在99°左右。在相同的燃油压差下，煤液化油的雾化角比RP-3喷气燃料小4°左右。煤液化油和RP-3喷气燃料的径向流量分布特征基本相同，分布不均度都小于10%。

关键词: 煤液化油；离心式喷嘴；雾化角；质量流量

LI Hui^1,2,GONG Jing-song¹,PIAO Ying¹,LU Qi-zhi¹,LIU Hai¹,CUI Jian². Investigation of Flow Rate Characteristics of Coal[J]. Journal of Propulsion Technology, 2016, 37(8): 1515-1521.

李辉,龚景松,朴英,陆奇志,刘海,崔健. 煤液化油在雾化过程中的流量特性研究[J]. 推进技术, 2016, 37(8): 1515-1521.

References

[1] 陶志平. 代喷气燃料的进展及在我国发展的建议[J]. 石油炼制与化工, 2011, 42(7): 91-96.
[2] 吴春来. 煤炭间接液化技术及其在中国的产业化前景[J]. 煤炭转化, 2003, 26(2): 17-24.
[3] Clifford A M, Petrus N J R. Properties, Characteristics, and Combustion Performance of Sasol Fully Synthetic Jet Fuel[J]. Journal of Engineering for Gas Turbines and Power, 2009, 131 (7): 1-17.
[4] DEF STAN 91-91, Turbine Fuel, Kerosene Type, Jet A-1 NATO Code: F-35 Join Service Designation: AVTUR[S].
[5] ASTM D1655, Standard Specification for Aviation Turbine Fuels[S].
[6] 张玉卓. 神华现代煤制油化工工程建设与运营实践[J]. 煤炭学报, 2011, 36(2): 179-184.
[7] 中国煤化网. 中国十大煤制油项目积极推进[EB/OL]. http://www.chinacoalchem.com, 2014-08-01.
[8] 李军芳, 赵学社, 李文博, 等. 煤直接液化油航空煤油馏分的性质与组分分析[J]. 煤炭转化, 2013, 36(4): 29-31.
[9] 李辉, 龚景松, 朴英, 等. 低功率状态下煤液化油的雾化特性[J]. 清华大学学报(自然科学版), 2014, 54(10): 1310-1315.
[10] Song Chunshan, Eser Semih, Schobert H H, et al. Pyrolytic Degradation Studies of a Coal-Derived and a Petroleum-Derived Aviation Jet Fuel[J]. Energy & Fuels, 1993, 7 (2): 234-243.
[11] Butnark Suchada, Badger M W, Schobert H H, et al. Coal-Based Jet Fuel: Composition, Thermal Stability and Properties[J]. Fuel Chemistry Division Preprints, 2003, 48 (1): 158-161.
[12] Balster Lori M, Corporan Edwin, Dewitt Matthew J, et al. Development of an Advanced, Thermally Stable, Coal-Based Jet Fuel[J]. Fuel Processing Technology, 2008, 89 : 364-378.
[13] 薛艳, 王树雷, 曹文杰, 等. 国产费-托合成燃料用于喷气燃料馏分的试验研究[J]. 石油炼制与化工, 2009, 40(11): 44-47.
[14] 薛艳, 王树雷, 刘婕. 煤直接液化制取喷气燃料原料油的组成分析[J]. 石油学报(石油加工), 2010, 26(Z): 264-266.
[15] 周猛, 庄逢辰. 离心喷嘴雾化特性的理论计算[J]. 推进技术, 1991, 12(4): 36-41. (ZHOU Meng, ZHUANG Feng-chen. Theoretical Analysis on Spray Performance of Centrifugal Spray Nozzle[J]. Journal of Propulsion Technology, 1991, 12(4): 36-41.)
[16] 龚景松, 陆奇志, 何裕昆, 等. 煤液化油的蒸发与着火特性[J]. 燃烧科学与技术, 2014, 20(1): 10-13.
[17] Jones A R. Design Optimization of a Large Pressure-Jet Atomizer for Power Plant[C]. Madison Wis: Proceedings of the 2nd International Conference on Liquid Atomization and Spray System, 1982, 181-185.
[18] Lefebvre A H. Atomization and Sprays[M]. Washington DC: Hemisphere Publishing Corporation, 1989.
[19] 胡传胜, 熊洪亮, 虞先煌. 喷嘴液滴雾化细度和喷雾角测量装置的研究[J]. 能源研究与信息, 2001, 17(4): 225-231.
[20] 何国强, 刘敏华, 肖育民, 等. 边缘检测技术在火箭发动机实验诊断中的应用[J]. 推进技术, 1998, 19(2):105-108. (HE Guo-qiang, LIU Min-hua, XIAO Yu-min, et al. Edge Detection Technique for Experimental Diagnosis in Rocket Motor[J]. Journal of Propulsion Technology, 1998, 19(2): 105-108.)
[21] 甘晓华. 航空燃料汽轮机燃油喷嘴技术[M]. 北京: 国防工业出版社, 2006.(编辑:梅瑛)　　　　　　　　　　　　　*　收稿日期:2015-01-30；修订日期:2015-05-18。基金项目:国家“八六三”高技术研究发展计划资助项目(2012AA051007); 清华大学实验室开放基金资助项目(LF20125028)。作者简介:李辉,男,博士生,研究领域为液体燃料的开发与燃烧。E-mail: lhui110@126.com通讯作者:朴英,女,博士,教授,研究领域为航空发动机推力技术。E-mail: piaoying@mail.tsinghua.edu.cn

Investigation of Flow Rate Characteristics of Coal

煤液化油在雾化过程中的流量特性研究

PDF

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 0

Recommended Articles

Metrics

Comments