叶顶抽吸对叶栅间隙泄漏流动的控制研究

doi:10.13675/j.cnki.tjjs.190585

推进技术 ›› 2020, Vol. 41 ›› Issue (8): 1701-1709.DOI: 10.13675/j.cnki.tjjs.190585

叶顶抽吸对叶栅间隙泄漏流动的控制研究

张博涛，刘波，赵航

西北工业大学动力与能源学院，陕西西安 710129

发布日期:2021-08-15
作者简介:张博涛，博士生，研究领域为叶轮机械气动热力学。E-mail：zhangbo_tao@126.com
基金资助:
国家自然科学基金（51676162；51790512）；国家科技重大专项（2017-II-0001-0013）。

Effects of Blade Tip Suction on Cascade Gap Leakage Flow

School of Power and Energy,Northwestern Polytechnical University,Xi’an 710129,China

Published:2021-08-15

摘要/Abstract

摘要： 为了控制压气机叶尖间隙泄漏流动，减少叶尖泄漏流和泄漏涡对压气机内部流场带来的不利影响，数值模拟研究了在压气机叶栅叶顶位置沿叶片中弧线开槽抽吸对叶尖泄漏流的控制效果，并与端壁流向开槽抽吸方案进行了对比分析。研究结果表明：叶顶抽吸和端壁抽吸直接通过影响叶尖泄漏流的结构形态，减弱间隙泄漏流强度和影响范围，从而提升压气机/叶栅性能。叶顶中游抽吸方案Slot TB对于泄漏流与泄漏涡的控制效果优于叶顶上游抽吸方案Slot TA；而机匣端壁上游抽吸方案Slot CA相较于中游抽吸方案Slot CB对叶顶流场改善效果更佳。叶顶抽吸和端壁抽吸在抽吸量为0.6%时分别可以使总压损失系数下降约3.3%和7.2%。

关键词: 叶顶抽吸;端壁抽吸;叶尖泄漏流;泄漏涡;流动控制技术

Abstract: In order to control the tip leakage flow, and reduce the adverse effects of tip leakage flow and tip leakage vortex on the internal flow field of compressors, the flow control effects of opening suction slots along the direction of the blade tip camber on the tip leakage flow in a compressor cascade were numerically studied. Moreover, a comparative analysis was performed with the endwall suction schemes that slotted in flow direction. The results show that the blade tip suction and endwall suction can weaken the intensity and range of tip leakage flow by directly affecting the structure of the tip leakage flow, thus improve the performance of compressor or cascade. The blade tip midstream suction scheme Slot TB has a better flow control effect on the tip leakage flow and tip leakage vortex than that of the blade tip upstream suction scheme Slot TA. However, the endwall upstream suction scheme Slot CA has a better effect on modifying the tip flow field than that of the endwall midstream suction scheme Slot CB. The total pressure loss coefficients were reduced by 3.3% and 7.2% when the suction amount was 0.6% with the blade tip suction and endwall suction, respectively.

Key words: Blade tip suction;Endwall suction;Tip leakage flow;Leakage vortex;Flow control technique

张博涛，刘波，赵航. 叶顶抽吸对叶栅间隙泄漏流动的控制研究[J]. 推进技术, 2020, 41(8): 1701-1709.

ZHANG Bo-tao, LIU Bo, ZHAO Hang. Effects of Blade Tip Suction on Cascade Gap Leakage Flow[J]. Journal of Propulsion Technology, 2020, 41(8): 1701-1709.

参考文献

[1] Kang S， Hirsch C. Tip Leakage Flow in Linear Compressor Cascade [J]. Journal of Turbomachinery， 1994， 116(4): 657-664.
[2] Storer J A， Cumpsty N A. Tip Leakage Flow in Axial Compressors[J]. Journal of Turbomachinery， 1991， 113(2): 252-259.
[3] Yoon S， Selmeier R， Cargill P， et al. Effect of the Stator Hub Configuration and Stage Design Parameters on Aerodynamic Loss in Axial Compressors[J]. Journal of Turbomachinery， 2015， 137(9).
[4] 卢新根，楚武利，朱俊强，等. 轴流压气机机匣处理研究进展及评述[J]. 力学进展， 2006， 36(2): 222-232.
[5] Chaitanya V H， Yashovardhan S C， Jubin T G， et al. Study of Effects of Rotor Tip Tailoring in Axial Flow Compressors[R]. ASME GT 2015-42520.
[6] Cui W， Xiang X， Zhao Q， et al. The Effect of Sweep on Flowfields of a Highly Loaded Transonic Rotor[J]. Aerospace Science and Technology， 2016， 58: 71-81.
[7] Lu H， Li Q. Cantilevered Stator Hub Leakage Flow Control and Loss Reduction Using Non-Uniform Clearances [J]. Aerospace Science and Technology， 2016， 51: 1-10.
[8] 李应红. 航空等离子体动力学与技术的发展[J]. 航空工程进展， 2011， 2(2): 127-132.
[9] 耿少娟，张宏武，朱俊强，等. 喷气对低速轴流压气机转子叶顶区域流动的影响[J]. 工程热物理学报， 2007, 28(3): 395-398.
[10] Stratford B S. The Prevention of Separation and Flow Reversal in the Corners of Compressor Blade Cascades[J]. The Aeronautical Journal， 1973， 77(749): 249-256.
[11] Loughery R J， Horn R A， Tramm P C. Single Stage Experimental Evaluation of Boundary Layer Blowing and Bleed Techniques for High Lift Stator Blades[R]. NASA CR-54573， 1971.
[12] 刘波，项效镕，南向谊，等. 边界层抽吸对叶栅表面分离流动控制的实验研究[J]. 推进技术， 2009， 30(6): 703-708.
[13] 郭爽，陈绍文，陆华伟，等. 组合抽吸对大转角扩压叶栅性能的影响[J]. 航空动力学报， 2010， 25(12): 2697-2703.
[14] 曹志远. 边界层抽吸对轴流压气机流动控制及性能影响的研究[D]. 西安：西北工业大学， 2014.
[15] 陆华伟，张永超，康达，等. 具有叶顶间隙扩压叶栅边界层抽吸研究[J]. 工程热物理学报， 2016， 37(2): 277-284.
[16] Mao X， Liu B， Tang T. Effect of Casing Aspiration on the Tip Leakage Flow in the Axial Flow Compressor Cascade[J]. Proceedings of the Institution of Mechanical Engineers， Part A: Journal of Power and Energy， 2017， 232(3): 225-239.
[17] Mao X， Liu B， Tang T. Control of Tip Leakage Flow in Axial Flow Compressor Cascade by Suction on the Blade Tip [J]. Journal of Applied Fluid Mechanics， 2018， 11(1): 137-149.
[18] Evans S， Hodson H， Hynes T， et al. Flow Control in a Compressor Cascade at High Incidence[J]. Journal of Propulsion and Power， 2010， 26(4): 828-836.
[19] 左志涛，朱阳历，张冬阳，等. 静叶轮毂间隙对高压压气机气动性能的影响[J]. 推进技术， 2011， 32(3): 329-333.

叶顶抽吸对叶栅间隙泄漏流动的控制研究

Effects of Blade Tip Suction on Cascade Gap Leakage Flow

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 0

编辑推荐

Metrics

本文评价