横向气流中液体射流袋式破碎机理

推进技术 ›› 2012, Vol. 33 ›› Issue (2): 198-204.

横向气流中液体射流袋式破碎机理

王雄辉,黄勇,王方,王少林,刘志林

北京航空航天大学能源与动力工程学院/航空发动机气动热力重点实验室,北京 100191;北京航空航天大学能源与动力工程学院/航空发动机气动热力重点实验室,北京 100191;北京航空航天大学能源与动力工程学院/航空发动机气动热力重点实验室,北京 100191;北京航空航天大学能源与动力工程学院/航空发动机气动热力重点实验室,北京 100191;北京航空航天大学能源与动力工程学院/航空发动机气动热力重点实验室,北京 100191

发布日期:2021-08-15
作者简介:王雄辉(1986—),男,硕士,研究领域为横向射流初始雾化机理。E-mail:wxionghui@gmail.com

Bag Breakup of Round Liquid Jets in Crossflow

National Key Laboratory on Aero-Engines, College of Energy and Power Engineering,Beijing University of Aeronautics and Astronautics,Beijing 100191,China;National Key Laboratory on Aero-Engines, College of Energy and Power Engineering,Beijing University of Aeronautics and Astronautics,Beijing 100191,China;National Key Laboratory on Aero-Engines, College of Energy and Power Engineering,Beijing University of Aeronautics and Astronautics,Beijing 100191,China;National Key Laboratory on Aero-Engines, College of Energy and Power Engineering,Beijing University of Aeronautics and Astronautics,Beijing 100191,China;National Key Laboratory on Aero-Engines, College of Energy and Power Engineering,Beijing University of Aeronautics and Astronautics,Beijing 100191,China

Published:2021-08-15

摘要/Abstract

摘要： 采用高速摄像仪对横向气流场中的液体圆形射流袋式破碎过程进行了实验研究。实验所用喷嘴孔径为1.0mm,实验工质采用水。We_a范围覆盖11~23,液/气动量通量比q覆盖11~95。实验中观察了袋的形成及破碎过程。实验发现,袋的触发长度lonset/d与无量纲数In(q/Re) 存在线性关系,而袋的触发时间则为常数；对袋式结构的进一步研究得出袋的破碎长度与液体射流速度无关,只与We数有关,且成线性关系,即破碎长度随着We数的增加线性减小。最后还给出了核心射流破碎位置与液/气动量通量比q的关系,无量纲化破碎位置横坐标为常数,而无量化破碎位置纵坐标随着In (q)线性增加。以上结果可以指导实际设计合理安排袋的触发、破碎点位置,改善雾化性能；在数值模拟上能帮助构建精确的初始雾化模型,提高模拟精度。

关键词: 液体圆形射流;横向气流;袋式破碎;破碎机理;袋的触发;高速摄像仪

Abstract: An experiment was conducted to investigate bag breakup process of round liquid jets in crossflow. High-speed camera was used to observe the formation and breakup of bags. The diameter of the nozzle used in the experiment was 1.0 mm. And the test liquid was tap water. We number covered the range of 11~23, and liquid-to-air momentum flux ratio varied from 11 to 95. Present results indicate that the dimensionless onset length of bags (lonset/d) is linear to In(q/Re), while the dimensionless onset time is almost a constant. With We increasing, the bag breakup length decreased linearly, and was unrelated to liquid jet velocity. Finally the relationship between jet breakup point and liquid-to-air momentum ratio was studied, and it was found that the breakup position in the stream direction was always the same while the distance in the crossflow direction was increased with In(q) linearly.

Key words: Round liquid jet; Crossflows; Bag breakup; Breakup mechanism; The onset of bags; High-speed camera

王雄辉,黄勇,王方,王少林,刘志林. 横向气流中液体射流袋式破碎机理[J]. 推进技术, 2012, 33(2): 198-204.

参考文献

[2] Wu P K, Kirkendall K A, Fullern R P.Spray Structures of Liquid Fuel Jets Atomized in Subsonic Crossflows [J].Journal of Propulsion and Power, 8,4 (2):173-182.
[3] Becker J, Hassa C.Breakup and Atomization of Kerosene Jet in Crossflow at Elevated Pressure [J]. Atomization and Sprays, 2,1:49-67.
[4] Wu P K, Kirkendall K A, Fuller R P, et al.Breakup Processes of Liquid Jets in Subsonic Crossflows [J].AIAA Journal, 7,3(1):64-73.
[5] Mazallon J, Dai Z, Faeth G M.Aerodynamic Primary Breakup at the Surface of Nonturbulent Round Liquid Jets in Crossflow [C].Reno:36th Aerospace Sciences Meeting and Exhibit, 1998.
[6] Aalburg C, Faeth G M, Sallam K A.Primary Breakup of Round Turbulent Liquid Jets in Uniform Crossflows [C].Reno:43rd AIAA Aerospace Sciences Meeting and Exhibit, 2005.
[7] Aalburg C, Sallam K A, Faeth G M.Properties of Non Turbulent Round Liquid Jets in Uniform Crossflows [C].Reno:42nd AIAA Aerospace Sciences Meeting and Exhibit, 2004.
[8] Zhu Y, Huang Y, Wang F, et al.Experiment on Breakup Processes and Surface Waves of Round Liquid Jets in Crossflows [C].Glasgow:Proceedings of ASME Turbo Expo, 2010.
[9] 朱英,黄勇,王方,等.横向气流中的液体圆形射流破碎实验[J].航空动力学报, 0,5:2261-2266.
[10] Sallam K A, Aalburg C, Faeth G M.Breakup of Round Nonturbulent Liquid Jets in Gaseous Crossflows [C].Reno, Nevada:41st AIAA Aerospace Sciences Meeting and Exhibit, 2003.
[11] Sallam K A, Ng C L, Sankarakrishnan R, et al.Breakup of Turbulent and Non-Turbulent Liquid Jets in Gaseous Crossflows [C].Reno:44th AIAA Aerospace Sciences Meeting and Exhibit, 2006.
[12] Ng C L, Sankarakrishinan R, Sallam K A.Bag Breakup of Nonturbulent Liquid Jets in Crossflow [J]. International Journal of Multiphase Flow, 8,4:241-259.
[13] 朱英,黄勇,郭志辉.液体圆形射流变形破碎及破碎长度实验[C].吉林:冲压发动机技术交流会,2005.
[14] 万云霞,黄勇,朱英.液体圆柱射流破碎过程的实验[J].航空动力学报,2008,23(2):208-214.
[15] Reitz R D, Bracco F V.Mechanism of Atomization of a Liquid Jet [J].Physics of Fluids, 2,5(10):1730-1742.
[16] Ranger A A, Nicholls J A.The Aerodynamic Shattering of Liquid Drops [J].AIAA Journal, 9,7:285-290.
[17] Chou W H, Hsiang L P, Faeth G M.Dynamics of Drop Deformation and Formation During Secondary Breakup in the Bag Breakup Regime [J].AIAA Journal, 7,7:797-815.