C/H/O/N/B体系气相燃烧化学动力学模型及计算研究

推进技术 ›› 2013, Vol. 34 ›› Issue (10): 1376-1381.

C/H/O/N/B体系气相燃烧化学动力学模型及计算研究

刘林林,何国强,王英红

西北工业大学燃烧、热结构与内流场重点实验室,陕西西安 710072;西北工业大学燃烧、热结构与内流场重点实验室,陕西西安 710072;西北工业大学燃烧、热结构与内流场重点实验室,陕西西安 710072

发布日期:2021-08-15
作者简介:刘林林(1984—),男,博士生,研究领域为含硼富燃料推进剂工艺与燃烧机理研究。E-mail:viola7788521@yahoo.com.cn
基金资助:
武器装备预研基金项目(9140c520107110c52)；西北工业大学博士论文创新基金(CX201306)。

Research on Model and Calculation of Chemical Kinetics Model of C/H/O/N/B System

National Key Lab. of Combustion, Thermo-Structure and Flow, Northwestern Polytechnical University, Xi′an 030051, China;National Key Lab. of Combustion, Thermo-Structure and Flow, Northwestern Polytechnical University, Xi′an 030051, China;National Key Lab. of Combustion, Thermo-Structure and Flow, Northwestern Polytechnical University, Xi′an 030051, China

Published:2021-08-15

摘要/Abstract

摘要： 为了更加深入地研究硼粒子的点火和燃烧机理,在Pasternkck和Zhou的模型的基础上,通过补充基元反应和修正基元反应的动力学参数,建立起了新的C/H/O/N/B体系气相燃烧动力学模型,该模型包含31种组分,190个正反基元反应。采用新的模型对贫氧体系气相燃烧过程进行计算,并改变体系的初始温度及压强,研究其对平衡温度和硼的氧化物平衡摩尔分数的影响。计算结果表明:(1)体系平衡后硼元素主要以硼的氧化物形式存在,其中BO和BO₂的摩尔分数随反应时间的增加先升高后降低,B₂O₃的摩尔分数随着反应时间的增加而不断升高。(2)提高初始温度和压强不但能使体系的平衡温度提高,而且能缩短体系达到平衡的时间。(3)提高初始温度会使B₂O₃更多地解离为BO和BO₂,不利于硼燃料能量的完全释放,但提高压强会抵制B₂O₃的解离,从而会在一定程度上提高硼燃料的能量释放。 

关键词: 固体推进剂;化学动力学;燃烧模型;气相 

Abstract: In order to study the ignition and combustion mechanism of boron particle more deeply, a homogenous gas-phase combustion model of C/H/O/N/B system was established based on the model of Pasternkck and Zhou. Some simple reactions were added to the model and some thermodynamic data was revised, and there were 31gas-phase species and 190forward-reverse simple reactions in the model. The gas-phase combustion was calculated for one kind of fuel-rich system by using the new model and the effects of initial temperature and pressure on the temperature of the system and equilibrium mole fraction of boron oxide were studied. The calculation results show that:(1) Boron oxide is the mainly products among all the boride products when the system reaches equilibrium state. Mole fraction of BO and BO_2increases firstly and then decreases, while mole fraction of B₂O_3increases with the reaction time. (2) Increasing the initial temperature and pressure can increase the equilibrium temperature of the system and decrease the equilibrium time. (3) More B₂O_3is dissociated to be BO and BO_2when the initial temperature increases which will do harm for the heat release of the fuel containing boron, while the higher pressure is benefit for the heat release of the fuel containing boron by inhibiting the dissociation of B₂O₃. 

Key words: Solid propellant;Chemical kinetics; Combustion model; Gas-phase

刘林林,何国强,王英红. C/H/O/N/B体系气相燃烧化学动力学模型及计算研究[J]. 推进技术, 2013, 34(10): 1376-1381.

LIU Lin-lin, HE Guo-qiang, WANG Ying-hong. Research on Model and Calculation of Chemical Kinetics Model of C/H/O/N/B System[J]. Journal of Propulsion Technology, 2013, 34(10): 1376-1381.

参考文献

[1] Kenneth K Kuo, Martin Summerfield.Fundamentals of Solid-Propellant Combustion[M].USA:American Institute of Aeronautics and Astronautics, 1984.
[2] Besser H L.Overview of Boron Ducted Rocket Development During the Last Two Decades[J].International Journal of Energetic Materials and Chemical Propulsion, 1993,2(2):133-178.
[3] A Gany, Y M Timant.Advantages and Drawbacks of Boron-Fueled Propulsion [J].Acta Astronautica, 1993,9(3):181-187.
[4] Kubota N, Kuwahara T.Combustion of Energetic Fuel for Ducted Rockets(I)[J].Propellants, Explosives, Pyrotechnics,1991,6(2):51-54．
[5] King M K.A Review of Studies of Boron Ignition and Combustion Phenomena Atlantic Research Corporation over the Past Decade[M].USA:Begell House Publishing Co.and CRC Press,1993:1-81.
[6] Yetter R A,Cho S Y,Dryer F L.Chemical Kinetic Modeling and Sensitivity Analyses for Boron Assisted Hydrocarbon Combustion[C].Pittsburgh: 22nd Symposium(International) on Combustion, The Combustion Institute,1988:919-929.
[7] Brown R C, Kolb C E, Rabitz H, et al.Kinetic Model of Liquid BO Gasification in a Hydrocarbon Combustion :I.Heterogeneous Surface Reaction[J].International Journal of Chemical Kinetics,1991,3(11):957-970.
[8] Pasternack L.Gas-Phase Modeling of Homogeneous Boron/Oxygen/Hydrogen/Carbon Combustion[J].Combustion and Flame,1992,0(3):259-268.
[9] Zhou W, Yetter R A, Dryer F L.A Comprehensive Physical and Numerical Model of Boron Particle Ignition[C].Pittsburgh: 26th Symposium(International) on Combustion, The Combustion Institute,1996:1909-1917.
[10] Zhou W, Yetter R A, Dryer F L.Multi-Phase Model for Ignition and Combustion Ofboron Particles[J].Combustion and Flames,1999,7(1):227-243.
[11] Zhou W.Numerical Study of Multi-Phase Combustion:Ignition and Combustion of aIl Isolated Boron Particle in Fluorinated Environments[D].Candidacy:Princeton University,1998.
[12] Brown R C, Kolb C E,Yetter, et al.Development of a Boron Assisted Combustion Model with Sensitivity Analysis[R].USA:Aerodyne Research, Inc., ARI-RR-580.