直航和回转工况下吊舱推进器水动力性能数值计算方法研究

推进技术 ›› 2016, Vol. 37 ›› Issue (3): 593-600.

• 电推进和其它推进 • 上一篇

直航和回转工况下吊舱推进器水动力性能数值计算方法研究

王展智¹,熊鹰¹,孙海涛²,王睿¹

海军工程大学舰船工程系，湖北武汉 430033,海军工程大学舰船工程系，湖北武汉 430033,国防科学技术大学指挥军官基础教育学院，湖南长沙 410072,海军工程大学舰船工程系，湖北武汉 430033

发布日期:2021-08-15
作者简介:王展智，男，讲师，研究领域为计算流体力学，推进器水动力学。
基金资助:
国家自然科学基金(51479207；51179198)；工信部高技术船舶科研项目(工信部联装[2012]534号)。

Numerical Study on Hydrodynamic Performance of Podded Propulsor in Straight Forward and Steering Conditions

Department of Naval Architecture，Naval University of Engineering，Wuhan 430033，China,Department of Naval Architecture，Naval University of Engineering，Wuhan 430033，China,College of Basic Education for Commanding Officers，National University of Defense Technology， Changsha 410072，China and Department of Naval Architecture，Naval University of Engineering，Wuhan 430033，China

Published:2021-08-15

摘要/Abstract

摘要： 为了探索吊舱推进器在回转工况下的水动力性能变化规律，采用全结构化网格离散计算域，基于RANS方法结合SST[k-ω]湍流模型和滑移网格技术计算了吊舱推进器在直航和回转工况下的水动力性能，并与试验数据进行了对比，进一步详细分析了螺旋桨和吊舱之间的相互干扰作用。结果表明，RANS方法结合全结构化网格可以较精确地预报直航和回转工况下的水动力性能，设计工况下计算值与试验数据的偏差在[±3%]以内；由于螺旋桨与吊舱之间的强烈相互干扰作用，吊舱桨的瞬时推力系数和扭矩系数成周期性变化，波动频率与桨叶数相等；直航状态下，吊舱桨的推力系数和扭矩系数最小，其值随回转角的增大而增大；而吊舱单元的推力系数随回转角的增大而减小；吊舱单元的横向力系数最小，基本上为0，其值随回转角的增大而迅速增大。

关键词: 吊舱推进器；水动力性能；直航工况；回转工况；数值计算

Abstract: In order to investigate unsteady hydrodynamic performance of podded propulsor in steering condition，structured grids were generated to discretize the flow domain，hydrodynamic performances of podded propulsor in straight forward and steering conditions were numerically solved by RANS method combined with SST[k-ω] turbulence model and moving mesh technique. Comparisons were made between numerical results and experimental data，and the interaction between propeller and pod was analyzed in detail. It shows that RANS method combined with structured grids can predict well on hydrodynamic performances of podded propulsor in straight forward and steering conditions，the error between numerical result and experimental data is below [±3%]in design condition. The transient thrust and torque coefficients of podded propeller vary periodically with phase angle due to the interaction between propeller and pod，and the frequency is equal to propeller blade number in a period. In straight forward condition，thrust and torque coefficients of podded propeller are minimum and increase with the increase of steering angle. The thrust coefficient of the podded unit decreases with the increase of steering angle. The transverse force coefficient increases significantly with the increase of steering angle.

Key words: Podded propulsor；Hydrodynamic performance；Straight forward condition；Steering condition；Numerical study

王展智,熊鹰,孙海涛,王睿. 直航和回转工况下吊舱推进器水动力性能数值计算方法研究[J]. 推进技术, 2016, 37(3): 593-600.

WANG Zhan-zhi¹,XIONG Ying¹,SUN Hai-taO²,WANG Rui¹. Numerical Study on Hydrodynamic Performance of Podded Propulsor in Straight Forward and Steering Conditions[J]. Journal of Propulsion Technology, 2016, 37(3): 593-600.

参考文献

[1] 王义波. 双吊舱船舶电力推进航向控制系统研究[D]. 大连:大连海事大学, 2006.
[2] 郭春雨. 吊舱推进器直航以及非设计工况下水动力性能研究[D]. 上海:上海交通大学, 2009.
[3] SHENG Li, XIONG Ying, WANG Song. Experimental Investigations and CFD Validation on the Open-Water Performance of Podded Propulsor[C]. Shanghai: Proceedings of 2011 IEEE International Conference on Computer Science and Automation Engineering, 2011:145-149.
[4] Bal S, Guner M. Performance Analysis of Podded Propulsors[J]. Ocean Engineering, 2009, 36(8): 556-563.
[5] 沈兴荣. 粘性流场中吊舱推进器水动力性能研究[D]. 上海:中国舰船研究院, 2007.
[6] SHEN Xingrong, FENG Xuemei, CAI Rongquan, et al. Study on Hydrodynamic Performance of Podded Propulsion in Viscous Flow[C]. Trondheim: Proceedings of First International Symposium on Marine Propulsors, 2009.
[7] Szantyr J A. Hydrodynamic Model Experiments with Pod Propulsor[J]. Oceanic Engineering International, 2001, 5(2): 95-103.
[8] Friesch J. Cavitation and Vibration Investigations for Podded Drives[C]. Newcastle: Proceedings of the First International Conference on Technological Advances in Podded Propulsion, 2004: 387-399.
[9] Heinke H J. Investigation about the Forces and Moments at Podded Drives[C]. Newcastle: Proceedings of the First International Conference on Technological Advances in Podded Propulsion, 2004: 305-320.
[10] Liu P F, Islam M, Veitch B. Unsteady Hydromechanics of a Steering Podded Propeller Unit[J]. Ocean Engineering, 2009, 36(12): 1003-1014.
[11] Amini H, Sileo L, Steen S. Numerical Calculations of Propeller Shaft Loads on Azimuth Propulsors in Oblique Inflows[J]. Journal of Marine Science and Technology, 2012, 17(4): 403-421.
[12] Shamsi R, Ghassemi H. Numerical Investigation of Yaw Angle Effects on Propulsive Characteristics of Podded Propulsor[J]. International Journal of Naval Architecture Ocean Engineering, 2013, 5(2): 287-301.
[13] SHEN Xingrong, CAI Yuejin. Study on Hydrodynamic Performance of Podded Propulsor at Steering Condition[C]. Tasmania: Proceedings of Third International Symposium on Marine Propulsors, 2013.
[14] 熊鹰, 盛立, 杨勇. 吊舱式推进器偏转工况下水动力性能[J]. 上海交通大学学报, 2013, 47(6):956-961.
[15] 董小倩. 吊舱推进器水动力性能数值研究[D]. 上海:上海交通大学, 2013.
[16] Islam M F, Veitch B, Akinturk A, et al. Experiments with Podded Propulsors in Static Azimuthing Conditions[C]. Newfoundland: Proceedings of the 8th Canadian Marine Hydromechanics and Structures Conference, 2007.

直航和回转工况下吊舱推进器水动力性能数值计算方法研究

Numerical Study on Hydrodynamic Performance of Podded Propulsor in Straight Forward and Steering Conditions

PDF

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 0

编辑推荐

Metrics

本文评价